Technology and device scaling considerations for CMOS imagers

This paper presents an analysis of the impact of device and technology scaling on active pixel CMOS image sensors. Using the SLA roadmap as a guideline, we calculate the device characteristics that are germane to the image sensing performance of CMOS imagers, and highlight the areas where the CIMOS imager technology may need to depart from "standard" CMOS technologies. The impact of scaling on those analog circuit performance that pertain to image sensing performances are analyzed. Our analyses suggest that while "standard" CMOS technologies may provide adequate imaging performance at the 2-1 /spl mu/m generation without any process change, some modifications to the fabrication process and innovations of the pixel architecture are needed to enable CMOS to perform good quality imaging at the 0.5 /spl mu/m technology generation and beyond. Finally, the challenges to the CMOS imager research community are outlined.

[1]  E. Fossum,et al.  CMOS active pixel image sensors for highly integrated imaging systems , 1997, IEEE J. Solid State Circuits.

[2]  A.A. Abidi,et al.  An analog CMOS network for Gaussian convolution with embedded image sensing , 1990, 1990 37th IEEE International Conference on Solid-State Circuits.

[3]  Kwok Y. Wong,et al.  Four-million-pixel CCD image sensor , 1990, Other Conferences.

[4]  M. C. Jeng,et al.  A physical model for MOSFET output resistance , 1992, 1992 International Technical Digest on Electron Devices Meeting.

[5]  Marvin H. White.  Photodiode Sensor Arrays , 1976 .

[6]  Masayuki Sugawara,et al.  An amplified MOS imager suited for image processing , 1994, Proceedings of IEEE International Solid-State Circuits Conference - ISSCC '94.

[7]  Eric R. Fossum,et al.  CMOS image sensors: electronic camera on a chip , 1995, Proceedings of International Electron Devices Meeting.

[8]  E. Roks,et al.  A S-VHS compatible 1/3" 720(H)*588(V) FT-CCD with low dark current by surface pinning , 1992, 1992 International Technical Digest on Electron Devices Meeting.

[9]  F. Van de Wiele,et al.  Photodiode quantum efficiency , 1976 .

[10]  G. P. Weckler,et al.  Operation of p-n Junction Photodetectors in a Photon Flux Integrating Mode , 1967 .

[11]  J. Hynecek.  A new device architecture suitable for high-resolution and high-performance image sensors , 1988 .

[12]  S. G. Chamberlain.  Photosensitivity and Scanning of Silicon Image Detector Arrays , 1969 .

[13]  R. M. Swanson,et al.  Measurement of electron lifetime, electron mobility and band-gap narrowing in heavily doped p-type silicon , 1986, 1986 International Electron Devices Meeting.

[14]  H. Momose,et al.  Characterization of two step impact ionization and its influence in NMOS and PMOS VLSI's , 1980, 1980 International Electron Devices Meeting.

[15]  Yuan Taur,et al.  A high-performance 0.25- mu m CMOS technology. I. Design and characterization , 1992 .

[16]  Yuan Taur,et al.  CMOS scaling into the 21st century: 0.1 µm and beyond , 1995, IBM J. Res. Dev..

[17]  Eric G. Stevens,et al.  A large area 1.3-megapixel full-frame CCD image sensor with a lateral-overflow drain and a transparent gate electrode , 1990, International Technical Digest on Electron Devices.

[18]  J. Yamada,et al.  1 V power supply, low-power consumption A/D conversion technique with swing-suppression noise shaping , 1994 .

[19]  David Renshaw,et al.  CMOS image sensors for multimedia applications , 1993, Proceedings of IEEE Custom Integrated Circuits Conference - CICC '93.

[20]  Akira Matsuzawa.  Low-voltage and low-power circuit design for mixed analog/digital systems in portable equipment , 1994 .

[21]  E. Fossum,et al.  Measurement of hole leakage and impact ionization currents in bistable metal—tunnel-oxide—semiconductor junctions , 1984, IEEE Transactions on Electron Devices.

[22]  Lawrence A. Clevenger,et al.  Investigation of titanium silicide formation in Ti+Si reactions using infrared spectroscopy and x‐ray diffraction , 1995 .

[23]  E. Palik.  Handbook of Optical Constants of Solids , 1997 .

[24]  D. A. Buchanan,et al.  GROWTH, CHARACTERIZATION AND THE LIMITS OF ULTRATHIN SiO,-BASED DIELECTRICS FOR FUTURE CMOS APPLICATIONS , 1996 .

[25]  Woodward Yang,et al.  A wide-dynamic-range, low-power photosensor array , 1994, Proceedings of IEEE International Solid-State Circuits Conference - ISSCC '94.

[26]  Eric R. Fossum,et al.  Active pixel sensors: are CCDs dinosaurs? , 1993, Electronic Imaging.

[27]  Sunetra K. Mendis,et al.  A 128/spl times/128 CMOS active pixel image sensor for highly integrated imaging systems , 1993, Proceedings of IEEE International Electron Devices Meeting.

[28]  Jean-Pierre Colinge,et al.  Recent advances in SOI technology , 1994, Proceedings of 1994 IEEE International Electron Devices Meeting.

[29]  A. Dickinson,et al.  Camera on a chip , 1996, 1996 IEEE International Solid-State Circuits Conference. Digest of TEchnical Papers, ISSCC.

[30]  Charles G. Sodini,et al.  A framework to evaluate technology and device design enhancements for MOS integrated circuits , 1989 .

[31]  Bruce A. Wooley,et al.  The effects of impact ionization on the operation of neighboring devices and circuits , 1994 .

[32]  Sunetra K. Mendis,et al.  CMOS active pixel image sensor , 1994 .

[33]  Y. Taur,et al.  A high-performance 0.25- mu m CMOS technology. II. Technology , 1992 .

[34]  H. Kawashima,et al.  A 1/4 inch format 250 K pixel amplified MOS image sensor using CMOS process , 1993, Proceedings of IEEE International Electron Devices Meeting.

[35]  Dimitri A. Antoniadis,et al.  Tradeoffs of current drive vs. short-channel effect in deep-submicrometer bulk and SOI MOSFETs , 1994, Proceedings of 1994 IEEE International Electron Devices Meeting.

[36]  K. Miyata,et al.  A 250000-pixel image sensor with FET amplification at each pixel for high-speed television cameras , 1990, 1990 37th IEEE International Conference on Solid-State Circuits.

[37]  David Renshaw,et al.  ASIC image sensors , 1990, IEEE International Symposium on Circuits and Systems.

[38]  O. Vellacott.  CMOS in camera , 1994 .

[39]  J. Hynecek.  BCMD-An improved photosite structure for high-density image sensors , 1991 .

[40]  R. Bez,et al.  A test pattern to investigate the effect of capping layers on the hot carrier induced photon spectra of MOSFETs , 1994, Proceedings of 1994 IEEE International Conference on Microelectronic Test Structures.

[41]  Marvin H. White,et al.  Characterization of surface channel CCD image arrays at low light levels , 1974 .

[42]  R. Fair,et al.  Zener and avalanche breakdown in As-implanted low-voltage Si n-p junctions , 1976, IEEE Transactions on Electron Devices.

[43]  Toshio Sunaga,et al.  DRAM macros for ASIC chips , 1995 .

[44]  Eugene S. Schlig,et al.  TDI charge-coupled devices: Design and applications , 1992, IBM J. Res. Dev..

[45]  Hon-Sum Philip Wong.  Experimental verification of the mechanism of hot-carrier-induced photon emission in n-MOSFET's with a CCD gate structure , 1991, International Electron Devices Meeting 1991 [Technical Digest].

[46]  Bryan D. Ackland,et al.  Standard CMOS active pixel image sensors for multimedia applications , 1995, Proceedings Sixteenth Conference on Advanced Research in VLSI.

[47]  A. Theuwissen,et al.  Solid-State Imaging with Charge-Coupled Devices , 1995 .

[48]  B. Wooley,et al.  A 128/spl times/128-pixel standard CMOS image sensor with electronic shutter , 1996, 1996 IEEE International Solid-State Circuits Conference. Digest of TEchnical Papers, ISSCC.

[49]  H. Miyazawa,et al.  A system-integrate ULSI chip containing eleven 4 Mb RAMs, six 64 kb SRAMs and an 18 k gate array , 1992, 1992 IEEE International Solid-State Circuits Conference Digest of Technical Papers.

[50]  E. R. Fossum,et al.  Low power camera-on-a-chip using CMOS active pixel sensor technology , 1995, 1995 IEEE Symposium on Low Power Electronics. Digest of Technical Papers.

[51]  I. Takayanagi,et al.  A multiple output CMD imager for real-time image processing , 1993, Proceedings of IEEE International Electron Devices Meeting.

[52]  Yuan Taur,et al.  Design and performance considerations for sub-0.1 /spl mu/m double-gate SOI MOSFET'S , 1994, Proceedings of 1994 IEEE International Electron Devices Meeting.

[53]  K. Matsumoto,et al.  A new MOS image sensor operating in a non-destructive readout mode , 1986, 1986 International Electron Devices Meeting.

[54]  J. P. Lavine,et al.  The pinned photodiode for an interline-transfer CCD image sensor , 1984, 1984 International Electron Devices Meeting.

[55]  Tsutomu Nakamura,et al.  A 2/3-inch 2M-pixel CMD image sensor with multi-scanning function , 1993, 1993 IEEE International Solid-State Circuits Conference Digest of Technical Papers.

[56]  B. Fowler,et al.  A CMOS area image sensor with pixel-level A/D conversion , 1994, Proceedings of IEEE International Solid-State Circuits Conference - ISSCC '94.

[57]  A. Dickinson,et al.  A 256/spl times/256 CMOS active pixel image sensor with motion detection , 1995, Proceedings ISSCC '95 - International Solid-State Circuits Conference.

[58]  E.R. Fossum,et al.  256/spl times/256 CMOS active pixel sensor camera-on-a-chip , 1996, 1996 IEEE International Solid-State Circuits Conference. Digest of TEchnical Papers, ISSCC.

[59]  P. Noble,et al.  Self-scanned silicon image detector arrays , 1968 .

[60]  B. Dierickx,et al.  Random addressable CMOS image sensor for industrial applications , 1994 .

[61]  S. Kohyama,et al.  An electrical mechanism for holding time degradation in dynamic MOS RAM's , 1979, IEEE Transactions on Electron Devices.

[62]  Seiichi Miyazaki,et al.  Electron Tunneling through Ultrathin Gate Oxide Formed on Hydrogen-Terminated Si(100) Surfaces , 1994 .

[63]  Hiroshi Iwai,et al.  Tunneling gate oxide approach to ultra-high current drive in small geometry MOSFETs , 1994, Proceedings of 1994 IEEE International Electron Devices Meeting.

[64]  E.R. Fossum,et al.  128 Mb/s multiport CMOS binary active-pixel image sensor , 1996, 1996 IEEE International Solid-State Circuits Conference. Digest of TEchnical Papers, ISSCC.

[65]  Ping K. Ko,et al.  Chapter 1 - Approaches to Scaling , 1989 .

[66]  Sunetra K. Mendis,et al.  A 128 x 128 CMOS Active Pixel Image Sensor for Highly Integrated Imaging Systems , 1993 .

[67]  R. M. Swanson,et al.  Simultaneous measurement of hole lifetime, hole mobility and bandgap narrowing in heavily doped n-type silicon , 1985, 1985 International Electron Devices Meeting.

[68]  Jean-Pierre Colinge,et al.  RECENT ADVANCES IN SO1 TECHNOLOGY , 1994 .