The determination of a ‘stable-equilibrium’ contact angle on heterogeneous and rough surfaces

Abstract The common measurement of the contact angle is performed in conditions not corresponding to true equilibrium states and gives non-equilibrium values, the advancing and receding contact angles. To solve this problem, a very simple experimental device, based on the Wilhelmy experiment, is proposed in the present paper. It is able to transfer mechanical energy to the three-phase system in a controlled way through a simple loudspeaker; the analysis of some common surfaces is made through this method showing as a new stable minimum of the surface free energy can be attained, independent on the initial conditions and corresponding to a value of the contact angle intermediate between the advancing and receding ones. A comparison is developed with literature results on heterogeneous and rough surfaces, some ‘first-order’-approximation equations proposed in the literature are examined and compared with the new results. A simple but useful theoretical treatment is also compared with the experimental results to allow a more detailed, although qualitative-level, analysis. An important consequence with respect to the calculations of solid surface free energies is indicated.

[1]  T. Young.  III. An essay on the cohesion of fluids , 1805, Philosophical Transactions of the Royal Society of London.

[2]  R. Good,et al.  Thermodynamics of contact angles. I. Heterogeneous solid surfaces , 1972 .

[3]  K. Birdi,et al.  Wettability and Contact Angles , 1984 .

[4]  Öpik.  Contact-Angle Hysteresis Caused by a Random Distribution of Weak Heterogeneities on a Solid Surface. , 2000, Journal of colloid and interface science.

[5]  W. Zisman,et al.  Contact angle, wettability, and adhesion , 1964 .

[6]  W. Possart,et al.  Young's equilibrium contact angle on rough solid surfaces. Part I. An empirical determination , 1989 .

[7]  A. Cassie,et al.  Wettability of porous surfaces , 1944 .

[8]  J. Andrade.  Surface and Interfacial Aspects of Biomedical Polymers , 1985 .

[9]  C. Sykes,et al.  Average spreading parameter on heterogeneous surfaces , 1994 .

[10]  F. Fowkes,et al.  The State of Monolayers Adsorbed at the Interface Solid—Aqueous Solution , 1940 .

[11]  P. G. de Gennes,et al.  A model for contact angle hysteresis , 1984 .

[12]  Egon Matijević,et al.  Surface and Colloid Science , 1971 .

[13]  R. H. Dettre,et al.  Contact Angle Hysteresis. IV. Contact Angle Measurements on Heterogeneous Surfaces1 , 1965 .

[14]  R. Shuttleworth,et al.  The spreading of a liquid over a rough solid , 1948 .

[15]  T. L. Hill,et al.  An Introduction to Statistical Thermodynamics , 1960 .

[16]  R. N. Wenzel.  RESISTANCE OF SOLID SURFACES TO WETTING BY WATER , 1936 .

[17]  Victor Starov,et al.  EQUILIBRIUM AND HYSTERESIS CONTACT ANGLES , 1992 .

[18]  Tennyson Smith,et al.  Effect of acoustic energy on contact angle measurements , 1978 .

[19]  J.-M. di Meglio.  Contact Angle Hysteresis and Interacting Surface Defects , 1992 .

[20]  R. H. Dettre,et al.  Contact Angle Hysteresis. III. Study of an Idealized Heterogeneous Surface , 1964 .

[21]  S. Siboni,et al.  An Experimental Procedure to Obtain the Equilibrium Contact Angle from the Wilhelmy Method , 2001 .

[22]  D. Paul,et al.  The relation between Young’s equilibrium contact angle and the hysteresis on rough paraffin wax surfaces , 1999 .

[23]  J. Lane,et al.  A thermodynamic discussion of the use of a vertical-plate balance for the measurement of surface tension , 1964 .

[24]  S. Garoff,et al.  Using Vibrational Noise To Probe Energy Barriers Producing Contact Angle Hysteresis , 1996 .

[25]  Chun Huh,et al.  Effects of surface roughness on wetting (theoretical) , 1977 .

[26]  R. M. Cannon,et al.  Ridging effects on wetting and spreading of liquids on solids , 1998 .

[27]  C. Volpe,et al.  Some Reflections on Acid-Base Solid Surface Free Energy Theories , 1997, Journal of colloid and interface science.

[28]  W. Richards,et al.  An Introduction to Statistical Thermodynamics , 1995 .

[29]  S. Garoff,et al.  Physics of contact angle measurement , 1999 .