Enhanced photocatalytic reduction of CO2 using CdS/Mn2O3 nanocomposite photocatalysts on porous anodic alumina support with solar concentrators

Abstract Photocatalytic reduction of CO2 has gained interest due to dual benefits of reduction of global warming and production of synthetic fuels. In this work, we report photochemical reduction of CO2 using CdS and CdS/Mn2O3 nanocomposites as photocatalyst supported on porous anodic alumnia (PAA) support. Incomplete anodization of an aluminum film substrate leaves a thin layer of aluminum in the middle that improves mechanical integrity and retain electrical conductivity of the support. The rod shaped crystals of CdS, grown on the support’s pore surface form a crumpled sheet like structure that helps in trapping of light energy incident on the catalyst surface. The photocatalytic reduction of CO2 was performed under the direct sunlight, using reflectors like flat mirrors, compound parabola, and concentrating Fresnel lens to direct solar radiation onto the catalytic surface. The combination of Fresnel lens as concentrator and CdS/Mn2O3 nanocomposite as the catalyst gave exceptional increase in the photocatalytic activity when compared with CdS alone, with a peak formation rate of 52.2 μmol/g.cat/hr of C2H5OH, 1392.3 μmol/g.cat/hr of HCOOH and H2 production at the rate of 2766 μmol/g.cat/hr.

[1]  Xiaoze Du,et al.  Numerical investigation on photocatalytic CO2 reduction by solar energy in double-skin sheet reactor , 2014 .

[2]  T. He,et al.  Hollow and mesoporous ZnTe microspheres: synthesis and visible-light photocatalytic reduction of carbon dioxide into methane , 2015 .

[3]  Leszek Zaraska,et al.  Anodic alumina membranes with defined pore diameters and thicknesses obtained by adjusting the anodizing duration and pore opening/widening time , 2011 .

[4]  Yi‐Jun Xu,et al.  Electrostatic self-assembly of CdS nanowires-nitrogen doped graphene nanocomposites for enhanced visible light photocatalysis , 2015 .

[5]  Xin Wang,et al.  Synthesis, structure and photocatalytic reactivity of layered CdS/H2La2Ti3O10 nanocomposites , 2006 .

[6]  Jingjing Chen,et al.  Enhanced visible light photocatalytic activity for g-C3N4/SnO2:Sb composites induced by Sb doping , 2018, Journal of Materials Science.

[7]  S. Datta,et al.  Directionally asymmetric self-assembly of cadmium sulfide nanotubes using porous alumina nanoreactors: need for chemohydrodynamic instability at the nanoscale. , 2012, Physical review. E, Statistical, nonlinear, and soft matter physics.

[8]  S. Ikeda,et al.  X-ray photoelectron spectroscopy of manganese—oxygen systems , 1975 .

[9]  Leszek Zaraska,et al.  Porous alumina membranes with branched nanopores as templates for fabrication of Y-shaped nanowire arrays , 2012, Journal of Solid State Electrochemistry.

[10]  A. Panacek,et al.  CdS nanoparticles deposited on montmorillonite: preparation, characterization and application for photoreduction of carbon dioxide. , 2011, Journal of colloid and interface science.

[11]  Liejin Guo,et al.  Manganese doped cadmium sulfide nanocrystal for hydrogen production from water under visible light , 2012 .

[12]  D. Ayodhya,et al.  One-pot sonochemical synthesis of CdS nanoparticles: photocatalytic and electrical properties , 2015, International Journal of Industrial Chemistry.

[13]  R. Penner,et al.  Size-Selective and Epitaxial Electrochemical/Chemical Synthesis of Sulfur-Passivated Cadmium Sulfide Nanocrystals on Graphite , 1998 .

[14]  Youlong Xu,et al.  Pulse Electrodeposition of Manganese Oxide for High-Rate Capability Supercapacitors , 2012, International Journal of Electrochemical Science.

[15]  Xiaoze Du,et al.  Photocatalytic reduction of CO2 by CO co-feed combined with photocatalytic water splitting in a novel twin reactor , 2016 .

[16]  N. Xu,et al.  Selectively hydrothermal and solvothermal growth of CdS nanospheres and nanorods: a facile way to tune finely optical properties , 2006 .

[17]  Xiaoze Du,et al.  Performance analysis of photocatalytic CO2 reduction in optical fiber monolith reactor with multiple inverse lights , 2014 .

[18]  H. Abdullah,et al.  Optical Properties of Ni2+-, Co2+-, and Mn2+-doped ZnS Nanoparticles Synthesized Using Reverse Micelle Method , 2015 .

[19]  Greg P. Smestad,et al.  Review: Photochemical and Thermochemical Production of Solar Fuels from H2O and CO2 Using Metal Oxide Catalysts , 2012 .

[20]  Chang-Tang Chang,et al.  Photocatalytic reduction of carbon dioxide to methanol and formic acid by graphene-TiO2 , 2014, Journal of the Air & Waste Management Association.

[21]  Weifeng Liu,et al.  CdS nanotubes and y-branched nanochannels in AAM fabricated by a double diffusion route , 2011 .

[22]  Ashavani Kumar,et al.  Synthesis, structural and photocatalytic studies of Mn-doped CdS nanoparticles , 2013, Research on Chemical Intermediates.

[23]  Jian Liu,et al.  3D ordered macroporous TiO2-supported Pt@CdS core–shell nanoparticles: design, synthesis and efficient photocatalytic conversion of CO2 with water to methane , 2015 .

[24]  R. Penner,et al.  “Multipulse” Electrochemical/Chemical Synthesis of CdS/S Core/Shell Nanocrystals Exhibiting Ultranarrow Photoluminescence Emission Lines , 1999 .

[25]  Ying Yu,et al.  Preparation of multi-walled carbon nanotube supported TiO2 and its photocatalytic activity in the reduction of CO2 with H2O , 2007 .

[26]  Aicheng Chen,et al.  Electrochemical fabrication of novel nanostructures based on anodic alumina , 2004 .

[27]  Yueping Fang,et al.  Adsorption of CO2 on heterostructure CdS(Bi2S3)/TiO2 nanotube photocatalysts and their photocatalytic activities in the reduction of CO2 to methanol under visible light irradiation , 2012 .

[28]  Xiaojun Wang,et al.  Single-step noninjection synthesis of highly luminescent water soluble Cu+ doped CdS quantum dots: application as bio-imaging agents. , 2013, Chemical Communications.

[29]  Xiaoze Du,et al.  Modeling photocatalytic conversion of carbon dioxide in bubbling twin reactor , 2017 .

[30]  Sibo Wang,et al.  Photocatalytic CO2 reduction by CdS promoted with a zeolitic imidazolate framework , 2015 .

[31]  T. Shripathi,et al.  Quenching of photoconductivity in Fe doped CdS thin films prepared by spray pyrolysis technique , 2008 .

[32]  Hiromi Yamashita,et al.  Photocatalytic reduction of CO2 with H2O on various titanium oxide photocatalysts , 2012 .

[33]  A. Mani,et al.  One pot synthesis of CdS/TiO2 hetero-nanostructures for enhanced H2 production from water and removal of pollutants from aqueous streams , 2016 .

[34]  Rui Li,et al.  Ultralong cadmium hydroxide nanowires: synthesis, characterization, and transformation into CdO nanostrands. , 2007, Langmuir : the ACS journal of surfaces and colloids.

[35]  S. Raj,et al.  Understanding of ferromagnetism in thiol capped Mn doped CdS nanocrystals , 2013 .

[36]  Yu‐Wen Chen,et al.  Photocatalytic reduction of carbon dioxide on NiO/InTaO4 under visible light irradiation , 2007 .

[37]  Fuat Egelioğlu,et al.  A Review of Solar Photovoltaic Concentrators , 2014 .

[38]  Ying Dai,et al.  Selective ethanol formation from photocatalytic reduction of carbon dioxide in water with BiVO4 photocatalyst , 2009 .

[39]  Kenji Fukuda,et al.  Ordered Metal Nanohole Arrays Made by a Two-Step Replication of Honeycomb Structures of Anodic Alumina , 1995, Science.

[40]  Alberto E. Cassano,et al.  Photocatalysis in water environments using artificial and solar light , 2000 .

[41]  Lianzhou Wang,et al.  Recent advances in 2D materials for photocatalysis. , 2016, Nanoscale.

[42]  M. Jaroniec,et al.  Ni(OH)2 modified CdS nanorods for highly efficient visible-light-driven photocatalytic H2 generation , 2011 .

[43]  Juncheng Hu,et al.  Hydrothermal synthesis of Mn-doped CdS hollow sphere nanocomposites as efficient visible-light driven photocatalysts , 2015 .

[44]  Ying Yu,et al.  Preparation, characterization and photocatalytic properties of CdS nanoparticles dotted on the surface of carbon nanotubes , 2008, Nanotechnology.

[45]  Hermenegildo Garcia,et al.  Solar Light Photocatalytic CO2 Reduction: General Considerations and Selected Bench-Mark Photocatalysts , 2014, International journal of molecular sciences.

[46]  Yu-Ming Lin,et al.  Formation of Thick Porous Anodic Alumina Films and Nanowire Arrays on Silicon Wafers and Glass , 2003 .

[47]  Jiani Qin,et al.  Enhanced selective photocatalytic CO2 reduction into CO over Ag/CdS nanocomposites under visible light , 2017 .

[48]  K. Kočí,et al.  EFFECT OF TEMPERATURE, PRESSURE AND VOLUME OF REACTING PHASE ON PHOTOCATALYTIC CO2 REDUCTION ON SUSPENDED NANOCRYSTALLINE TiO2 , 2008 .

[49]  Micah J. Green,et al.  Liquid phase exfoliation and crumpling of inorganic nanosheets. , 2015, Physical chemistry chemical physics : PCCP.

[50]  Mufeedah Muringa Kandy,et al.  Photocatalytic reduction of CO2 using CdS nanorods on porous anodic alumina support , 2018, Materials Research Bulletin.

[51]  C. H. Chen,et al.  Hydrogen Bubbles and the Growth Morphology of Ramified Zinc by Electrodeposition , 2008 .

[52]  Bin Zhang,et al.  Synthesis of ultrathin CdS nanosheets as efficient visible-light-driven water splitting photocatalysts for hydrogen evolution. , 2013, Chemical communications.

[53]  Ravi Sharma.  Optical studies of CdS:Mn nanoparticles. , 2012, Luminescence : the journal of biological and chemical luminescence.

[54]  M. Anderson,et al.  A Hybrid Electrochemical/Chemical Synthesis of Supported, Luminescent Cadmium Sulfide Nanocrystals , 1997 .

[55]  Prashant V Kamat,et al.  Mn-doped quantum dot sensitized solar cells: a strategy to boost efficiency over 5%. , 2012, Journal of the American Chemical Society.

[56]  João E. Benedetti,et al.  Synthesis and characterization of a quaternary nanocomposite based on TiO2/CdS/rGO/Pt and its application in the photoreduction of CO2 to methane under visible light , 2015 .

[57]  A. Fujishima,et al.  Photoelectrocatalytic reduction of carbon dioxide in aqueous suspensions of semiconductor powders , 1979, Nature.

[58]  G. Guan,et al.  Photoreduction of carbon dioxide with water over K2Ti6O13 photocatalyst combined with Cu/ZnO catalyst under concentrated sunlight , 2003 .

[59]  Takehiko Kitamori,et al.  Photocatalytic generation of hydrogen by core-shell WO3/BiVO4 nanorods with ultimate water splitting efficiency , 2015, Scientific Reports.

[60]  Nan Zhang,et al.  Nanocomposites of graphene-CdS as photoactive and reusable catalysts for visible-light-induced selective reduction process , 2014 .