Dominant four-pole placement in filtered PID control loop with delay

Abstract The paper proposes a novel approach to the filter design in the delayed PID control loop. The novel approach is based on the dominant four-pole placement providing all five controller parameters including the filter time constant and damping factor. Moreover, the dominant four-pole placement is carried out iteratively as long as an optimum dominant four-pole placement is achieved by means of the constrained IAE optimization. The constraints considered for the optimization are the dominance of the placed poles and the fixed value of the filter damping factor. The achieved optimum dominant four-pole placement then corresponds to the least IAE obtained under these constraints. Then the filtered PID controller results very close to the ideal PID controller up to the filter cut-off frequency. Finally, the constrained IAE optimization of the disturbance rejection is preferred in the paper.

[1]  Moonyong Lee,et al.  Analytical design of PID controller cascaded with a lead-lag filter for time-delay processes , 2009 .

[2]  M. Huba.  Comparing 2DOF PI and predictive disturbance observer based filtered PI control , 2013 .

[3]  Moonyong Lee,et al.  An Enhanced Performance PID Filter Controller for First Order Time Delay Processes , 2007 .

[4]  Pavel Zítek,et al.  Algebraic design of anisochronic controllers for time delay systems , 2003 .

[5]  Silviu-Iulian Niculescu,et al.  Multiplicity and Stable Varieties of Time-delay Systems : A Missing Link , 2016 .

[6]  Tore Hägglund,et al.  Measurement noise filtering for common PID tuning rules , 2014 .

[7]  K. Åström,et al.  Revisiting the Ziegler-Nichols step response method for PID control , 2004 .

[8]  Bengt Lennartson,et al.  Evaluation and tuning of robust PID controllers , 2009 .

[9]  Weng Khuen Ho,et al.  Optimal Gain and Phase Margin Tuning for PID Controllers , 1998, Autom..

[10]  Pavel Zítek,et al.  Dimensional analysis approach to dominant three-pole placement in delayed PID control loops , 2013 .

[11]  Alf Isaksson,et al.  Derivative filter is an integral part of PID design , 2002 .

[12]  Tore Hägglund,et al.  Measurement noise filtering for PID controllers , 2014 .

[13]  Miroslav R. Mataušek,et al.  Optimization of PID controller with higher-order noise filter , 2014 .

[14]  S. Mondié,et al.  Velocity control of servo systems using an integral retarded algorithm. , 2015, ISA transactions.

[15]  Karl Johan Åström,et al.  Self-Tuning Controllers Based on Pole-Zero Placement , 1980 .

[16]  Sabine Mondié,et al.  On Delay-Based Control of Low-Order LTI Systems: a Simple Alternative to PI/PID Controllers Under Noisy Measurements , 2016 .