Model predictive control of water management in PEMFC

Water management is critical for Proton Exchange Membrane Fuel Cells (PEMFC). An appropriate humidity condition not only can improve the performances and efficiency of the fuel cell, but can also prevent irreversible degradation of internal composition such as the catalyst or the membrane. In this paper we built the model of water management systems which consist of stack voltage model, water balance equation in anode and cathode, and water transport process in membrane. Based on this model, model predictive control mechanism was proposed by utilizing Recurrent Neural Network (RNN) optimization. The models and model predictive controller have been implemented in the MATLAB and SIMULINK environment. Simulation results showed that this approach can avoid fluctuation of water concentration in cathode and can extend the lifetime of PEM fuel cell stack.

[1]  Sirivatch Shimpalee,et al.  Prediction of transient response for a 25-cm2 PEM fuel cell , 2007 .

[2]  T. Nguyen,et al.  A liquid water management strategy for PEM fuel cell stacks , 2003 .

[3]  S. Dutta,et al.  NUMERICAL PREDICTION OF TEMPERATURE DISTRIBUTION IN PEM FUEL CELLS , 2000 .

[4]  Jun Wang,et al.  A recurrent neural network with exponential convergence for solving convex quadratic program and related linear piecewise equations , 2004, Neural Networks.

[5]  Cheng-Ching Yu,et al.  Operation-relevant modeling of an experimental proton exchange membrane fuel cell , 2007 .

[6]  Felix N. Büchi,et al.  Operating Proton Exchange Membrane Fuel Cells Without External Humidification of the Reactant Gases Fundamental Aspects , 1997 .

[7]  A.G. Stefanopoulou,et al.  Control of fuel cell breathing , 2004, IEEE Control Systems.

[8]  Amir Abtahi,et al.  Water management of PEM fuel cells using fuzzy logic controller system , 2005, 2005 IEEE International Conference on Systems, Man and Cybernetics.

[9]  Wei-Mon Yan,et al.  Effective schemes to control the dynamic behavior of the water transport in the membrane of PEM fuel cell , 2005 .

[10]  Ralph E. White,et al.  A water and heat management model for proton-exchange-membrane fuel cells , 1993 .

[11]  Denise A. McKay,et al.  Measurement of Liquid Water Accumulation in a PEMFC with Dead-Ended Anode , 2008 .

[12]  D. Chu,et al.  Performance of polymer electrolyte membrane fuel cell (PEMFC) stacks. Part I. Evaluation and simulation of an air-breathing PEMFC stack , 1999 .

[13]  Daniel R. Lewin,et al.  Model-based Control of Fuel Cells: (1) Regulatory Control , 2004 .

[14]  Alberto Bemporad,et al.  The explicit linear quadratic regulator for constrained systems , 2003, Autom..

[15]  J. C. Amphlett,et al.  Performance modeling of the Ballard Mark IV solid polymer electrolyte fuel cell. II: Empirical model development , 1995 .

[16]  S. Rael,et al.  Mathematical model and characterization of the transient behavior of a PEM fuel cell , 2004, IEEE Transactions on Power Electronics.

[17]  Murat Arcak,et al.  An algorithm for estimation of membrane water content in PEM fuel cells , 2006 .