Two-Phase Dynamic Modeling of PEMFCs and Simulation of Cyclo-Voltammograms

A mathematical model is developed that is based on a coupled system of partial differential equations. The model contains a dynamic and two-phase description of the proton exchange membrane fuel cell (PEMFC) and a membrane model that accounts for Schroeder's paradox. The mass transport in the gas phase and in the liquid phase is considered as well as the phase transition between liquid water and water vapor. The transport of charges and the electrochemical reactions are part of the model. A potential sweep experiment is simulated using the mathematical model and measured using a test cell with an active area of 1 cm 2 . In this way, the dynamic effect of liquid water formation and transport on the current-voltage characteristic of the fuel cell is investigated. A hysteresis effect is found in the measured time-dependent current-voltage relation. The limiting current density is time-dependent. Qualitative agreement of simulated and measured results is achieved. An analysis of the observed hysteresis of the current-voltage characteristics, based on the modeling results, is given.

[1]  M. C. Leverett,et al.  Capillary Behavior in Porous Solids , 1941 .

[2]  Adam Z. Weber,et al.  Transport in Polymer-Electrolyte Membranes I. Physical Model , 2004 .

[3]  I-Ming Hsing,et al.  Thermodynamics of water vapor uptake in perfluorosulfonic acid membranes , 1999 .

[4]  A. Weber,et al.  Transport in Polymer-Electrolyte Membranes II. Mathematical Model , 2004 .

[5]  R. Datta,et al.  Modeling of Conductive Transport in Proton-Exchange Membranes for Fuel Cells , 2000 .

[6]  Xianguo Li,et al.  Modelling of polymer electrolyte membrane fuel cells with variable degrees of water flooding , 2000 .

[7]  A. Parthasarathy,et al.  Temperature Dependence of the Electrode Kinetics of Oxygen Reduction at the Platinum/Nafion® Interface—A Microelectrode Investigation , 1992 .

[8]  Jin Hyun Nam,et al.  Effective diffusivity and water-saturation distribution in single- and two-layer PEMFC diffusion medium , 2003 .

[9]  Van Genuchten,et al.  A closed-form equation for predicting the hydraulic conductivity of unsaturated soils , 1980 .

[10]  T. Springer,et al.  Polymer Electrolyte Fuel Cell Model , 1991 .

[11]  Chao-Yang Wang,et al.  A multiphase mixture model for multiphase, multicomponent transport in capillary porous media—I. Model development , 1996 .

[12]  G. Lindbergh,et al.  Influence of the composition on the structure and electrochemical characteristics of the PEFC cathode , 2003 .

[13]  M. Wöhr,et al.  Dynamic modelling and simulation of a polymer membrane fuel cell including mass transport limitation , 1998 .

[14]  Z. H. Wang,et al.  Two-phase flow and transport in the air cathode of proton exchange membrane fuel cells , 2000 .

[15]  Norman R. Morrow,et al.  Irreducible wetting-phase saturations in porous media , 1970 .

[16]  Nathan P. Siegel,et al.  A two-dimensional computational model of a PEMFC with liquid water transport , 2004 .

[17]  Hongtan Liu,et al.  A two-phase flow and transport model for the cathode of PEM fuel cells , 2002 .

[18]  Chao-Yang Wang,et al.  Liquid Water Transport in Gas Diffusion Layer of Polymer Electrolyte Fuel Cells , 2004 .

[19]  C. R. Martin,et al.  Investigations of the O sub 2 reduction reaction at the platinum/Nafion interface using a solid-state electrochemical cell. Technical report , 1991 .

[20]  Mark W. Verbrugge,et al.  A Mathematical Model of the Solid‐Polymer‐Electrolyte Fuel Cell , 1992 .

[21]  Göran Lindbergh,et al.  Flooding of Gas Diffusion Backing in PEFCs Physical and Electrochemical Characterization , 2004 .

[22]  Ned Djilali,et al.  A 3D, Multiphase, Multicomponent Model of the Cathode and Anode of a PEM Fuel Cell , 2003 .

[23]  A. Kornyshev,et al.  Phenomenological theory of electro-osmotic effect and water management in polymer electrolyte proton-conducting membranes , 1998 .

[24]  J. C. Amphlett.  Performance Modeling of the Ballard Mark IV Solid Polymer Electrolyte Fuel Cell , 1995 .

[25]  Massimo Ceraolo,et al.  Modelling static and dynamic behaviour of proton exchange membrane fuel cells on the basis of electro-chemical description , 2003 .

[26]  Charles R. Martin,et al.  The Platinum Microelectrode/Nafion Interface: An Electrochemical Impedance Spectroscopic Analysis of Oxygen Reduction Kinetics and Nafion Characteristics , 1992 .

[27]  R. Helmig.  Multiphase Flow and Transport Processes in the Subsurface: A Contribution to the Modeling of Hydrosystems , 2011 .

[28]  Adam Z. Weber,et al.  Transport in Polymer-Electrolyte Membranes III. Model Validation in a Simple Fuel-Cell Model , 2004 .