High field related thin oxide wearout and breakdown

The high voltage wearout and breakdown of thin silicon oxides has been described in terms of traps generated inside of the oxide and at the interfaces by a high field emission process. The trap generation was accompanied by the motion of atoms which resulted in permanent traps fixed in space. Breakdown occurred when the local density of traps exceeded a critical density. The charge state of these traps could easily be changed by application of low voltages after the high voltage stresses. The energy levels of the traps varied depending on the probability of trap generation. This model has been applied to analyze the thickness, field, polarity, time, and temperature dependences of oxide wearout and breakdown observed in oxides thinner than 22 mn. It was concluded that the wearout process in oxides thinner than 22 nm was determined by the electric fields applied to the oxides and not by the passage of currents through the oxides. >

[1]  K. R. Farmer,et al.  Time‐dependent positive charge generation in very thin silicon oxide dielectrics , 1992 .

[2]  Prasad Chaparala,et al.  Field and temperature acceleration of time-dependent dielectric breakdown in intrinsic thin SiO/sub 2/ , 1994, Proceedings of 1994 IEEE International Reliability Physics Symposium.

[3]  S. Sze.  Semiconductor Devices: Physics and Technology , 1985 .

[4]  B. Ricco,et al.  Novel Mechanism for Tunneling and Breakdown of Thin SiO 2 Films , 1983 .

[5]  R. S. Scott,et al.  The Transient Nature of Excess Low‐Level Leakage Currents in Thin Oxides , 1995 .

[6]  E. Harari,et al.  Conduction and trapping of electrons in highly stressed ultrathin films of thermal SiO2 , 1977 .

[7]  R. S. Scott,et al.  A model relating wearout induced physical changes in thin oxides to the statistical description of breakdown , 1993, 31st Annual Proceedings Reliability Physics 1993.

[8]  D. J. Dumin,et al.  Bipolar stressing, breakdown, and trap generation in thin silicon oxides , 1994 .

[9]  B. Riccò,et al.  High-field-induced degradation in ultra-thin SiO/sub 2/ films , 1988 .

[10]  K. R. Farmer,et al.  Negative charging in ultrathin metal‐oxide‐silicon tunnel diodes , 1992 .

[11]  Jordi Suñé,et al.  Temperature dependence of Fowler-Nordheim injection from accumulated n-type silicon into silicon dioxide , 1993 .

[12]  C. N. Berglund.  Surface states at steam-grown silicon-silicon dioxide interfaces , 1966 .

[13]  George A. Brown,et al.  Extrapolation of high-voltage stress measurements to low-voltage operation for thin silicon-oxide films , 1991 .

[14]  E. Harari.  Dielectric breakdown in electrically stressed thin films of thermal SiO2 , 1978 .

[15]  T. Lei,et al.  Electrical characteristics of a stacked nitride/microcrystalline‐silicon/oxide/silicon structure , 1993 .

[16]  E. Kane.  Theory of Tunneling , 1961 .

[17]  Jack C. Lee,et al.  Modeling and characterization of gate oxide reliability , 1988 .

[18]  J. McPherson,et al.  Acceleration Factors for Thin Gate Oxide Stressing , 1985, 23rd International Reliability Physics Symposium.

[19]  R. S. Scott,et al.  A statistical model of oxide breakdown based on a physical description of wearout , 1992, 1992 International Technical Digest on Electron Devices Meeting.

[20]  R. S. Scott,et al.  High field emission related thin oxide wearout and breakdown , 1994, Proceedings of 1994 IEEE International Reliability Physics Symposium.

[21]  D. Fleetwood,et al.  Effects of oxide traps, interface traps, and ‘‘border traps’’ on metal‐oxide‐semiconductor devices , 1993 .

[22]  N. Shiono,et al.  A lifetime projection method using series model and acceleration factors for TDDB failures of thin gate oxides , 1993, 31st Annual Proceedings Reliability Physics 1993.

[23]  Arnold,et al.  Theory of high-field electron transport and impact ionization in silicon dioxide. , 1994, Physical review. B, Condensed matter.

[24]  R.-P. Vollertsen,et al.  Dependence of dielectric time to breakdown distributions on test structure area , 1990, Proceedings of the 1991 International Conference on Microelectronic Test Structures.

[25]  D. J. Dumin,et al.  Correlation of stress-induced leakage current in thin oxides with trap generation inside the oxides , 1993 .

[26]  E. E. King,et al.  Improved method for evaluating hot-carrier aging in p-channel MOSFET's , 1993, 31st Annual Proceedings Reliability Physics 1993.

[27]  G. Ghibaudo,et al.  Correlation between negative bulk oxide charge and breakdown: modeling, and new criteria for dielectric quality evaluation , 1993, 31st Annual Proceedings Reliability Physics 1993.

[28]  Yukiharu Uraoka,et al.  A New Technique for Evaluating Gate Oxide Reliability Using a Photon Emission Method (Special Issue on Sub-Half Micron Si Device and Process Technologies) , 1993 .

[29]  D. Kwong,et al.  Influence of process parameters on the time‐dependent dielectric breakdown of rapid thermally nitrided and reoxidized nitrided thin SiO2 , 1992 .

[30]  C. Hsu,et al.  Optimized silicon-rich oxide (SRO) deposition process for 5 V only flash EEPROM applications , 1993, IEEE Electron Device Letters.

[31]  Jordi Suñé,et al.  Degradation and Breakdown of Gate Oxides in VLSI Devices , 1989, February 16.

[32]  Eduard A. Cartier,et al.  Degradation and breakdown of silicon dioxide films on silicon , 1992 .

[33]  Y. Hokari,et al.  Stress voltage polarity dependence of thermally grown thin gate oxide wearout , 1988 .

[34]  D. Dimaria,et al.  Temperature dependence of trap creation in silicon dioxide , 1990 .

[35]  T. Ohmi,et al.  Highly-reliable ultra-thin oxide formation using hydrogen-radical-balanced steam oxidation technology , 1994, Proceedings of 1994 IEEE International Reliability Physics Symposium.

[36]  N. Singpurwalla,et al.  Methods for Statistical Analysis of Reliability and Life Data. , 1975 .

[37]  C. Hu,et al.  Hole injection oxide breakdown model for very low voltage lifetime extrapolation , 1993, 31st Annual Proceedings Reliability Physics 1993.

[38]  D. Arnold,et al.  Impact Ionization, Degradation, and Breakdown in SiO 2 , 1992 .

[39]  Jordi Suñé,et al.  On the breakdown statistics of very thin SiO2 films , 1990 .

[40]  D. J. Dumin,et al.  Traps in Reoxidized Nitrided Oxides of Varying Thicknesses , 1995 .

[41]  George A. Brown,et al.  Polarity dependence of thin oxide wearout , 1989 .

[42]  B. Ricco,et al.  Influence of localized latent defects on electrical breakdown of thin insulators , 1991 .

[43]  D. J. Dumin,et al.  Stress Induced Increased Low Level Leakage in Thin Oxides , 1992 .

[44]  Y. Nissan-Cohen,et al.  Determination of SiO2 trapped charge distribution by capacitance‐voltage analysis of undoped polycrystalline silicon‐oxide‐silicon capacitors , 1984 .

[45]  Z. Weinberg,et al.  The relation between positive charge and breakdown in metal‐oxide‐silicon structures , 1987 .

[46]  S. Levine.  Quantum physics of electronics , 1965 .

[47]  George A. Brown,et al.  The polarity, field and fluence dependence of interface trap generation in thin silicon oxide , 1992 .

[48]  D. Dumin,et al.  Measurement of High Voltage Stress Induced Traps Inside Thin Silicon Oxide Films , 1992 .

[49]  D. Dumin,et al.  Transient Flat-Band Voltage Shifts Following High Voltage Stressing of Thin Oxides , 1992 .

[50]  A. Brand,et al.  Novel read disturb failure mechanism induced by FLASH cycling , 1993, 31st Annual Proceedings Reliability Physics 1993.

[51]  P. P. Apte,et al.  Modeling ultrathin dielectric breakdown on correlation of charge trap-generation to charge-to-breakdown , 1994, Proceedings of 1994 IEEE International Reliability Physics Symposium.