Profiling of oxygen in biofilms using individually addressable disk microelectrodes on a microfabricated needle

AbstractA novel microelectrode array sensor was fabricated using MEMS technology on a needle, and then applied to real-time measurement of dissolved oxygen (DO) inside biofilms. The sensor consists of eleven gold disk microelectrodes, a rectangular auxiliary electrode along them, and an external and internal reference electrode. Three kinds of sensors were designed and their responses were characterized and evaluated under various conditions. The arrays exhibit a linear response to DO in the 0–8 mg·L−1 concentration range in water, high sensitivity, repeatability, and low limits of detection (<0.11 mg·L−1 of DO) and quantification (0.38 mg·L−1 DO). The sensors were validated against a commercial Clark-type microelectrode and applied to profiling of DO in a heterotrophic biofilm cultivated in a flat-plate bioreactor. It is shown that the sensor array can provide a multipoint, simultaneous snapshot profile of DO inside a biofilm with high spatial resolution due to its micrometric dimensions. We conclude that this new sensor array represents a powerful tool for sensing of DO biofilms and in numerous bioprocesses. Graphical AbstractA microelectrode array sensor for real-time measurement of dissolved oxygen (DO) is presented for use in  multipoint and simultaneous snapshot profiling of DO in a biofilm. The sensor has been validated against a commercial Clark-type.

[1]  Tong Yu,et al.  Development of an automation system to evaluate the three-dimensional oxygen distribution in wastewater biofilms using microsensors , 2006 .

[2]  Xiaohong Zhou,et al.  Estimation of Heterotrophic Biokinetic Parameters in Wastewater Biofilms from Oxygen Concentration Profiles by Microelectrode , 2012 .

[3]  M. He,et al.  A new approach to quantify spatial distribution of biofilm kinetic parameters by in situ determination of oxygen uptake rate (OUR). , 2009, Environmental science & technology.

[4]  D. Arrigan,et al.  Recessed nanoband electrodes fabricated by focused ion beam milling , 2007 .

[5]  R. Compton,et al.  Mass Transport to Nanoelectrode Arrays and Limitations of the Diffusion Domain Approach: Theory and Experiment , 2009 .

[6]  E. Baldrich,et al.  Electrochemical detection of testosterone by use of three-dimensional disc-ring microelectrode sensing platforms: application to doping monitoring. , 2011, Analytical chemistry.

[7]  Francesc Xavier Muñoz,et al.  Continuous measurement of acute toxicity in water using a solid state microrespirometer , 2007 .

[8]  Tae-Sun Lim,et al.  Needle-type dissolved oxygen microelectrode array sensors for in situ measurements , 2007 .

[9]  Horacio A. Mottola,et al.  Enzymic substrate determination in closed flow-through systems by sample injection and amperometric monitoring of dissolved oxygen levels , 1978 .

[10]  Haluk Beyenal,et al.  Fundamentals of biofilm research , 2007 .

[11]  Y. Cohen,et al.  Biofiltration--the treatment of fluids by microorganisms immobilized into the filter bedding material: a review. , 2001, Bioresource technology.

[12]  R. Compton,et al.  Microarrays of ring-recessed disk electrodes in transient generator-collector mode: theory and experiment. , 2009, Analytical chemistry.

[13]  Z. Lewandowski,et al.  Fundamentals of Biofilm Research, Second Edition , 2013 .

[14]  F. J. D. Campo,et al.  High Aspect-Ratio, Fully Conducting Gold Micropillar Array Electrodes: Silicon Micromachining and Electrochemical Characterization , 2012 .

[15]  F. Fang,et al.  Development of an in situ dissolved oxygen measurement system and calculation of its effective diffusion coefficient in a biofilm , 2012 .

[16]  Carlos Paliteiro,et al.  (100)-Type behaviour of polycrystalline gold towards O2 reduction , 1994 .

[17]  Control of electrode aging by a periodic anodization technique. , 1976, Advances in experimental medicine and biology.

[18]  Xavier Borrisé,et al.  Determination of heterogeneous electron transfer rate constants at interdigitated nanoband electrodes fabricated by an optical mix-and-match process , 2014 .

[19]  M. Gavrilescu,et al.  Attached-growth process engineering in wastewater treatment , 2000 .

[20]  F. Schreiber,et al.  Aerobic denitrification in permeable Wadden Sea sediments , 2010, The ISME Journal.

[21]  M. Kühl,et al.  A H2S microsensor for profiling biofilms and sediments: application in an acidic lake sediment , 1998 .

[22]  O. Wolfbeis,et al.  Optical methods for sensing and imaging oxygen: materials, spectroscopies and applications. , 2014, Chemical Society reviews.

[23]  J. Wingender,et al.  Chemical and physical methods for characterisation of biofilms , 2007 .

[24]  Plane-recessed disk electrodes and their arrays in transient generator–collector mode: The measurement of the rate of the chemical reaction of electrochemically generated species , 2010 .

[25]  Tomoyuki Yasukawa,et al.  Fabrication of miniature Clark oxygen sensor integrated with microstructure , 2005 .

[26]  R WOLF,et al.  Continuous recording of blood oxygen tensions by polarography. , 1953, Journal of applied physiology.

[27]  S. Okabe,et al.  Analyses of Spatial Distributions of Sulfate-Reducing Bacteria and Their Activity in Aerobic Wastewater Biofilms , 1999, Applied and Environmental Microbiology.

[28]  M. Duch,et al.  Microfabrication and characterization of cylinder micropillar array electrodes , 2011 .

[29]  M. D. Rooij,et al.  Electrochemical Methods: Fundamentals and Applications , 2003 .

[30]  Francesc Xavier Muñoz,et al.  Electroanalysis Utilizing Amperometric Microdisk Electrode Arrays , 2007 .

[31]  B. Jørgensen,et al.  Microelectrodes: Their Use in Microbial Ecology , 1986 .

[32]  Anja Boisen,et al.  Gold cleaning methods for electrochemical detection applications , 2009 .

[33]  C. Banks,et al.  The cyclic and linear sweep voltammetry of regular arrays of microdisc electrodes : Fitting of experimental data , 2005 .

[34]  J. Dewulf,et al.  Oxygen transport within the biofilm matrix of a membrane biofilm reactor treating gaseous toluene , 2012 .

[35]  Juan A. Baeza,et al.  Biomass accumulation in a biofilter treating toluene at high loads – Part 1: Experimental performance from inoculation to clogging , 2012 .