P(VDF-TrFE) Polymer-Based Thin Films Deposited on Stainless Steel Substrates Treated Using Water Dissociation for Flexible Tactile Sensor Development

In this work, deionized (DI) water dissociation was used to treat and change the contact angle of the surface of stainless steel substrates followed by the spin coating of P(VDF-TrFE) material for the fabrication of tactile sensors. The contact angle of the stainless steel surface decreased 14° at −30 V treatment; thus, the adhesion strength between the P(VDF-TrFE) thin film and the stainless steel substrate increased by 90%. Although the adhesion strength was increased at negative voltage treatment, it is observed that the crystallinity value of the P(VDF-TrFE) thin film declined to 37% at −60 V. In addition, the remanent polarization value of the P(VDF-TrFE) thin film declined from 5.6 μC/cm2 to 4.61 μC/cm2 for treatment voltages between −5 V and −60 V. A maximum value of approximately 1000 KV/cm of the coercive field value was obtained with the treatment at −15 V. The d33 value was approximately −10.7 pC/N for the substrate treated at 0 V and reached a minimum of −5 pC/N for treatment at −60 V. By using the P(VDF-TrFE) thin-film as the sensing material for tactile sensors, human pulse measurements were obtained from areas including the carotid, brachial, ankle, radial artery, and apical regions. In addition, the tactile sensor is suitable for monitoring the Cun, Guan, and Chi acupoints located at the radial artery region in Traditional Chinese Medicine (TCM). Waveform measurements of the Cun, Guan, and Chi acupoints are crucial because, in TCM, the various waveforms provided information regarding the health conditions of organs.

[1]  Benjamin C. K. Tee,et al.  Highly sensitive flexible pressure sensors with microstructured rubber dielectric layers. , 2010, Nature materials.

[2]  R. Stutz,et al.  Wafer-Level Transfer Technologies for PZT-Based RF MEMS Switches , 2010, Journal of Microelectromechanical Systems.

[3]  Panayiotis A. Kyriacou,et al.  Evaluation of Electrical and Optical Plethysmography Sensors for Noninvasive Monitoring of Hemoglobin Concentration , 2012, Sensors.

[4]  Eunkyoung Kim,et al.  Fabrication of micropatterned ferroelectric gamma poly(vinylidene fluoride) film for non-volatile polymer memory , 2011 .

[5]  Michael C. McAlpine,et al.  Piezoelectric ribbons printed onto rubber for flexible energy conversion. , 2010, Nano letters.

[6]  Wen-Jong Wu,et al.  Flexible PZT Thin Film Tactile Sensor for Biomedical Monitoring , 2013, Sensors.

[7]  M.-Y. Cheng,et al.  A flexible capacitive tactile sensing array with floating electrodes , 2009 .

[8]  Paula M. Vilarinho,et al.  High-quality PbZr0.52Ti0.48O3 films prepared by modified sol–gel route at low temperature , 2004 .

[9]  G. Minas,et al.  Improving the optical and electroactive response of poly(vinylidene fluoride–trifluoroethylene) spin-coated films for sensor and actuator applications , 2012 .

[10]  J. Hyun,et al.  A new approach to characterize crystallinity by observing the mobility of plasma treated polymer surfaces , 2001 .

[11]  Peter Ryser,et al.  Pyroelectric thin-film sensor array , 1997 .

[12]  J McLaughlin,et al.  Piezoelectric sensor determination of arterial pulse wave velocity. , 2003, Physiological measurement.

[13]  J. Hwu,et al.  Electrical characteristics of ultra-thin gate oxides (<3 nm) prepared by direct current superimposed with alternating-current anodization , 2004 .

[14]  C. K. Lee,et al.  Piezoelectric MEMS generators fabricated with an aerosol deposition PZT thin film , 2009 .

[15]  S. Lanceros‐Méndez,et al.  Effect of the microsctructure and lithium-ion content in poly[(vinylidene fluoride)-co-trifluoroethylene]/lithium perchlorate trihydrate composite membranes for battery applications , 2012 .

[16]  T. Kamei,et al.  Novel surface structure and its fabrication process for MEMS fingerprint sensor , 2005, IEEE Transactions on Electron Devices.

[17]  Kazuhiro Nonaka,et al.  Flexible pulse-wave sensors from oriented aluminum nitride nanocolumns , 2003 .

[18]  Na Lu,et al.  Enhancement of adhesion strength between two AISI 316 L stainless steel plates through atmospheric pressure plasma treatment , 2006 .

[19]  Ernesto Suaste-Gómez,et al.  A Piezoelectric Plethysmograph Sensor Based on a Pt Wire Implanted Lead Lanthanum Zirconate Titanate Bulk Ceramic , 2010, Sensors.

[20]  Yu-Feng Chung,et al.  Possibility of quantifying TCM finger-reading sensations: I. Bi-Sensing Pulse Diagnosis Instrument , 2012 .

[21]  Osamu Tabata,et al.  Monolithic pyroelectric infrared image sensor using PVDF thin film , 1997 .

[22]  Joe-Air Jiang,et al.  A Novel Pulse Measurement System by Using Laser Triangulation and a CMOS Image Sensor , 2007, Sensors.

[23]  Pasquale Arpaia,et al.  A piezo-film-based measurement system for global haemodynamic assessment , 2010, Physiological measurement.

[24]  Sang-Gook Kim,et al.  Energy harvesting MEMS device based on thin film piezoelectric cantilevers , 2006 .

[25]  D. Márton,et al.  Human aortic endothelial cell response to 316L stainless steel material microstructure , 2009, Journal of materials science. Materials in medicine.

[26]  K. Matsushige,et al.  Lamellae orientation effect on local polarized domain in P(VDF/TrFE) copolymer: Application in data storage , 2005 .

[27]  Sang-Gook Kim,et al.  MEMS power generator with transverse mode thin film PZT , 2005 .

[28]  Wen-Yang Chang,et al.  A Large Area Flexible Array Sensors Using Screen Printing Technology , 2009, Journal of Display Technology.

[29]  Y. Takata,et al.  Evaporation of water drop on a plasma-irradiated hydrophilic surface , 2004 .

[30]  F. Ko,et al.  Fabrication of a gas sensor with a piezoelectric PZT film deposited by a novel hydrothermal microwave-assisted annealing , 2007 .

[31]  Vanessa F. Cardoso,et al.  Micro and nanofilms of poly(vinylidene fluoride) with controlled thickness, morphology and electroactive crystalline phase for sensor and actuator applications , 2011 .

[32]  Husam N. Alshareef,et al.  Electrical performance of polymer ferroelectric capacitors fabricated on plastic substrate using transparent electrodes , 2012 .

[33]  J. G. Rocha,et al.  Effect of degree of porosity on the properties of poly(vinylidene fluoride-trifluorethylene) for Li-ion battery separators , 2012 .

[34]  G. Metta,et al.  Towards Tactile Sensing System on Chip for Robotic Applications , 2011, IEEE Sensors Journal.

[35]  Chengkuo Lee,et al.  A 1-V Operated MEMS Variable Optical Attenuator Using Piezoelectric PZT Thin-Film Actuators , 2009, IEEE Journal of Selected Topics in Quantum Electronics.

[36]  J. Maria,et al.  Importance Of Solution Chemistry In Preparing Sol–Gel PZT Thin Films Directly On Copper Surfaces , 2008 .

[37]  Ching-Hsing Luo,et al.  Temporal and Spatial Properties of Arterial Pulsation Measurement Using Pressure Sensor Array , 2011, Evidence-based complementary and alternative medicine : eCAM.

[38]  Alan Bernjak,et al.  Pulse transit times to the capillary bed evaluated by laser Doppler flowmetry , 2009, Physiological measurement.

[39]  Influences of thin Ni layer on the electrical and absorption properties of PZT thin film pyroelectric IR sensors , 2000 .

[40]  L. Hao,et al.  Wettability modification and the subsequent manipulation of protein adsorption on a Ti6Al4V alloy by means of CO2 laser surface treatment , 2007, Journal of materials science. Materials in medicine.

[41]  Osamu Fukuda,et al.  Preparation of Oriented Aluminum Nitride Thin Films on Polyimide Films and Piezoelectric Response with High Thermal Stability and Flexibility , 2007 .

[42]  R. Voytovych,et al.  Wetting and brazing of stainless steels by copper–silver eutectic , 2008 .