The influence of high flux broadband irradiation on soot concentration and temperature of a sooty flame

Abstract This paper reports the first set of measurements of the influence of simulated concentrated solar radiation (CSR) on the soot volume fraction and temperature in a laminar non-premixed ethylene flame. Broadband irradiation that closely approximates the solar spectrum was produced with a metal-halide lamp configured in a series of three optical concentrators to achieve fluxes of up to 0.45 MW/m 2 in a focused area of 80 mm in diameter. The radiation was used to irradiate an entire Santoro-type laminar flame of 64 mm in length, where the soot volume fraction and flame temperature were measured using planar laser-induced incandescence (LII) and two-line atomic fluorescence (TLAF), respectively. The results show that the simulated concentrated solar radiation significantly influences the evolution of soot on the fuel-rich side of the flame, but does not change either the visible length or width of the flame. It causes the soot volume fraction to increase by up to 50%, the soot inception to be translated upstream by 7% of the flame length, and the consumption rate of soot in the radial direction to increase by an average value of 54% for heights greater than 10 mm above the burner. The temperature of the flame was also found to increase by up to ∼100 K in most of the downstream locations.

[1]  Guillermo Ordorica-Garcia,et al.  Novel integration options of concentrating solar thermal technology with fossil-fuelled and CO2 capture processes , 2011 .

[2]  S. Turns.  Introduction to Combustion , 1995, Aerothermodynamics and Jet Propulsion.

[3]  Zhiwei Sun,et al.  Time-resolved spectra of solar simulators employing metal halide and xenon arc lamps , 2015 .

[4]  Hsueh-Chia Chang,et al.  Determination of the wavelength dependence of refractive indices of flame soot , 1990, Proceedings of the Royal Society of London. Series A: Mathematical and Physical Sciences.

[5]  Qing Nian Chan,et al.  Assessment of interferences to nonlinear two-line atomic fluorescence (NTLAF) in sooty flames , 2011 .

[6]  C. Megaridis,et al.  Fuel preheat effects on soot-field structure in laminar gas jet diffusion flames burning in 0-g and 1-g , 1999 .

[7]  Robert J. Santoro,et al.  Modeling and measurements of soot and species in a laminar diffusion flame , 1996 .

[8]  Laurence S. Rothman,et al.  Reprint of: The HITRAN molecular spectroscopic database and HAWKS (HITRAN Atmospheric Workstation): 1996 edition , 1998 .

[9]  Zhiwei Sun,et al.  Concentric multilayer model of the arc in high intensity discharge lamps for solar simulators with experimental validation , 2015 .

[10]  Robert J. Santoro,et al.  INVESTIGATION OF SPECIES CONCENTRATION AND SOOT FORMATION IN A CO-FLOWING DIFFUSION FLAME OF ETHYLENE , 2007 .

[11]  Robert J. Santoro,et al.  The oxidation of soot and carbon monoxide in hydrocarbon diffusion flames , 1994 .

[12]  Nicholas A. Dembsey,et al.  A simplified model for soot formation and oxidation in CFD simulation of non-premixed hydrocarbon flames , 2005 .

[13]  G. Nathan,et al.  The effect of global mixing on soot volume fraction: measurements in simple jet, precessing jet, and bluff body flames , 2005 .

[14]  Katherine R. Krueger.  Design and characterization of a concentrating solar simulator. , 2012 .

[15]  G. Nathan,et al.  Simultaneous imaging of temperature and soot volume fraction , 2011 .

[16]  You Ying,et al.  Thermodynamic advantages of using solar energy in the regenerative Rankine power plant , 1999 .

[17]  Qing Nian Chan,et al.  The influence on the soot distribution within a laminar flame of radiation at fluxes of relevance to concentrated solar radiation , 2011 .

[18]  Christof Schulz,et al.  Laser-Induced Incandescence , 2006 .

[19]  Aldo Steinfeld,et al.  A Novel 50kW 11,000 suns High-Flux Solar Simulator Based on an Array of Xenon Arc Lamps , 2007 .

[20]  Gang Li,et al.  The HITRAN 2008 molecular spectroscopic database , 2005 .

[21]  Graham J. Nathan,et al.  Economic evaluation of a novel fuel-saver hybrid combining a solar receiver with a combustor for a solar power tower , 2014 .

[22]  M. Thomson,et al.  Application of an enhanced PAH growth model to soot formation in a laminar coflow ethylene/air diffusion flame , 2011 .

[23]  Alain Ferriere,et al.  Thermal Performances of a High Temperature Air Solar Absorber Based on Compact Heat Exchange Technology , 2011 .

[24]  K. M. Leung,et al.  A simplified reaction mechanism for soot formation in nonpremixed flames , 1991 .

[25]  W. Duley,et al.  EXCITATION OF THE AROMATIC INFRARED EMISSION BANDS: CHEMICAL ENERGY IN HYDROGENATED AMORPHOUS CARBON PARTICLES? , 2011, 1107.3778.

[26]  Hui Hong,et al.  A novel hybrid oxy-fuel power cycle utilizing solar thermal energy , 2007 .

[27]  Antonio D'Alessio,et al.  Spectroscopic characterisation of carbonaceous nanoparticles in premixed flames , 1999 .

[28]  Qing Nian Chan,et al.  Recent advances in the measurement of strongly radiating, turbulent reacting flows , 2012 .

[29]  H. Pitsch,et al.  Modification of sooting tendency by magnetic effects , 2015 .

[30]  Damon Honnery,et al.  A soot formation rate map for a laminar ethylene diffusion flame , 1990 .

[31]  M. Thomson,et al.  Modeling DME Addition Effects to Fuel on PAH and Soot in Laminar Coflow Ethylene/Air Diffusion Flames Using Two PAH Mechanisms , 2012 .

[32]  R. Craig.  Investigating the use of concentrated solar energy to thermally decompose limestone. , 2010 .

[33]  Nilay Shah,et al.  Solar-assisted Post-combustion Carbon Capture feasibility study , 2012 .

[34]  C. McEnally,et al.  Computational and experimental study of soot formation in a coflow, laminar ethylene diffusion flame , 1998 .

[35]  Zhiwei Sun,et al.  Secondary Concentrators to Achieve High Flux Radiation With Metal Halide Solar Simulators , 2016 .

[36]  Pierre Garcia,et al.  Solar Field Efficiency and Electricity Generation Estimations for a Hybrid Solar Gas Turbine Project in France , 2008 .

[37]  Stefan Will,et al.  Laser-induced incandescence: recent trends and current questions , 2006 .

[38]  F. Migliorini,et al.  Investigation of optical properties of aging soot , 2011 .

[39]  Burak Atakan,et al.  Studies of aromatic hydrocarbon formation mechanisms in flames: Progress towards closing the fuel gap , 2006 .

[40]  Dragos Ciuparu,et al.  Experimental study of fuel decomposition and hydrocarbon growth processes for practical fuel components: heptanes , 2003 .

[41]  I. Glassman.  Soot formation in combustion processes , 1989 .

[42]  Adel F. Sarofim,et al.  Soot formation in methane-oxygen flames , 1975 .

[43]  Bassam B. Dally,et al.  Improvement of precision and accuracy of temperature imaging in sooting flames using two-line atomic fluorescence (TLAF) , 2016 .

[44]  C. Joblin,et al.  On-line database of the spectral properties of polycyclic aromatic hydrocarbons , 2007 .

[45]  Klaus Peter Geigle,et al.  The influence of wavelength in extinction measurements and beam steering in laser-induced incandescence measurements in sooting flames , 2009 .

[46]  Robert J. Santoro,et al.  Spatially resolved measurements of soot volume fraction using laser-induced incandescence , 1994 .

[47]  Qing Nian Chan,et al.  Soot volume fraction in a piloted turbulent jet non-premixed flame of natural gas , 2009 .

[48]  Michael G. Littman,et al.  Comparative study of soot formation on the centerline of axisymmetric laminar diffusion flames: Fuel and temperature effects , 1987 .