Comparative Study of ZnO Thin Films Grown on Quartz Glass and Sapphire (001) Substrates by Means of Magnetron Sputtering and High-Temperature Annealing

In this work, we reported a comparative study of ZnO thin films grown on quartz glass and sapphire (001) substrates through magnetron sputtering and high-temperature annealing. Firstly, the ZnO thin films were deposited on the quartz glass and sapphire (001) substrates in the same conditions by magnetron sputtering. Afterwards, the sputtered ZnO thin films underwent an annealing process at 600 ◦C for 1 h in an air atmosphere to improve the quality of the films. X-ray diffraction, scanning electron microscopy, atomic force microscopy, X-ray photoelectron spectroscopy (XPS), ultraviolet-visible spectra, photoluminescence spectra, and Raman spectra were used to investigate the structural, morphological, electrical, and optical properties of the both as-received ZnO thin films. The ZnO thin films grown on the quartz glass substrates possess a full width of half maximum value of 0.271◦ for the (002) plane, a surface root mean square value of 0.50 nm and O vacancies/defects of 4.40% in the total XPS O 1s peak. The comparative investigation reveals that the whole properties of the ZnO thin films grown on the quartz glass substrates are comparable to those grown on the sapphire (001) substrates. Consequently, ZnO thin films with high quality grown on the quartz glass substrates can be achieved by means of magnetron sputtering and high-temperature annealing at 600 ◦C.

[1]  J. Leem,et al.  Laser-assisted sol-gel growth and characteristics of ZnO thin films , 2012 .

[2]  N. Bundaleski,et al.  XPS analysis of ZnO:Ga films deposited by magnetron sputtering: Substrate bias effect , 2018, Applied Surface Science.

[3]  A. Galeckas,et al.  Zinc vacancy and oxygen interstitial in ZnO revealed by sequential annealing and electron irradiation , 2012 .

[4]  Y. Liu,et al.  Bioinspired Synthesis of Vertically Aligned ZnO Nanorod Arrays: Toward Greener Chemistry , 2009 .

[5]  R. Shabannia,et al.  Structural, optical, and electrical properties of ZnO nanofilms deposited over PS substrate , 2017 .

[6]  M. Marssi,et al.  Mn doping effect on the structural properties of ZnO-nanostructured films deposited by the ultrasonic spray pyrolysis method , 2012 .

[7]  Z. Hassan,et al.  Structural and optical properties of In-doped ZnO thin films under wet annealing , 2014 .

[8]  Lizhong Hu,et al.  Piezoelectric effect enhancing decay time of p-NiO/n-ZnO ultraviolet photodetector , 2016 .

[9]  W. Stickle,et al.  Handbook of X-Ray Photoelectron Spectroscopy , 1992 .

[10]  Jikui Luo,et al.  Thermal annealing effect on ZnO surface acoustic wave-based ultraviolet light sensors on glass substrates , 2014 .

[11]  R. Spolenak,et al.  Correlation between the defect structure and the residual stress distribution in ZnO visualized by TEM and Raman microscopy , 2010 .

[12]  Jenn–Ming Wu,et al.  Fabrication and characterization of well-dispersed plasmonic Pt nanoparticles on Ga-doped ZnO nanopagodas array with enhanced photocatalytic activity , 2015 .

[13]  M. G. Patil,et al.  Synthesis of highly selective and sensitive Cu-doped ZnO thin film sensor for detection of H2S gas , 2017 .

[14]  A. Pham,et al.  Thermoelectric Properties of Indium and Gallium Dually Doped ZnO Thin Films. , 2016, ACS applied materials & interfaces.

[15]  H. C. Ong,et al.  Photoluminescence and cathodoluminescence studies of stoichiometric and oxygen-deficient ZnO films , 2001 .

[16]  V. Nampoori,et al.  Effect of annealing on the spectral and nonlinear optical characteristics of thin films of nano-ZnO , 2008 .

[17]  Li Han,et al.  Enhanced electrical properties of ZnO transparent conducting films prepared by electron beam annealing , 2018 .

[18]  L. Torres-Martínez,et al.  ZnO thin films deposited by RF magnetron sputtering: Effects of the annealing and atmosphere conditions on the photocatalytic hydrogen production , 2018 .

[19]  Jiecai Han,et al.  Influence of film thickness and annealing temperature on the structural and optical properties of ZnO thin films on Si (1 0 0) substrates grown by atomic layer deposition , 2015 .

[20]  Dong Chan Kim,et al.  A comparative analysis of deep level emission in ZnO layers deposited by various methods , 2009 .

[21]  K. Sreenivas,et al.  Residual stress and defect content in magnetron sputtered ZnO films grown on unheated glass substrates , 2016 .

[22]  Dong-Wook Kim,et al.  Selective photochemical synthesis of Ag nanoparticles on position-controlled ZnO nanorods for the enhancement of yellow-green light emission. , 2015, Nanoscale.

[23]  A. Djurišić,et al.  Surface polarity control in ZnO films deposited by pulsed laser deposition , 2019, Applied Surface Science.

[24]  Wenliang Wang,et al.  2D AlN Layers Sandwiched Between Graphene and Si Substrates , 2018, Advanced materials.

[25]  Xiu-lan Yan,et al.  A nondestructive raman spectra stress 2D analysis for the pressure sensor sensitive silicon membrane , 2019, Engineering Failure Analysis.

[26]  T. Karthik,et al.  Porous silicon ZnO/SnO2 structures for CO2 detection , 2018 .

[27]  Yichun Liu,et al.  Significant improvement of near-UV electroluminescence from ZnO quantum dot LEDs via coupling with carbon nanodot surface plasmons. , 2017, Nanoscale.

[28]  S. Tseng.  Investigation of post-annealing aluminum-doped zinc oxide (AZO) thin films by a graphene-based heater , 2018, Applied Surface Science.

[29]  Harold P. Klug,et al.  X-Ray Diffraction Procedures: For Polycrystalline and Amorphous Materials, 2nd Edition , 1974 .

[30]  Juncheng Liu,et al.  Effects of the annealing temperature on the structure and up-conversion photoluminescence of ZnO film , 2018, Journal of Materials Science & Technology.

[31]  P. Jannotti,et al.  Measurement of microscale residual stresses in multi-phase ceramic composites using Raman spectroscopy , 2017 .

[32]  W. K. Chan,et al.  Defect emissions in ZnO nanostructures , 2005, SPIE Optics + Photonics.

[33]  K. Balin,et al.  The influence of atomic layer deposition process temperature on ZnO thin film structure , 2019, Applied Surface Science.

[34]  Dongmei Li,et al.  Effect of the initial thin Ti buffer layers on the quality of ZnO thin films grown on Si(111) substrates by MOCVD , 2006 .

[35]  H. Ho,et al.  Light-Activated Metal Oxide Gas Sensors: A Review , 2017, Micromachines.

[36]  Bao-Lian Su,et al.  Bio-inspired Murray materials for mass transfer and activity , 2017, Nature Communications.

[37]  C. Chandrinou,et al.  PL study of oxygen defect formation in ZnO nanorods , 2009, Microelectron. J..

[38]  B. Bahrami,et al.  Origin of high carrier mobility and low residual stress in RF superimposed DC sputtered Al doped ZnO thin film for next generation flexible devices , 2018 .

[39]  X. J. Wang,et al.  Oxygen and zinc vacancies in as-grown ZnO single crystals , 2009 .

[40]  Soon-Ku Hong,et al.  Enhancement of CO gas sensing properties in ZnO thin films deposited on self-assembled Au nanodots , 2010 .

[41]  P. Chand,et al.  Structural, morphological and optical study of Li doped ZnO thin films on Si (100) substrate deposited by pulsed laser deposition , 2014 .

[42]  D. Lucca,et al.  Frequency shifts of the E2high Raman mode due to residual stress in epitaxial ZnO thin films , 2013 .

[43]  Yuan‐Cheng Cao,et al.  Single-crystalline porous ZnO nanosheet frameworks for efficient fully flexible dye-sensitized solar cells , 2017 .

[44]  Z. Suo,et al.  A transparent bending-insensitive pressure sensor. , 2016, Nature nanotechnology.

[45]  Wenliang Wang,et al.  Lattice Structure and Bandgap Control of 2D GaN Grown on Graphene/Si Heterostructures. , 2019, Small.

[46]  S. Mohammad Nejad,et al.  Recent advances in ultraviolet photodetectors , 2015 .

[47]  Mohamed Salah Aida,et al.  Annealing effects on the structural, electrical and optical properties of ZnO thin films prepared by thermal evaporation technique , 2015 .

[48]  Jow-Lay Huang,et al.  Effect of annealing temperature and atmosphere on aluminum-doped ZnO/Au/aluminum-doped ZnO thin film properties , 2016 .