Engineering Study of a Pilot Scale Process Plant for Microalgae-Oil Production Utilizing Municipal Wastewater and Flue Gases: Fukushima Pilot Plant

This article presents an engineering study of an integrated system to produce bio-oil from microalgae biomass. The analysis is based on a pilot plant located at Minami-soma Fukushima, Japan, which further simulates 1 ha based-cultivation. Municipal wastewater and flue gases were utilized as nutrient sources for the microalgae culture of the proposed design. A flow sheet diagram of the integrated plant was synthesized by process engineering software to allow simulation of a continuous system. The design and sizing of the process equipment were performed to obtain a realistic estimation of possible production cost. The results demonstrated that nutrient savings was achieved by wastewater and CO 2 utilization to the polyculture of native microalgae. Process simulation gave an estimated CO 2 sequestration of 82.77 to 140.58 tons ha −1 year −1 with 63 to 107 tons ha −1 year −1 of potential biomass production. The integrated process significantly improved the energy balance and economics of biofuel production and also the wastewater treatment plant (WWTP). The economic analysis confirmed that higher biomass production and technology improvement were required to achieve operational feasibility and profitability of the current microalgae-based bio-oil production.

[1]  H. Kariminia,et al.  Lipid production in mixotrophic cultivation of Chlorella vulgaris in a mixture of primary and secondary municipal wastewater , 2014 .

[2]  R. Sen,et al.  Metabolic pathway engineering towards enhancing microalgal lipid biosynthesis for biofuel application—A review , 2015 .

[3]  Mikihide Demura,et al.  Biomass productivity of native algal communities in Minamisoma city, Fukushima Prefecture, Japan , 2018 .

[4]  D. Barreiro,et al.  Hydrothermal liquefaction (HTL) of microalgae for biofuel production: State of the art review and future prospects , 2013 .

[5]  L. Laurens,et al.  Lipid recovery from wet oleaginous microbial biomass for biofuel production: A critical review , 2016 .

[6]  R. Ptáčník,et al.  Performance of the Redfield Ratio and a Family of Nutrient Limitation Indicators as Thresholds for Phytoplankton N vs. P Limitation , 2010, Ecosystems.

[7]  Sonia Heaven,et al.  A review of the harvesting of micro-algae for biofuel production , 2013, Reviews in Environmental Science and Bio/Technology.

[8]  P. Broady,et al.  Enhancing microalgal photosynthesis and productivity in wastewater treatment high rate algal ponds for biofuel production. , 2015, Bioresource technology.

[9]  S. Venkata Mohan,et al.  Heterotrophic cultivation of mixed microalgae for lipid accumulation and wastewater treatment during sequential growth and starvation phases: Effect of nutrient supplementation , 2012 .

[10]  T. Ahamed,et al.  Introduction of Integrated Energy Plantation Model for Microalgae-Using Palm Oil Mill Effluent (POME) , 2015 .

[11]  Y. Chisti.  Large-Scale Production of Algal Biomass: Raceway Ponds , 2016 .

[12]  Andrew J. Schmidt,et al.  Process Design and Economics for the Conversion of Algal Biomass to Hydrocarbons: Whole Algae Hydrothermal Liquefaction and Upgrading , 2014 .

[13]  Jean-Luc Achard,et al.  An Overview of Microalgae Lipid Extraction in a Biorefinery Framework , 2017 .

[14]  Yoshiro Higano,et al.  Perspective assessment of algae-based biofuel production using recycled nutrient sources: the case of Japan. , 2013, Bioresource technology.

[15]  A. Panico,et al.  Experimental study for the reduction of CO2 emissions in wastewater treatment plant using microalgal cultivation , 2017 .

[16]  P. Lammers,et al.  Feasibility of algal systems for sustainable wastewater treatment , 2015 .

[17]  S. Watanabe,et al.  Development of Botryococcus Seed Culture System for Future Mass Culture , 2012 .

[18]  Arnaud Hélias,et al.  Biodiesel from microalgae - life cycle assessment and recommendations for potential improvements. , 2014 .

[19]  Ganti S. Murthy,et al.  Effects of Environmental Factors and Nutrient Availability on the Biochemical Composition of Algae for Biofuels Production: A Review , 2013 .

[20]  Susanne B. Jones,et al.  Hydrothermal liquefaction of biomass: developments from batch to continuous process. , 2015, Bioresource technology.

[21]  Jacco C. Kromkamp,et al.  A computer model of buoyancy and vertical migration in cyanobacteria , 1990 .

[22]  Kristina M. Weyer,et al.  Theoretical Maximum Algal Oil Production , 2009, BioEnergy Research.

[23]  Raphael Slade,et al.  Micro-algae cultivation for biofuels: Cost, energy balance, environmental impacts and future prospects , 2013 .

[24]  M. Farid,et al.  Wastewater treatment high rate algal ponds (WWT HRAP) for low-cost biofuel production. , 2015, Bioresource technology.

[25]  R. Craggs,et al.  Hectare-scale demonstration of high rate algal ponds for enhanced wastewater treatment and biofuel production , 2012, Journal of Applied Phycology.

[26]  A. Fathi,et al.  Phycoremediation and the potential of sustainable algal biofuel production using wastewater. , 2013 .

[27]  J. Benemann,et al.  Wastewater Treatment Pond Algal Production for Biofuel , 2012 .

[28]  Hwai Chyuan Ong,et al.  Cultivation of Chlorella vulgaris using nutrients source from domestic wastewater for biodiesel production: Growth condition and kinetic studies , 2017 .

[29]  Priyanka Singh,et al.  Effect of CO2 concentration on algal growth: A review , 2014 .

[30]  A. C. Redfield.  The biological control of chemical factors in the environment. , 1960, Science progress.

[31]  J. Passarge,et al.  Modelling vertical migration of the cyanobacterium Microcystis , 1997, Hydrobiologia.

[32]  René H. Wijffels,et al.  Scenario Analysis of Nutrient Removal from Municipal Wastewater by Microalgal Biofilms , 2012 .

[33]  Jixiang Zhang,et al.  Hydrothermal liquefaction of mixed-culture algal biomass from wastewater treatment system into bio-crude oil. , 2014, Bioresource technology.

[34]  Amanda Lea-Langton,et al.  Nutrient recycling of aqueous phase for microalgae cultivation from the hydrothermal liquefaction process , 2012 .

[35]  Thore Berntsson,et al.  Algae-based biofuel production as part of an industrial cluster , 2014 .

[36]  J. E. Coons,et al.  Getting to low-cost algal biofuels: A monograph on conventional and cutting-edge harvesting and extraction technologies , 2014 .

[37]  Jesse W. Campbell,et al.  Production of Biodiesel and Biogas from Algae: A Review of Process Train Options , 2011, Water environment research : a research publication of the Water Environment Federation.

[38]  Mahmoud M. El-Halwagi,et al.  A review of biodiesel production from microalgae , 2017, Clean Technologies and Environmental Policy.

[39]  J. Pittman,et al.  The potential of sustainable algal biofuel production using wastewater resources. , 2011, Bioresource technology.

[40]  Richard J. Brown,et al.  A review of hydrothermal liquefaction bio-crude properties and prospects for upgrading to transportation fuels , 2015 .

[41]  R. Geider,et al.  Redfield revisited: variability of C:N:P in marine microalgae and its biochemical basis , 2002 .

[42]  T. Smayda.  The suspension and sinking of phytoplankton in the sea , 1970 .

[43]  C. Posten,et al.  Microalgae and terrestrial biomass as source for fuels--a process view. , 2009, Journal of biotechnology.

[44]  T. Ahamed,et al.  Environmental load assessment for an integrated design of microalgae system of palm oil mill in Indonesia , 2018, Energy.

[45]  L. Peperzak,et al.  Separation of marine seston and density determination of marine diatoms by density gradient centrifugation , 1984 .

[46]  Xing Zhang.  Microalgae removal of CO2 from flue gas , 2015 .

[47]  Brajendra Kumar Sharma,et al.  Hydroprocessing of bio-crude from continuous hydrothermal liquefaction of microalgae , 2015 .

[48]  D. Vandamme.  Flocculation based harvesting processes for microalgae biomass production , 2013 .

[49]  Wen J Hu.  Dry Weight and Cell Density of Individual Algal and Cyanobacterial Cells for Algae Research and Development , 2014 .

[50]  Julian N. Rosenberg,et al.  A critical analysis of paddlewheel-driven raceway ponds for algal biofuel production at commercial scales , 2014 .

[51]  M. Borowitzka.  High-value products from microalgae—their development and commercialisation , 2013, Journal of Applied Phycology.

[52]  Derek R. Vardon.  Hydrothermal liquefaction for energy recovery from high-moisture waste biomass , 2012 .

[53]  Duu-Jong Lee,et al.  Sustainable approaches for algae utilisation in bioenergy production , 2017, Renewable Energy.