Suture-Only Repair Versus Suture Anchor–Augmented Repair for Achilles Tendon Ruptures With a Short Distal Stump

Background: Chronic noninsertional Achilles tendinosis can result in an acute Achilles tendon rupture with a short distal stump. In such tendon ruptures, there is a limited amount of adequate tissue that can hold suture, thus presenting a challenge for surgeons who elect to treat the rupture operatively. Hypothesis: Adding suture anchors to the repair construct may result in biomechanically stronger repairs compared with a suture-only technique. Study Design: Controlled laboratory study. Methods: Nine paired Achilles-calcaneus complexes were harvested from cadavers. An artificial Achilles rupture was created 2 cm proximal to the insertion on the calcaneus. One specimen from each cadaver was assigned to a suture-only or a suture anchor–augmented repair. The contralateral specimen of the same cadaver received the opposing repair. Cyclic testing was then performed at 10 to 100 N for 2000 cycles, and load-to-failure testing was performed at 0.2 mm/s. This was followed by analysis of repair displacement, gapping at repair site, peak load to failure, and failure mode. Results: The suture anchor–augmented repair exhibited a 116% lower displacement compared with the suture-only repair (mean ± SD, 1.54 ± 1.13 vs 3.33 ± 1.47 mm, respectively; P < .03). The suture anchor–augmented repair also exhibited a 45% greater load to failure compared with the suture-only repair (303.50 ± 102.81 vs 209.09 ± 48.12 N, respectively; P < .04). Conclusion: Suture anchor–augmented repairs performed on acute Achilles tendon ruptures with a short distal stump are biomechanically stronger than suture-only repairs. Clinical Relevance: Our results support the use of suture anchor–augmented repairs for a biomechanically stronger construct in Achilles tendon ruptures with a short distal stump. Biomechanically stronger repairs may lead to less tendon repair gapping and failure, increasing the ability to start early active rehabilitation protocols and thus improving patient outcomes.

[1]  W. Hutton,et al.  The Effect of Ankle Position on the Static Tension in the Achilles Tendon Before and After Operative Repair: A Biomechanical Cadaver Study , 2007, Foot & ankle international.

[2]  W. Hutton,et al.  The "Giftbox" repair of the Achilles tendon: a modification of the Krackow technique. , 2009, Foot & ankle international.

[3]  C. Baker,et al.  Fixation of the Achilles Tendon Insertion Using Suture Button Technology , 2012, The American journal of sports medicine.

[4]  Brett W. McCoy,et al.  The Strength of Achilles Tendon Repair: A Comparison of Three Suture Techniques in Human Cadaver Tendons , 2010, Foot & ankle international.

[5]  Donald C. Jones.  Tendon Disorders of the Foot and Ankle , 1993, The Journal of the American Academy of Orthopaedic Surgeons.

[6]  Robert F LaPrade,et al.  A Biomechanical Comparison of an Open Repair and 3 Minimally Invasive Percutaneous Achilles Tendon Repair Techniques During a Simulated, Progressive Rehabilitation Protocol , 2015, The American journal of sports medicine.

[7]  W. Hutton,et al.  Achilles Tendon Rupture Repair: Biomechanical Comparison of the Triple Bundle Technique versus the Krakow Locking Loop Technique , 2000, Foot & ankle international.

[8]  Matthew J. Silva,et al.  Biomechanical Testing of Fracture Fixation Constructs: Variability, Validity, and Clinical Applicability , 2012, The Journal of the American Academy of Orthopaedic Surgeons.

[9]  K. Wapner,et al.  Surgical Treatment for Chronic Disease and Disorders of the Achilles Tendon , 2009, The Journal of the American Academy of Orthopaedic Surgeons.

[10]  J. Maquirriain.  Achilles Tendon Rupture: Avoiding Tendon Lengthening during Surgical Repair and Rehabilitation , 2011, The Yale journal of biology and medicine.

[11]  D. Adams,et al.  Cyclic Loading of Achilles Tendon Repairs: A Comparison of Polyester and Polyblend Suture , 2006, Foot & ankle international.

[12]  Michael D. Barnett,et al.  Knotted Versus Knotless Suture Bridge Repair of the Achilles Tendon Insertion , 2014, The American journal of sports medicine.

[13]  R. Laughlin,et al.  Fatty Infiltration of the Gastrocsoleus after Tendo-Achilles Lengthening and Gastrocnemius Recession in a Rabbit Model , 2009, Foot & ankle international.

[14]  Karl F. Orishimo,et al.  Cyclic Loading of 3 Achilles Tendon Repairs Simulating Early Postoperative Forces , 2009, The American journal of sports medicine.

[15]  A. Rausing,et al.  Chronic Achilles Tendinopathy: A Survey of Surgical and Histopathologic Findings Mats , 1995, Clinical orthopaedics and related research.

[16]  A. Amendola,et al.  Biomechanical Properties of Double- and Single-Row Suture Anchor Repair for Surgical Treatment of Insertional Achilles Tendinopathy , 2013, The American journal of sports medicine.

[17]  M. McHugh,et al.  Optimizing Achilles Tendon Repair: Effect of Epitendinous Suture Augmentation on the Strength of Achilles Tendon Repairs , 2008, Foot & ankle international.

[18]  Y. Temelli,et al.  Suture anchor tenodesis in repair of distal Achilles tendon injuries , 2012, European Journal of Orthopaedic Surgery & Traumatology.

[19]  P. Rosenfeld,et al.  The ruptured Achilles tendon: a current overview from biology of rupture to treatment , 2013, MUSCULOSKELETAL SURGERY.

[20]  T. Wright,et al.  Achilles tendon repair: Achillon system vs. Krackow suture: an anatomic in vitro biomechanical study. , 2008, Clinical biomechanics.