Research on the Conductivity-Based Detection Principles of Bubbles in Two-Phase Flows and the Design of a Bubble Sensor for CBM Wells

The parameters of gas-liquid two-phase flow bubbles in field coalbed methane (CBM) wells are of great significance for analyzing coalbed methane output, judging faults in CBM wells, and developing gas drainage and extraction processes, which stimulates an urgent need for detecting bubble parameters for CBM wells in the field. However, existing bubble detectors cannot meet the requirements of the working environments of CBM wells. Therefore, this paper reports findings on the principles of measuring the flow pattern, velocity, and volume of two-phase flow bubbles based on conductivity, from which a new bubble sensor was designed. The structural parameters and other parameters of the sensor were then computed, the “water film phenomenon” produced by the sensor was analyzed, and the appropriate materials for making the sensor were tested and selected. After the sensor was successfully devised, laboratory tests and field tests were performed, and the test results indicated that the sensor was highly reliable and could detect the flow patterns of two-phase flows, as well as the quantities, velocities, and volumes of bubbles. With a velocity measurement error of ±5% and a volume measurement error of ±7%, the sensor can meet the requirements of field use. Finally, the characteristics and deficiencies of the bubble sensor are summarized based on an analysis of the measurement errors and a comparison of existing bubble-measuring devices and the designed sensor.

[1]  Timothy A. Shedd,et al.  Two-Phase Internal Flow: Toward a Theory of Everything , 2013 .

[2]  Shi Li-min.  Wettability of High Surface Energy Solid and its Surface Tension Calculation , 2008 .

[3]  Marios S. Valavanides.  Steady-State Two-Phase Flow in Porous Media: Review of Progress in the Development of the DeProF Theory Bridging Pore to Statistical Thermodynamics Scales , 2012 .

[4]  Qingchun Lei,et al.  Experimental demonstration of 4D imaging in two-phase flows based on computed tomography at 5  kHz. , 2014, Applied optics.

[5]  Rakesh Mishra,et al.  Measurement of bubble velocity components in a swirling gas–liquid pipe flow using a local four-sensor conductance probe , 2005 .

[6]  Franco Magelli,et al.  Two-Phase Flow and Bubble Size Distribution in Air-Sparged and Surface-Aerated Vessels Stirred by a Dual Impeller , 2010 .

[7]  Shihong Yue,et al.  Using Dempster-Shafer Evidence Theory and Choquet Integral for Image Segmentation in Gas-Liquid Two-Phase Flow , 2009 .

[8]  F. Barthel,et al.  Velocity measurement for two-phase flows based on ultrafast X-ray tomography , 2015 .

[9]  Nie Baisheng.  Study on Measurement and Calculation of Critical Surface Tension of Wetting Coal with Water , 2012 .

[10]  Hao Xu,et al.  Geological controls and coalbed methane production potential evaluation: A case study in Liulin area, eastern Ordos Basin, China , 2014 .

[11]  P. Griffith,et al.  Two-Phase Flow: Theory and Applications , 2017 .

[12]  Seungjin Kim,et al.  Considerations in the Practical Application of the Multisensor Conductivity Probe for Two-Phase Flow , 2015 .

[13]  Sun Bin.  Method for Identifying Gas/Liquid Two-Phase Flow Patterns Using Conductance Probes Technique and Noise Recognition of Conductance Fluctuating Signals , 2008 .

[14]  Cheng Wen.  Experimental Study of the Velocity of Bubble Rising in Water , 2000 .

[15]  Ting Xue,et al.  Three-dimensional feature parameters measurement of bubbles in gas–liquid two-phase flow based on virtual stereo vision , 2012 .

[16]  Li Yon,et al.  Calculation of abroad coalbed methane recoverable resources , 2014 .

[17]  Liejin Guo,et al.  An experimental study on local interfacial area concentration using a double-sensor probe , 2005 .

[18]  Steven L. Ceccio,et al.  A review of electrical impedance techniques for the measurement of multiphase flows , 1991 .

[19]  Mark R. Loewen,et al.  Fiber-optic probe measurements of void fraction and bubble size distributions beneath breaking waves , 2007 .

[20]  Cheng-Shing Lo,et al.  Local hydrodynamic properties of gas phase in an internal-loop airlift reactor , 2003 .

[21]  Somchai Wongwises,et al.  Flow pattern, void fraction and pressure drop of two-phase air–water flow in a horizontal circular micro-channel , 2008 .

[22]  Yuejin Yuan,et al.  Void fraction measurement in steam–water two-phase flow using the gamma ray attenuation under high pressure and high temperature evaporating conditions , 2016 .

[23]  Sun Licheng.  Model of bubble velocity vector measurement using four-sensor optical fiber probe , 2013 .

[24]  J.L.G. Oliveira,et al.  Frictional pressure drop and void fraction analysis in air–water two-phase flow in a microchannel , 2015 .

[25]  Zhang Zhi-xun.  ACOUSTIC DETECTING METHOD FOR BUBBLES FROM SHALLOW GAS TO SEA WATER , 2008 .

[26]  Ting Xue,et al.  Bubble Image Processing Based on ARM in Gas-Liquid Two-Phase Flow , 2013 .

[27]  J. B. Zhu,et al.  Microstructure and the properties of FeCoCuNiSnx high entropy alloys , 2012 .