POF-IMU sensor system: A fusion between inertial measurement units and POF sensors for low-cost and highly reliable systems

Abstract This paper presents a low cost and highly reliable system for angle measurement based on a sensor fusion between inertial and fiber optic sensors. The system consists of the sensor fusion through Kalman filter of two inertial measurement units (IMUs) and an intensity variation-based polymer optical fiber (POF) curvature sensor. In addition, the IMU was applied as a reference for a compensation technique of POF curvature sensor hysteresis. The proposed system was applied on the knee angle measurement of a lower limb exoskeleton in flexion/extension cycles and in gait analysis. Results show the accuracy of the system, where the Root Mean Square Error (RMSE) between the POF-IMU sensor system and the encoder was below 4° in the worst case and about 1° in the best case. Then, the POF-IMU sensor system was evaluated as a wearable sensor for knee joint angle assessment without the exoskeleton, where its suitability for this purpose was demonstrated. The results obtained in this paper pave the way for future applications of sensor fusion between electronic and fiber optic sensors in movement analysis.

[1]  H. Krebs,et al.  Effects of Robot-Assisted Therapy on Upper Limb Recovery After Stroke: A Systematic Review , 2008, Neurorehabilitation and neural repair.

[2]  Gérard Lachapelle,et al.  Data Fusion Algorithms for Multiple Inertial Measurement Units , 2011, Sensors.

[3]  D. Roetenberg,et al.  Estimating Body Segment Orientation by Applying Inertial and Magnetic Sensing Near Ferromagnetic Materials , 2007, IEEE Transactions on Neural Systems and Rehabilitation Engineering.

[4]  A. Siqueira,et al.  Polymer Optical Fiber for Angle and Torque Measurements of a Series Elastic Actuator's Spring , 2018, Journal of Lightwave Technology.

[5]  Guido G. Pena,et al.  Design and evaluation of a modular lower limb exoskeleton for rehabilitation , 2017, 2017 International Conference on Rehabilitation Robotics (ICORR).

[6]  P. Veltink,et al.  Compensation of magnetic disturbances improves inertial and magnetic sensing of human body segment orientation , 2005, IEEE Transactions on Neural Systems and Rehabilitation Engineering.

[7]  Shaghayegh Zihajehzadeh,et al.  A Novel Biomechanical Model-Aided IMU/UWB Fusion for Magnetometer-Free Lower Body Motion Capture , 2017, IEEE Transactions on Systems, Man, and Cybernetics: Systems.

[8]  Mohammed El-Diasty,et al.  A Rigorous Temperature-Dependent Stochastic Modelling and Testing for MEMS-Based Inertial Sensor Errors , 2009, Sensors.

[9]  P H Veltink,et al.  Ambulatory measurement of arm orientation. , 2007, Journal of biomechanics.

[10]  Arnaldo G. Leal-Junior,et al.  Polymer optical fiber strain gauge for human-robot interaction forces assessment on an active knee orthosis , 2018 .

[11]  Carlos A. F. Marques,et al.  Measurement of Temperature and Relative Humidity with Polymer Optical Fiber Sensors Based on the Induced Stress-Optic Effect , 2018, Sensors.

[12]  Ph. André,et al.  Carotid distension waves acquired with a fiber sensor as an alternative to tonometry for central arterial systolic pressure assessment in young subjects , 2017 .

[13]  Begonya Garcia-Zapirain,et al.  Gait Analysis Methods: An Overview of Wearable and Non-Wearable Systems, Highlighting Clinical Applications , 2014, Sensors.

[14]  Cesar Jauregui,et al.  Lateral polishing of bends in plastic optical fibres applied to a multipoint liquid-level measurement sensor , 2007 .

[15]  K. Peters.  Polymer optical fiber sensors—a review , 2010 .

[16]  Laura Rocchi,et al.  A Wearable System for Gait Training in Subjects with Parkinson's Disease , 2014, Sensors.

[17]  A. Leal-Junior,et al.  Sensitive zone parameters and curvature radius evaluation for polymer optical fiber curvature sensors , 2018 .

[18]  B M Jolles,et al.  Functional calibration procedure for 3D knee joint angle description using inertial sensors. , 2009, Journal of biomechanics.

[19]  Wilian M. dos Santos,et al.  Design and control of an active knee orthosis driven by a rotary Series Elastic Actuator , 2017 .

[20]  James McNames,et al.  Shoulder and Elbow Joint Angle Tracking With Inertial Sensors , 2012, IEEE Transactions on Biomedical Engineering.

[21]  Maria José Pontes,et al.  Polymethyl methacrylate (PMMA) recycling for the production of optical fiber sensor systems. , 2017, Optics express.

[22]  Gang-Ding Peng,et al.  Highly sensitive liquid level monitoring system utilizing polymer fiber Bragg gratings. , 2015, Optics express.

[23]  J. Burdick,et al.  Implications of Assist-As-Needed Robotic Step Training after a Complete Spinal Cord Injury on Intrinsic Strategies of Motor Learning , 2006, The Journal of Neuroscience.

[24]  David J. Webb,et al.  Thermal and chemical treatment of polymer optical fiber Bragg grating sensors for enhanced mechanical sensitivity , 2017 .

[25]  Shigeru Tadano,et al.  Three Dimensional Gait Analysis Using Wearable Acceleration and Gyro Sensors Based on Quaternion Calculations , 2013, Sensors.

[26]  Humberto Varum,et al.  Intensity-Encoded Polymer Optical Fiber Accelerometer , 2013, IEEE Sensors Journal.

[27]  Eduardo Rocon,et al.  An IMU-to-Body Alignment Method Applied to Human Gait Analysis , 2016, Sensors.

[28]  Lucy E. Dunne,et al.  Wearable Monitoring of Seated Spinal Posture , 2008, IEEE Transactions on Biomedical Circuits and Systems.

[29]  A. Leal-Junior,et al.  Polymer-optical-fiber-based sensor system for simultaneous measurement of angle and temperature. , 2018, Applied optics.

[30]  Luis Rodriguez-Cobo,et al.  Optical fiber strain sensor with extended dynamic range based on specklegrams , 2013 .

[31]  Bjarke Rose,et al.  Improved thermal and strain performance of annealed polymer optical fiber Bragg gratings , 2011 .

[32]  Elia Palange,et al.  A New Flexible Optical Fiber Goniometer for Dynamic Angular Measurements: Application to Human Joint Movement Monitoring , 2008, IEEE Transactions on Instrumentation and Measurement.

[33]  H. Di.  Sensing principle of fiber-optic curvature sensor , 2014 .

[34]  A. Kourepenis,et al.  Error sources in in-plane silicon tuning-fork MEMS gyroscopes , 2006, Journal of Microelectromechanical Systems.

[35]  Ferdinando A. Mussa-Ivaldi,et al.  Body-Machine Interfaces after Spinal Cord Injury: Rehabilitation and Brain Plasticity , 2016, Brain sciences.

[36]  M. B. Zivanov,et al.  Wearable Low-Cost System for Human Joint Movements Monitoring Based on Fiber-Optic Curvature Sensor , 2012, IEEE Sensors Journal.

[37]  Dafang Zhuang,et al.  Advances in Multi-Sensor Data Fusion: Algorithms and Applications , 2009, Sensors.

[38]  Nélia Alberto,et al.  Optical Sensors Based on Plastic Fibers , 2012, Sensors.

[39]  Zhihao Chen,et al.  Plastic optical fiber microbend sensor used as breathing sensor , 2012, 2012 IEEE Sensors.

[40]  David J. Webb,et al.  Polymer optical fiber sensors in human life safety , 2017 .

[41]  Fakhri Karray,et al.  Multisensor data fusion: A review of the state-of-the-art , 2013, Inf. Fusion.

[42]  Carlos A. F. Marques,et al.  A Polymer Optical Fiber Temperature Sensor Based on Material Features , 2018, Sensors.

[43]  Beatriz Ortega,et al.  Fast Inscription of Long Period Gratings in Microstructured Polymer Optical Fibers , 2018, IEEE Sensors Journal.

[44]  M H Granat,et al.  A practical gait analysis system using gyroscopes. , 1999, Medical engineering & physics.

[45]  Maria José Pontes,et al.  Dynamic Compensation Technique for POF Curvature Sensors , 2018, Journal of Lightwave Technology.

[46]  A. Frizera-Neto,et al.  Hysteresis compensation technique applied to polymer optical fiber curvature sensor for lower limb exoskeletons , 2017 .

[47]  A. Cappozzo,et al.  A spot check for assessing static orientation consistency of inertial and magnetic sensing units. , 2011, Gait & posture.

[48]  Alessio Stefani,et al.  Dynamic Characterization of Polymer Optical Fibers , 2012, IEEE Sensors Journal.

[49]  A. Leal-Junior,et al.  Dynamic Mechanical Analysis on a PolyMethyl Methacrylate (PMMA) Polymer Optical Fiber , 2018, IEEE Sensors Journal.

[50]  Yili Fu,et al.  Light intensity modulation fiber-optic sensor for curvature measurement , 2010 .

[51]  J. Zubía,et al.  Theoretical Analysis of the Torsion-Induced Optical Effect in a Plastic Optical Fiber , 1997 .

[52]  Angelo M. Sabatini,et al.  Estimating Orientation Using Magnetic and Inertial Sensors and Different Sensor Fusion Approaches: Accuracy Assessment in Manual and Locomotion Tasks , 2014, Sensors.

[53]  Kamiar Aminian,et al.  A new approach to accurate measurement of uniaxial joint angles based on a combination of accelerometers and gyroscopes , 2005, IEEE Transactions on Biomedical Engineering.

[54]  Getinet Woyessa,et al.  Solution-Mediated Annealing of Polymer Optical Fiber Bragg Gratings at Room Temperature , 2017, IEEE Photonics Technology Letters.

[55]  Yan Yan,et al.  A low-complexity sensor fusion algorithm based on a fiber-optic gyroscope aided camera pose estimation system , 2015, Science China Information Sciences.

[56]  Aurelio Cappozzo,et al.  Joint kinematics estimate using wearable inertial and magnetic sensing modules. , 2008, Gait & posture.

[57]  Angelo M. Sabatini,et al.  How Angular Velocity Features and Different Gyroscope Noise Types Interact and Determine Orientation Estimation Accuracy , 2015, Sensors.

[58]  Jaw-Kuen Shiau,et al.  Noise Characteristics of MEMS Gyro's Null Drift and Temperature Compensation , 2012 .

[59]  A. Frizera,et al.  Analytical model for a polymer optical fiber under dynamic bending , 2017 .

[60]  João L. Pinto,et al.  A reliable low-cost wireless and wearable gait monitoring system based on a plastic optical fibre sensor , 2011 .

[61]  Arnaldo G. Leal-Junior,et al.  Polymer Optical Fiber for In-Shoe Monitoring of Ground Reaction Forces During the Gait , 2018, IEEE Sensors Journal.

[62]  Raymond Y.W. Lee,et al.  Dynamic measurement of lumbar curvature using fibre-optic sensors. , 2010, Medical engineering & physics.

[63]  Adriano Ferrari,et al.  ‘Outwalk’: a protocol for clinical gait analysis based on inertial and magnetic sensors , 2009, Medical & Biological Engineering & Computing.

[64]  Thomas Seel,et al.  IMU-Based Joint Angle Measurement for Gait Analysis , 2014, Sensors.