Aerofoil flow separation suppression using dimples

Flow separation is a source of aerodynamic inefficiency, by using vortex generators flow separation can be controlled. This is of particular benefit to flows around bodies which are susceptible to separated flows, such as bodies in ground effect. Previous studies on the ability of dimples to produce vortices for flow mixing concerned heat transfer applications. Experimental measurements using Laser Doppler Anemometry (LDA) were taken in the wake of the Tyrrell026 aerofoil (Re C = 0-5 x 10 5 ) with a dimple array machined in the surface. Results for a dimple array of three rows placed forward of x/c = 0·23 with 1·5D dimple to dimple spacing, showed significant flow recovery in the wake. The velocity deficit of u/U o,min = ―0·1 recovered to u/U o ,min = 0-3 with the dimple array and the size of the wake reduced by 50%; at α = 10°, h/c = 0·313. The positive effect of the dimple array on the wing reduced as the wing was brought closer to the ground.

[1]  Jongmyung Park,et al.  NUMERICAL PREDICTIONS OF HEAT TRANSFER AND FLUID FLOW CHARACTERISTICS FOR SEVEN DIFFERENT DIMPLED SURFACES IN A CHANNEL , 2005 .

[2]  S. A. Isaev,et al.  Numerical Analysis of the Influence of the Depth of a Spherical Hole on a Plane Wall on Turbulent Heat Exchange , 2003 .

[3]  D. Geropp,et al.  Experimental investigation of the ground effect on the flow around some two-dimensional bluff bodies with moving-belt technique , 1998 .

[4]  M. L. Hill,et al.  Flow structure due to dimple depressions on a channel surface , 2001 .

[5]  G. Mahmood,et al.  Heat transfer in a dimpled channel: combined influences of aspect ratio, temperature ratio, Reynolds number, and flow structure , 2002 .

[6]  S. A. Isaev,et al.  Numerical Analysis of the Effect of Viscosity on the Vortex Dynamics in Laminar Separated Flow Past a Dimple on a Plane with Allowance for Its Asymmetry , 2001 .

[7]  Jonathan Zerihan,et al.  Off-Surface Aerodynamic Measurements of a Wing in Ground Effect , 2003 .

[8]  Ronald Scott Bunker,et al.  Heat Transfer and Friction Factors for Flows Inside Circular Tubes With Concavity Surfaces , 2003 .

[9]  S. Won,et al.  NUMERICAL PREDICTIONS OF FLOW STRUCTURE AND LOCAL NUSSELT NUMBER RATIOS ALONG AND ABOVE DIMPLED SURFACES WITH DIFFERENT DIMPLE DEPTHS IN A CHANNEL , 2004 .

[10]  P. Ligrani,et al.  Flow visualization and flow tracking as applied to turbine components in gas turbine engines , 2000 .

[11]  P. Bearman,et al.  Golf Ball Aerodynamics , 1976 .

[12]  S. A. Isaev,et al.  Modeling of the Influence of Viscosity on the Tornado Heat Exchange in Turbulent Flow around a Small Hole on the Plane , 2002 .

[13]  J. W van der Burg,et al.  Low speed maximum lift and flow control , 2004 .

[14]  R. Gould,et al.  Towards better uncertainty estimates for turbulence statistics , 1996 .

[15]  S. A. Isaev,et al.  Identification of self-organized vortexlike structures in numerically simulated turbulent flow of a viscous incompressible liquid streaming around a well on a plane , 2000 .

[16]  P. A. Baranov,et al.  Effect of supercirculation in a flow around a thick airfoil with vortex cells , 2001 .

[17]  Qiang Zhang,et al.  Comparisons of flow structure above dimpled surfaces with different dimple depths in a channel , 2005 .

[18]  J. M. Davies,et al.  The Aerodynamics of Golf Balls , 1949 .

[19]  C. Tropea,et al.  Laser Doppler and Phase Doppler Measurement Techniques , 2002 .

[20]  Yair Mor-Yossef,et al.  Effect of Oscillations on Airfoils in Close Proximity to the Ground , 2004 .

[21]  Bruce L. Storms,et al.  Lift enhancement of an airfoil using a Gurney flap and vortex generators , 1993 .

[22]  Haecheon Choi,et al.  Mechanism of drag reduction by dimples on a sphere , 2006 .

[23]  John C. Lin,et al.  Review of research on low-profile vortex generators to control boundary-layer separation , 2002 .