Implementation of internal model based control and individual pitch control to reduce fatigue loads and tower vibrations in wind turbines

Abstract Vibration control and fatigue loads reduction are important issues in large-scale wind turbines. Identifying the vibration frequencies and tuning dampers and controllers at these frequencies are major concerns in many control methods. In this paper, an internal model control (IMC) method with an adaptive algorithm is implemented to first identify the vibration frequency of the wind turbine tower and then to cancel the vibration signal. Standard individual pitch control (IPC) is also implemented to compare the performance of the controllers in term of fatigue loads reduction. Finally, the performance of the system when both controllers are implemented together is evaluated. Simulation results demonstrate that using only IMC or IPC alone has advantages and can reduce fatigue loads on specific components. IMC can identify and suppress tower vibrations in both fore-aft and side-to-side directions, whereas, IPC can reduce fatigue loads on blades, shaft and yaw bearings. When both IMC and IPC are implemented together, the advantages of both controllers can be used. The aforementioned analysis and comparisons were not studied in literature and this study fills this gap. FAST, AreoDyn and Simulink are used to simulate the mechanical, aerodynamic and electrical aspects of wind turbine.

[1]  Biswajit Basu,et al.  Dynamics and control of vibrations in wind turbines with variable rotor speed , 2013 .

[2]  Bruce A. Francis,et al.  The internal model principle of control theory , 1976, Autom..

[3]  Biswajit Basu,et al.  Tuned liquid column dampers in offshore wind turbines for structural control , 2009 .

[4]  Zhipeng Feng,et al.  Complex signal analysis for wind turbine planetary gearbox fault diagnosis via iterative atomic decomposition thresholding , 2014 .

[5]  Liu Hong,et al.  A time domain approach to diagnose gearbox fault based on measured vibration signals , 2014 .

[6]  N. Peric,et al.  Individual pitch control of wind turbine based on loads estimation , 2008, 2008 34th Annual Conference of IEEE Industrial Electronics.

[7]  Yolanda Vidal,et al.  Fault Diagnosis and Fault-Tolerant Control of Wind Turbines via a Discrete Time Controller with a Disturbance Compensator , 2015 .

[8]  W.E. Leithead,et al.  Controller Design for the Cancellation of the Tower Fore-aft Mode in a Wind Turbine , 2005, Proceedings of the 44th IEEE Conference on Decision and Control.

[9]  Henry Hong,et al.  Wind Turbine Fault Diagnosis and Fault-Tolerant Torque Load Control Against Actuator Faults , 2015, IEEE Transactions on Control Systems Technology.

[10]  Ervin Bossanyi,et al.  Individual Blade Pitch Control for Load Reduction , 2003 .

[11]  Liang Huang,et al.  Experimental study and numerical simulation of active vibration control of a highly flexible beam using piezoelectric intelligent material , 2014 .

[12]  J. Landaluze,et al.  H∞ Based Control for Load Mitigation in Wind Turbines , 2012 .

[13]  Nicola Caterino,et al.  Semi-active control of a wind turbine via magnetorheological dampers , 2015 .

[14]  Hamid Reza Karimi,et al.  Semiactive vibration control of offshore wind turbine towers with tuned liquid column dampers using H∞ output feedback control , 2010, 2010 IEEE International Conference on Control Applications.

[15]  Søren Nielsen,et al.  Actuator Control of Edgewise Vibrations in Wind Turbine Blades , 2012 .

[16]  Roohollah Fadaeinedjad,et al.  A new control strategy to suppress the tower vibrations of variable speed wind turbines , 2014 .

[17]  Søren Nielsen,et al.  Mitigation of edgewise vibrations in wind turbine blades by means of roller dampers , 2014 .

[18]  A. D. Wright,et al.  Advanced Control Design for Wind Turbines; Part I: Control Design, Implementation, and Initial Tests , 2008 .

[19]  Christos T. Georgakis,et al.  Tuned rolling-ball dampers for vibration control in wind turbines , 2013 .

[20]  S. Krenk,et al.  Resonant vibration control of three-bladed wind turbine rotors , 2012 .

[21]  Wenyi Liu,et al.  Wind turbine fault diagnosis based on Morlet wavelet transformation and Wigner-Ville distribution , 2010 .

[22]  Karl Stol,et al.  Performance analysis of individual blade pitch control of offshore wind turbines on two floating platforms , 2011 .

[23]  R. H. Park,et al.  Two-reaction theory of synchronous machines generalized method of analysis-part I , 1929, Transactions of the American Institute of Electrical Engineers.

[24]  Qing Zhang,et al.  Identification of periodic signals with uncertain frequency , 2003, IEEE Trans. Signal Process..

[25]  Patrick Moriarty,et al.  AeroDyn Theory Manual , 2005 .

[26]  Francesc Pozo,et al.  Wind Turbine Fault Detection through Principal Component Analysis and Statistical Hypothesis Testing , 2015 .

[27]  Alan Wright,et al.  Adding feedforward blade pitch control to standard feedback controllers for load mitigation in wind turbines , 2011 .

[28]  Mario A. Rotea,et al.  Passive structural control of offshore wind turbines , 2011 .

[29]  Spilios D. Fassois,et al.  A supervised vibration-based statistical methodology for damage detection under varying environmental conditions & its laboratory assessment with a scale wind turbine blade☆ , 2016 .

[30]  Mehrdad Moallem,et al.  Investigation of Voltage Sag Impact on Wind Turbine Tower Vibrations , 2008 .

[31]  Yinghui Li,et al.  Flapwise dynamic response of a wind turbine blade in super-harmonic resonance , 2012 .

[32]  Søren Nielsen,et al.  Dynamics and Control of Lateral Tower Vibrations in Offshore Wind Turbines by Means of Active Generator Torque , 2014 .

[33]  Spilios D. Fassois,et al.  Stationary and non-stationary random vibration modelling and analysis for an operating wind turbine , 2014 .

[34]  Qing Zhang,et al.  Periodic disturbance cancellation with uncertain frequency , 2004, Autom..