Highly sensitive detection of DMMP using a CMUT-based chemical sensor

We present ppt-level detection of dimethyl methylphosphonate (DMMP), a common simulant used in detector calibrations for sarin gas, using a new capacitive micromachined ultrasonic transducer (CMUT) design with a mass sensitivity improved from 130 zg/Hz/µm2 to 48.8 zg/Hz/µm2. A low-noise oscillator using the CMUT as the frequency selective component exhibits an Allan deviation of 0.55 Hz at the presence of air flow. The CMUT resonant sensor was functionalized with a 50-nm thick proprietary polymer layer (Sandia National Laboratory, Albuquerque, NM). Our sensor performance was reliably measured at the MIT Lincoln Laboratory where the accurate delivery of low concentrations of gases was ensured through stringent calibrations. Our sensor response to various concentrations of DMMP in air (10 ppb-1 ppm) showed an excellent volume sensitivity of 30.6 pptv/Hz. Based on the system noise floor, we achieved a mass resolution of 26.9 zg/µm2 and a limit of detection of 16.8 pptv. In addition, the sensor showed good selectivity to DMMP.

[1]  Eun Sok Kim,et al.  Micromachined acoustic resonant mass sensor , 2005 .

[2]  O. Oralkan,et al.  Fabricating capacitive micromachined ultrasonic transducers with direct wafer-bonding and LOCOS technology , 2008, 2008 IEEE 21st International Conference on Micro Electro Mechanical Systems.

[3]  Peter Vettiger,et al.  A chemical sensor based on a micromechanical cantilever array for the identification of gases and vapors , 1998 .

[4]  He Shitang,et al.  Enhanced sensitivity of SAW gas sensor coated molecularly imprinted polymer incorporating high frequency stability oscillator , 2007 .

[5]  Kwan Kyu Park,et al.  Capacitive micromachined ultrasonic transducers for chemical detection in nitrogen , 2007 .

[6]  J. Vig,et al.  Noise in microelectromechanical system resonators , 1999, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[7]  Anja Boisen,et al.  Miniature sensor suitable for electronic nose applications. , 2007, The Review of scientific instruments.

[8]  B. Khuri-Yakub,et al.  CMUT as a chemical sensor for DMMP detection , 2008, FCS 2008.

[9]  H. Wohltjen,et al.  Trace Chemical Vapor Detection Using SAW Delay Line Oscillators , 1987, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[10]  Aaas News,et al.  Book Reviews , 1893, Buffalo Medical and Surgical Journal.

[11]  L. Meirovitch.  Analytical Methods in Vibrations , 1967 .

[12]  Stewart Sherrit,et al.  Accurate equivalent circuits for unloaded piezoelectric resonators , 1997, 1997 IEEE Ultrasonics Symposium Proceedings. An International Symposium (Cat. No.97CH36118).