Acoustic wave flow sensor using quartz thickness shear mode resonator

A quartz thickness shear mode (TSM) bulk acoustic wave resonator was used for in situ and real-time detection of liquid flow rate in this study. A special flow chamber made of 2 parallel acrylic plates was designed for flow measurement. The flow chamber has a rectangular flow channel, 2 flow reservoirs for stabilizing the fluid flow, a sensor mounting port for resonator holding, one inlet port, and one outlet port for pipe connection. A 5-MHz TSM quartz resonator was edge-bonded to the sensor mounting port with one side exposed to the flowing liquid and other side exposed to air. The electrical impedance spectra of the quartz resonator at different volumetric flow rate conditions were measured by an impedance analyzer for the extraction of the resonant frequency through a data-fitting method. The fundamental, 3rd, 5th, 7th, and 9th resonant frequency shifts were found to be around 920, 3572, 5947, 8228, and 10 300 Hz for flow rate variation from 0 to 3000 mL/min, which had a corresponding Reynolds number change from 0 to 822. The resonant frequency shifts of different modes are found to be quadratic with flow rate, which is attributed to the nonlinear effect of quartz resonator due to the effective normal pressure imposing on the resonator sensor by the flowing fluid. The results indicate that quartz TSM resonators can be used for flow sensors with characteristics of simplicity, fast response, and good repeatability.

[1]  Peter Hauptmann,et al.  Transduction mechanism of acoustic-wave based chemical and biochemical sensors , 2003 .

[2]  Bernhard Jakoby,et al.  The potential of microacoustic SAW- and BAW-based sensors for automotive applications - a review , 2002 .

[3]  F. Durst,et al.  Highly spatially resolved velocity measurements of a turbulent channel flow by a fiber-optic heterodyne laser-Doppler velocity-profile sensor , 2006 .

[4]  C. Steinem,et al.  Piezoelectric Mass-Sensing Devices as Biosensors-An Alternative to Optical Biosensors? , 2000, Angewandte Chemie.

[5]  H. F. Tiersten,et al.  Perturbation theory for linear electroelastic equations for small fields superposed on a bias , 1978 .

[6]  Errol P. Eernisse,et al.  Frequency shift calculations for quartz resonators , 1991, Proceedings of the 45th Annual Symposium on Frequency Control 1991.

[7]  Anne M. Robertson,et al.  The numerical design of a parallel plate flow chamber for investigation of endothelial cell response to shear stress , 2003 .

[8]  Dominique Rebière,et al.  Acoustic wave devices to measure gas flow : comparison between surface acoustic wave (SAW) and shear horizontal acoustic plate mode (SH-APM) oscillators , 1994 .

[9]  Zheyao Wang,et al.  Effect of transverse force on the performance of quartz resonator force sensors. , 2004, IEEE transactions on ultrasonics, ferroelectrics, and frequency control.

[10]  J. Gordon,et al.  Frequency of a quartz microbalance in contact with liquid , 1985 .

[11]  E.P. EerNisse,et al.  Review of thickness-shear mode quartz resonator sensors for temperature and pressure , 2001, IEEE Sensors Journal.

[12]  Jiashi Yang,et al.  An estimate on the second-order normal acceleration sensitivity of a quartz resonator. , 2006, IEEE transactions on ultrasonics, ferroelectrics, and frequency control.

[13]  Qing-Ming Wang,et al.  Thickness shear mode acoustic wave sensors for characterizing the viscoelastic properties of cell monolayer , 2008 .

[14]  Michael D. Ward,et al.  Measurement of interfacial processes at electrode surfaces with the electrochemical quartz crystal microbalance , 1992 .

[15]  D. Janiaud,et al.  Analytical Calculation of Initial Stress Effects on Anisotropic Crystals: Application to Quartz Resonators , 1978 .

[16]  H. Karrer,et al.  A Quartz Resonator Pressure Transducer , 1969, IEEE Transactions on Industrial Electronics and Control Instrumentation.

[17]  S. Joshi.  Surface-acoustic-wave (SAW) flow sensor , 1991, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[18]  X. Markenscoff,et al.  High−frequency vibrations of crystal plates under initial stresses , 1975 .

[19]  E. P. Eernisse,et al.  The Force-Frequency Effect in Doubly Rotated Quartz Resonators , 1977 .

[20]  Lifeng Qin,et al.  Characterization of polymer nanocomposite films using quartz thickness shear mode (TSM) acoustic wave sensor , 2007 .

[21]  K. Marx,et al.  Quartz crystal microbalance: a useful tool for studying thin polymer films and complex biomolecular systems at the solution-surface interface. , 2003, Biomacromolecules.

[22]  J. Ratajski,et al.  Force-frequency coefficient of singly rotated vibrating quartz crystals , 1968 .