CMOS-compatible AlN piezoelectric micromachined ultrasonic transducers

Piezoelectric micromachined ultrasonic transducers for air-coupled ultrasound applications were fabricated using aluminum nitride (AlN) as the active piezoelectric layer. The AlN is deposited via a low-temperature sputtering process that is compatible with deposition on metalized CMOS wafers. An analytical model describing the electromechanical response is presented and compared with experimental measurements. The membrane deflection was measured to be 210 nm when excited at the 220 kHz resonant frequency using a 1Vpp input voltage.

[1]  J. Reddy.  Theory and Analysis of Elastic Plates and Shells , 2006 .

[2]  Richard S. Muller,et al.  Piezoelectric microphone with on-chip CMOS circuits , 1993 .

[3]  O. V. von Ramm,et al.  Theory and operation of 2-D array piezoelectric micromachined ultrasound transducers , 2008, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[4]  P. Muralt,et al.  Process optimization for the sputter deposition of molybdenum thin films as electrode for AlN thin films , 2006 .

[5]  K.K. Li,et al.  Micromachined high frequency ferroelectric sonar transducers , 1997, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[6]  Abdullah Atalar,et al.  Micromachined two-dimensional array piezoelectrically actuated transducers , 1998 .

[7]  M. Kupnik,et al.  50 kHz capacitive micromachined ultrasonic transducers for generation of highly directional sound with parametric arrays , 2009, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[8]  P. Muralt,et al.  PZT thin films for microsensors and actuators: Where do we stand? , 2000, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[9]  A. Barzegar,et al.  Piezoelectric micromachined ultrasonic transducers based on PZT thin films , 2005, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[10]  Firas Akasheh,et al.  Development of piezoelectric micromachined ultrasonic transducers , 2004 .

[11]  Balakumar Balachandran,et al.  Sensor diaphragm under initial tension: Linear analysis , 2005 .

[12]  T. Ikeda.  Fundamentals of piezoelectricity , 1990 .

[13]  S. Trolier-McKinstry,et al.  Thin Film Piezoelectrics for MEMS , 2004 .