Environment-enhancing algal biofuel production using wastewaters

The potential of algae-based biofuels to replace petroleum fuels and mitigate greenhouse gas production through microalgal photosynthesis has long been recognized. However, currently there are no commercial algae-to-fuels technologies that can overcome techno-economic barriers and address serious sustainability concerns. Coupling microalgae cultivation with wastewater treatment is considered as one of the most promising routes to produce bio-energy and bio-based byproducts in an economically viable and environmentally friendly way. This paper critically reviews the current status of this specific niche research area covering utilization of different types of wastewaters as media for algae cultivation, microalgae selection, bioreactor type, cultivation mode, environmental factors and operational parameters as well as harvesting techniques and production of a broad spectrum of biofuels and byproducts through various conversion pathways. Future development of practical solutions to key problems and integration of advanced algae cultivation and wastewater treatment, and system analysis approach to the evaluation of economic feasibility and sustainability of wastewater-based algal biofuel production are also discussed in depth.

[1]  W. Oswald,et al.  Biological transformation of solar energy. , 1960, Advances in applied microbiology.

[2]  Paul Chen,et al.  Cultivation of a microalga Chlorella vulgaris using recycled aqueous phase nutrients from hydrothermal carbonization process. , 2012, Bioresource technology.

[3]  Jaakko A Puhakka,et al.  Biogenic hydrogen and methane production from Chlorella vulgaris and Dunaliella tertiolecta biomass , 2011, Biotechnology for biofuels.

[4]  Y. Bashan,et al.  Treatment of recalcitrant wastewater from ethanol and citric acid production using the microalga Chlorella vulgaris and the macrophyte Lemna minuscula. , 2002, Water research.

[5]  G. Shelef,et al.  High-Rate Algae Ponds for Wastewater Treatment and Protein Production , 1982 .

[6]  T. Lundquist,et al.  Algae Grown on Dairy and Municipal Wastewater for Simultaneous Nutrient Removal and Lipid Production for Biofuel Feedstock , 2009 .

[7]  J. Dexter,et al.  Metabolic engineering of cyanobacteria for ethanol production , 2009 .

[8]  Tra-My Justine Richardson,et al.  Microalgae Cultivation Using Offshore Membrane Enclosures for Growing Algae (OMEGA) , 2013 .

[9]  Kimberley A Mullins,et al.  Life cycle environmental impacts of wastewater-based algal biofuels. , 2014, Environmental science & technology.

[10]  Charlotte K. Williams,et al.  The Path Forward for Biofuels and Biomaterials , 2006, Science.

[11]  Y. Wong,et al.  Effect of algal density on nutrient removal from primary settled wastewater , 1995 .

[12]  Paul Chen,et al.  Effect of light intensity on algal biomass accumulation and biodiesel production for mixotrophic strains Chlorella kessleri and Chlorella protothecoide cultivated in highly concentrated municipal wastewater , 2012, Biotechnology and bioengineering.

[13]  Qin Chen,et al.  Microwave-assisted pyrolysis of microalgae for biofuel production. , 2011, Bioresource technology.

[14]  Wen-Tso Liu,et al.  Determination of virus abundance, diversity and distribution in a municipal wastewater treatment plant. , 2009, Water research.

[15]  Jeffrey Philip Obbard,et al.  Two phase microalgae growth in the open system for enhanced lipid productivity , 2011 .

[16]  E. Olguín.  Dual purpose microalgae-bacteria-based systems that treat wastewater and produce biodiesel and chemical products within a biorefinery. , 2012, Biotechnology advances.

[17]  S. Oncel,et al.  Microalgal biohydrogen production considering light energy and mixing time as the two key features for scale-up. , 2012, Bioresource technology.

[18]  Crop residue removal and tillage - Effects on soil erosion and nutrient loss in the corn belt , 1981 .

[19]  R. Lovitt,et al.  Placing microalgae on the biofuels priority list: a review of the technological challenges , 2010, Journal of The Royal Society Interface.

[20]  E.Corbin McGriff,et al.  The removal of nutrients and organics by activated algae , 1972 .

[21]  Yonghui Song,et al.  Effects of solution conditions on the precipitation of phosphate for recovery. A thermodynamic evaluation. , 2002, Chemosphere.

[22]  Yingkuan Wang,et al.  Cultivation of Green Algae Chlorella sp. in Different Wastewaters from Municipal Wastewater Treatment Plant , 2010, Applied biochemistry and biotechnology.

[23]  Mark A. White,et al.  Environmental life cycle comparison of algae to other bioenergy feedstocks. , 2010, Environmental science & technology.

[24]  Z Zhang,et al.  Plasmid stability in recombinant Saccharomyces cerevisiae. , 1996, Biotechnology advances.

[25]  Paul Chen,et al.  Catalytic pyrolysis of microalgae and their three major components: carbohydrates, proteins, and lipids. , 2013, Bioresource technology.

[26]  Y. Chisti.  Biodiesel from microalgae. , 2007, Biotechnology advances.

[27]  R. Ruan,et al.  Novel Fungal Pelletization-Assisted Technology for Algae Harvesting and Wastewater Treatment , 2012, Applied Biochemistry and Biotechnology.

[28]  Jo‐Shu Chang,et al.  Cultivation, photobioreactor design and harvesting of microalgae for biodiesel production: a critical review. , 2011, Bioresource technology.

[29]  Jo‐Shu Chang,et al.  Bioprocess development on microalgae-based CO2 fixation and bioethanol production using Scenedesmus obliquus CNW-N. , 2013, Bioresource technology.

[30]  Andre M. Coleman,et al.  National microalgae biofuel production potential and resource demand , 2011 .

[31]  Andrew Hoadley,et al.  Dewatering of microalgal cultures : a major bottleneck to algae-based fuels , 2010 .

[32]  S. Sim,et al.  Enzymatic pretreatment of Chlamydomonas reinhardtii biomass for ethanol production. , 2010, Bioresource technology.

[33]  Paul Chen,et al.  Cultivating Chlorella sp. in a Pilot-Scale Photobioreactor Using Centrate Wastewater for Microalgae Biomass Production and Wastewater Nutrient Removal , 2011, Applied biochemistry and biotechnology.

[34]  Jian Shi,et al.  Filamentous fungi assisted bio-flocculation: A novel alternative technique for harvesting heterotrophic and autotrophic microalgal cells , 2013 .

[35]  A. Shilton,et al.  Wastewater treatment high rate algal ponds for biofuel production. , 2011, Bioresource technology.

[36]  D. D. Mara,et al.  Solar-powered aeration and disinfection, anaerobic co-digestion, biological CO2 scrubbing and biofuel production: the energy and carbon management opportunities of waste stabilisation ponds. , 2008, Water science and technology : a journal of the International Association on Water Pollution Research.

[37]  J. S. Lee,et al.  Hydrocarbon production from secondarily treated piggery wastewater by the green alga Botryococcus braunii , 2003, Journal of Applied Phycology.

[38]  J. R. Miner,et al.  Algal growth in diluted pig waste , 1975 .

[39]  H. Hong-ying,et al.  Lipid accumulation and nutrient removal properties of a newly isolated freshwater microalga, Scenedesmus sp. LX1, growing in secondary effluent. , 2010, New biotechnology.

[40]  C. Pérez-Martínez,et al.  Growth and nutrient removal in free and immobilized planktonic green algae isolated from pig manure , 2004 .

[41]  Qingyu Wu,et al.  Waste molasses alone displaces glucose-based medium for microalgal fermentation towards cost-saving biodiesel production. , 2011, Bioresource technology.

[42]  Shu-wen Huang,et al.  Bioethanol production using carbohydrate-rich microalgae biomass as feedstock. , 2013, Bioresource technology.

[43]  Mark Z. Jacobson,et al.  Review of solutions to global warming, air pollution, and energy security , 2009 .

[44]  Joe L. Outlaw,et al.  Agriculture as a Producer and Consumer of Energy , 2005 .

[45]  Paul Chen,et al.  Swine Manure-Based Pilot-Scale Algal Biomass Production System for Fuel Production and Wastewater Treatment—a Case Study , 2014, Applied Biochemistry and Biotechnology.

[46]  K. C. Das,et al.  Biomass and bioenergy production potential of microalgae consortium in open and closed bioreactors using untreated carpet industry effluent as growth medium. , 2010, Bioresource technology.

[47]  Paul Chen,et al.  Characterization of a microalga Chlorella sp. well adapted to highly concentrated municipal wastewater for nutrient removal and biodiesel production. , 2011, Bioresource technology.

[48]  Y. Chisti.  Biodiesel from microalgae beats bioethanol. , 2008, Trends in biotechnology.

[49]  D. Voltolina,et al.  Growth of Scenedesmus sp. in artificial wastewater , 1999 .

[50]  G Charles Dismukes,et al.  Aquatic phototrophs: efficient alternatives to land-based crops for biofuels. , 2008, Current opinion in biotechnology.

[51]  Paul Chen,et al.  Enhanced mixotrophic growth of microalga Chlorella sp. on pretreated swine manure for simultaneous biofuel feedstock production and nutrient removal. , 2012, Bioresource technology.

[52]  M. Wong,et al.  Toxic effect of landfill leachate on microalgae , 1993 .

[53]  S. Baena,et al.  Efficiency of ammonia and phosphorus removal from a colombian agroindustrial wastewater by the microalgae Chlorella vulgaris and Scenedesmus dimorphus , 1997 .

[54]  W. Oswald,et al.  Systems and economic analysis of microalgae ponds for conversion of CO2 to biomass , 1994 .

[55]  J. Noüe,et al.  Effect of acetate on growth and ammonium uptake in the microalga Scenedesmus obliquus , 1994 .

[56]  Con Sheahan,et al.  Metabolic engineering of algae for fourth generation biofuels production , 2011 .

[57]  Paul Chen,et al.  A hetero-photoautotrophic two-stage cultivation process to improve wastewater nutrient removal and enhance algal lipid accumulation. , 2012, Bioresource technology.

[58]  Anushree Malik,et al.  Metal bioremediation through growing cells. , 2004, Environment international.

[59]  C. D. Miller,et al.  Acetone, butanol, and ethanol production from wastewater algae. , 2012, Bioresource technology.

[60]  Paul Chen,et al.  Review of biological and engineering aspects of algae to fuels approach , 2009 .

[61]  O. Pulz,et al.  Photobioreactors: production systems for phototrophic microorganisms , 2001, Applied Microbiology and Biotechnology.

[62]  Gassan Hodaifa,et al.  Use of industrial wastewater from olive-oil extraction for biomass production of Scenedesmus obliquus. , 2008, Bioresource technology.

[63]  Duu-Jong Lee,et al.  Microalgae-based biorefinery--from biofuels to natural products. , 2013, Bioresource technology.

[64]  Ann C. Wilkie,et al.  Growth of benthic freshwater algae on dairy manures , 2001, Journal of Applied Phycology.

[65]  Chen Guo,et al.  Microalgal biodiesel in China: Opportunities and challenges , 2011 .

[66]  C. Pizarro,et al.  Recycling of manure nutrients: use of algal biomass from dairy manure treatment as a slow release fertilizer. , 2005, Bioresource technology.

[67]  G. Skjåk-Bræk,et al.  Alginate as immobilization matrix for cells. , 1990, Trends in biotechnology.

[68]  J. Benemann,et al.  Look Back at the U.S. Department of Energy's Aquatic Species Program: Biodiesel from Algae; Close-Out Report , 1998 .

[69]  M. Przytocka-Jusiak,et al.  Studies on the purification of wastewater from the nitrogen fertillizer industry by intensive algal cultures. II. Removal of nitrogen from the wastewater. , 1976, Acta microbiologica Polonica.

[70]  R. Craggs,et al.  Wastewater treatment and algal production in high rate algal ponds with carbon dioxide addition. , 2010, Water science and technology : a journal of the International Association on Water Pollution Research.

[71]  Paul Chen,et al.  Mutual influence of light and CO2 on carbon sequestration via cultivating mixotrophic alga Auxenochlorella protothecoides UMN280 in an organic carbon-rich wastewater , 2011, Journal of Applied Phycology.

[72]  Ryan Davis,et al.  Techno-economic analysis of autotrophic microalgae for fuel production , 2011 .

[73]  J. V. Beilen,et al.  Why microalgal biofuels won't save the internal combustion machine , 2010 .

[74]  Paul Chen,et al.  Mass Cultivation of Microalgae on Animal Wastewater: a Sequential Two-Stage Cultivation Process for Energy Crop and Omega-3-Rich Animal Feed Production , 2012, Applied Biochemistry and Biotechnology.

[75]  S. Tsuru,et al.  Proceedings: Preservation of marine and fresh water algae by means of freezing and freeze-drying. , 1973, Cryobiology.

[76]  Jun Zhu,et al.  Anaerobic digested dairy manure as a nutrient supplement for cultivation of oil-rich green microalgae Chlorella sp. , 2010, Bioresource technology.

[77]  Paul Chen,et al.  Hydrothermal pretreatment of microalgae for production of pyrolytic bio-oil with a low nitrogen content. , 2012, Bioresource technology.

[78]  John R. Coleman,et al.  Ethanol Synthesis by Genetic Engineering in Cyanobacteria , 1999, Applied and Environmental Microbiology.

[79]  Q. Hu,et al.  Microalgal triacylglycerols as feedstocks for biofuel production: perspectives and advances. , 2008, The Plant journal : for cell and molecular biology.

[80]  B. Ibelings,et al.  Parasitic chytrids: their effects on phytoplankton communities and food-web dynamics , 2007, Hydrobiologia.

[81]  Willy Verstraete,et al.  Anaerobic digestibility of marine microalgae Phaeodactylum tricornutum in a lab-scale anaerobic membrane bioreactor , 2011, Applied Microbiology and Biotechnology.

[82]  Paul Chen,et al.  Influence of Exogenous CO2 on Biomass and Lipid Accumulation of Microalgae Auxenochlorella protothecoides Cultivated in Concentrated Municipal Wastewater , 2012, Applied Biochemistry and Biotechnology.

[83]  Manjinder Singh,et al.  Microalgal system for treatment of effluent from poultry litter anaerobic digestion. , 2011, Bioresource technology.

[84]  Paul Chen,et al.  Development of an effective acidogenically digested swine manure-based algal system for improved wastewater treatment and biofuel and feed production , 2013 .

[85]  René H. Wijffels,et al.  Harvesting of microalgae by bio-flocculation , 2010, Journal of Applied Phycology.

[86]  Eric E. Jarvis,et al.  Manipulation of microalgal lipid production using genetic engineering , 1996 .

[87]  J. Noüe,et al.  Intensive cultivation of freshwater microalgae on aerated pig manure , 1985 .

[88]  Göran Berndes,et al.  The contribution of biomass in the future global energy supply: a review of 17 studies , 2003 .

[89]  Feng Chen,et al.  Eicosapentaenoic acid and docosahexaenoic acid production potential of microalgae and their heterotrophic growth , 1998 .

[90]  Paul Chen,et al.  Algae were cultured in the artificial culture media containing the following ingredients : NaNO , 2009 .

[91]  Chunfang Gao,et al.  Double CO(2) fixation in photosynthesis-fermentation model enhances algal lipid synthesis for biodiesel production. , 2010, Bioresource technology.

[92]  Lewis M. Brown,et al.  Genetic Engineering Approaches for Enhanced Production of Biodiesel Fuel from Microalgae , 1994 .

[93]  O. Pulz,et al.  Fast and unambiguous determination of EPA and DHA content in oil of selected strains of algae and cyanobacteria. , 2009 .

[94]  N. Mallick.  Biotechnological potential of immobilized algae for wastewater N, P and metal removal: A review , 2002, Biometals.

[95]  Paul Chen,et al.  Growing wastewater-born microalga Auxenochlorella protothecoides UMN280 on concentrated municipal wastewater for simultaneous nutrient removal and energy feedstock production , 2012 .

[96]  Walter Mulbry,et al.  Treatment of dairy and swine manure effluents using freshwater algae: fatty acid content and composition of algal biomass at different manure loading rates , 2008, Journal of Applied Phycology.

[97]  Y. Bashan,et al.  Immobilized microalgae for removing pollutants: review of practical aspects. , 2010, Bioresource technology.

[98]  Y. Wong,et al.  Wastewater nutrient removal by Chlorella pyrenoidosa and Scenedesmus sp. , 1989, Environmental pollution.

[99]  D. Goyal,et al.  Microbial and plant derived biomass for removal of heavy metals from wastewater. , 2007, Bioresource technology.

[100]  X. Miao,et al.  Biodiesel production from heterotrophic microalgal oil. , 2006, Bioresource technology.

[101]  J. Pittman,et al.  The potential of sustainable algal biofuel production using wastewater resources. , 2011, Bioresource technology.

[102]  A. Darzins,et al.  The promise and challenges of microalgal‐derived biofuels , 2009 .

[103]  J. Dewulf,et al.  Enhanced CO(2) fixation and biofuel production via microalgae: recent developments and future directions. , 2010, Trends in biotechnology.

[104]  Y. Wong,et al.  The Comparison of Growth and Nutrient Removal Efficiency of Chlorella pyrenoidosa in Settled and Activated Sewages , 1989 .

[105]  Q. Hu,et al.  Life-cycle analysis on biodiesel production from microalgae: water footprint and nutrients balance. , 2011, Bioresource technology.

[106]  M. Huntley,et al.  CO2 Mitigation and Renewable Oil from Photosynthetic Microbes: A New Appraisal , 2007 .

[107]  Paul Chen,et al.  Local bioprospecting for high-lipid producing microalgal strains to be grown on concentrated municipal wastewater for biofuel production. , 2011, Bioresource technology.

[108]  I. Kapdan,et al.  Batch kinetics of nitrogen and phosphorus removal from synthetic wastewater by algae , 2006 .

[109]  Yutaka Dote,et al.  Growth of the hydrocarbon-rich microalga Botryococcus braunii in secondarily treated sewage , 1992, Applied Microbiology and Biotechnology.

[110]  K. Jeune,et al.  Use of FT-IR to identify enhanced biomass production and biochemical pool shifts in the marine microalgae, Chlorella ovalis, cultured in media composed of different ratios of deep seawater and fermented animal wastewater. , 2009, Journal of microbiology and biotechnology.

[111]  K. L Kadam,et al.  Environmental implications of power generation via coal-microalgae cofiring , 2002 .

[112]  Ann C Wilkie,et al.  Recovery of dairy manure nutrients by benthic freshwater algae. , 2002, Bioresource technology.

[113]  Olivier Bernard,et al.  Anaerobic digestion of microalgae as a necessary step to make microalgal biodiesel sustainable. , 2009, Biotechnology advances.

[114]  Benoit Guieysse,et al.  Algal-bacterial processes for the treatment of hazardous contaminants: a review. , 2006, Water research.

[115]  M. Wong,et al.  Properties of animal manures and sewage sludges and their utilisation for algal growth , 1981 .