Silicon trench photodiodes on a wafer for efficient X-ray-to-current signal conversion using side-X-ray-irradiation mode

In this paper, we report a direct-conversion-type X-ray sensor composed of trench-structured silicon photodiodes, which achieves a high X-ray-to-current conversion efficiency under side X-ray irradiation. The silicon X-ray sensor with a length of 22.6 mm and a trench depth of 300 µm was fabricated using a single-poly single-metal 0.35 µm process. X-rays with a tube voltage of 80 kV were irradiated along the trench photodiode from the side of the test chip. The theoretical limit of X-ray-to-current conversion efficiency of 83.8% was achieved at a low reverse bias voltage of 25 V. The X-ray-to-electrical signal conversion efficiency of conventional indirect-conversion-type X-ray sensors is about 10%. Therefore, the developed sensor has a conversion efficiency that is about eight times higher than that of conventional sensors. It is expected that the developed X-ray sensor will be able to markedly lower the radiation dose required for X-ray diagnoses.

[1]  G. Hounsfield.  Computerized transverse axial scanning (tomography): Part I. Description of system. 1973. , 1973, The British journal of radiology.

[2]  H. Eyring.  The Activated Complex in Chemical Reactions , 1935 .

[3]  Roger Lecomte,et al.  Investigation of GSO, LSO and YSO scintillators using reverse avalanche photodiodes , 1997 .

[4]  Amy Berrington de González,et al.  Risk of cancer from diagnostic X-rays: estimates for the UK and 14 other countries , 2004, The Lancet.

[5]  C. Ponchut,et al.  Characterization of a Pixelated CdTe X-Ray Detector Using the Timepix Photon-Counting Readout Chip , 2012, IEEE Transactions on Nuclear Science.

[6]  Non-linear Response In The Scintillation Yield Of Lu/sub 2/ SiO/sub 5/ O:Ce/sup 3+/ , 1993 .

[7]  H. L. Malm,et al.  A Mercuric Iodide Gamma-Ray Spectrometer , 1972 .

[8]  N. Gehrels,et al.  Hard X-ray and low-energy gamma-ray spectrometers , 1988 .

[9]  Dieter K. Schroder,et al.  Carrier lifetimes in silicon , 1997 .

[10]  J. L. Blankenship,et al.  Silicon Surface-Barrier Nuclear Particle Spectrometer , 1960, IRE Transactions on Nuclear Science.

[11]  Ezio Caroli,et al.  Progress in the Development of CdTe and CdZnTe Semiconductor Radiation Detectors for Astrophysical and Medical Applications , 2009, Sensors.

[12]  R. D. Ryan,et al.  Evaluation of epitaxial n-GaAs for nuclear radiation detection , 1971 .

[13]  G. Wright.  ABSOLUTE SCINTILLATION EFFICIENCY OF ANTHRACENE CRYSTALS , 1955 .

[14]  D. Mcgregor,et al.  Room-temperature compound semiconductor radiation detectors , 1997 .

[15]  Eiji Sakai,et al.  Present status of room temperature semiconductor detectors , 1982 .

[16]  C. Canali,et al.  Performance of SI LEC GaAs detectors at 20°C and −30°C for X- and γ-ray spectroscopy , 1996 .

[17]  Hiroshi Nakashima,et al.  Particle and Heavy Ion Transport code System, PHITS, version 2.52 , 2013 .

[18]  K. Sakamoto,et al.  X-ray-to-current signal conversion characteristics of trench-structured photodiodes for direct-conversion-type silicon X-ray sensor , 2017 .

[19]  M. Moszynski,et al.  Advantages and limitations of LSO scintillator in nuclear physics experiments , 1995 .

[20]  M. Schieber,et al.  Cadmium telluride and mercuric iodide gamma radiation detectors , 1979 .

[21]  M. Moszynski,et al.  Large size LSO:Ce and YSO:Ce scintillators for 50 MeV range /spl gamma/-ray detector , 2000 .

[22]  C. Bargholtz,et al.  Investigation into the properties of CdTe detectors for in-situ measurements , 2008 .

[23]  J. A. Coleman,et al.  Effective Charge Carrier Lifetime in Silicon p-i-n Junction Detectors , 1966 .

[24]  Magnus Dahlbom,et al.  Performance of a YSO/LSO phoswich detector for use in a PET/SPECT system , 1997 .