Study on concentration of aqueous sulfuric acid solution by multiple-effect membrane distillation

Abstract Multiple-effect membrane distillation (MEMD) process, by using a hollow fiber-based AGMD module and an external heat exchanger, was studied to concentrate dilute sulfuric acid solution. Latent heat of distillate was in-situ recovered by directly heating the cold feed within the AGMD module of special configuration. Permeation flux (Jw) and performance ratio (PR) parameters were used to characterize the operation performance of MEMD process. PR value obtained in the MEMD process was much higher than that obtained in traditional and the other modified membrane distillation process. The effects of heated feed-in temperature, cold feed-in temperature, feed-in flow rate and feed-in concentration on the MEMD performance were experimentally investigated. The dilute sulfuric acid in 2 wt.% could be concentrated up to about 40 wt.% by using MEMD process. The maximum value of PR and Jw could reach 11.5 and 5.3 L/m2h, respectively. When the feed concentration was up to 20 wt.%, the value of PR and Jw could still be 4.9 and 1.9 L/m2h, respectively. In a long-term stability test lasting for > 30 days, the electrical conductivity of the distillate was always less than 150 μs/cm, which demonstrated that the performance of MEMD modules was kept in good condition.

[1]  C. W. Leung,et al.  Theoretical and experimental studies on air gap membrane distillation , 1998 .

[2]  P. Fiorini,et al.  Thermoeconomic analysis of a MSF desalination plant , 2005 .

[3]  M. Degrez,et al.  Applications of electrodialysis for acid pickling wastewater treatment , 2000 .

[4]  Julián Blanco,et al.  Experimental analysis of an air gap membrane distillation solar desalination pilot system , 2011 .

[5]  Junghui Chen,et al.  Numerical Simulation and Optimal Design of AGMD-Based Hollow Fiber Modules for Desalination , 2009 .

[6]  Magdalena Regel-Rosocka,et al.  A review on methods of regeneration of spent pickling solutions from steel processing. , 2010, Journal of hazardous materials.

[7]  A. B. de Haan,et al.  Air gap membrane distillation: 2. Model validation and hollow fibre module performance analysis , 2005 .

[8]  Kamalesh K. Sirkar,et al.  Novel membrane and device for vacuum membrane distillation-based desalination process , 2005 .

[9]  T. Hodgkiess,et al.  Membrane distillation - an assessment , 1985 .

[10]  M. Tomaszewska,et al.  Concentration of the extraction fluid from sulfuric acid treatment of phosphogypsum by membrane distillation , 1993 .

[11]  A. B. de Haan,et al.  Desalination and water recycling by air gap membrane distillation , 2006 .

[12]  Matthias Rommel,et al.  Solar thermal-driven desalination plants based on membrane distillation☆ , 2003 .

[13]  Anthony G. Fane,et al.  The efficient use of energy in membrane distillation , 1987 .

[14]  Shoji Kimura,et al.  Transport phenomena in membrane distillation , 1987 .

[15]  Noam Lior,et al.  Transport analysis of air-gap membrane distillation , 2005 .

[16]  Jack Gilron,et al.  Design for Cascade of Crossflow Direct Contact Membrane Distillation , 2007 .

[17]  Shoji Kimura,et al.  Experiments on sea water desalination by membrane distillation , 1988 .

[18]  M. Gryta,et al.  Study on the concentration of acids by membrane distillation , 1995 .

[19]  Toshio Sawa,et al.  Heat recovery characteristics of membrane distillation , 1996 .

[20]  M. Qtaishat,et al.  Heat and mass transfer analysis in direct contact membrane distillation , 2008 .

[21]  Noam Lior,et al.  Comparative study of direct-contact and air-gap membrane distillation processes , 2007 .

[22]  S. Sau,et al.  Membrane distillation of HI /H2O and H2SO4/H2O mixtures for the sulfur-iodine thermochemical process , 2007 .

[23]  M. Tomaszewska.  Concentration and Purification of Fluosilicic Acid by Membrane Distillation , 2000 .

[24]  P. Sridhar,et al.  Recovery of acid from cation exchange resin regeneration waste by diffusion dialysis , 1989 .

[25]  Jack Gilron,et al.  Desalination with a Cascade of Cross-Flow Hollow Fiber Membrane Distillation Devices Integrated with a Heat Exchanger , 2011 .