Review of the Fault Mechanism and Diagnostic Techniques for the Range Extender Hybrid Electric Vehicle

This paper presents a thorough literature review on the fault mechanism and diagnostic techniques for a range extender hybrid electric vehicle, which is one of the most feasible electric vehicles. However, extensive fault diagnosis research has been done on the diesel engine or a generator, but studies on the range extender are still limited, which is a coupling device of an engine-generator shaft. It has many coupling faults except to the single failure mode of the diesel engine or the generator. In this paper, the research development of the fault mechanism and fault diagnosis has been reviewed and analyzed. In addition, the trends in fault diagnosis technologies have been discussed, which provides a theoretical foundation for the engineering application of the condition monitoring and fault diagnosis of the electric vehicle range extender.

[1]  Lu Zhen-yon.  Dynamic characteristics of a open crack in hollow shaft rotor system , 2015 .

[2]  Alireza Sadeghian,et al.  Mechanical fault diagnostics for induction motor with variable speed drives using Adaptive Neuro-fuzzy Inference System , 2006 .

[3]  Rui Ma,et al.  Research on dynamics and fault mechanism of spur gear pair with spalling defect , 2012 .

[4]  Wang Hai-yan.  Coupling Simulation of ICE Crankshaft System Dynamics and Dynamic Lubrication , 2010 .

[5]  Simon Ho,et al.  Fatigue analysis of crankshaft sections under bending with consideration of residual stresses , 2005 .

[6]  Cai Gan-hua.  A Study on Two Fold Resonance of Shaft in Coupled Mechanical and Electrical Torsional Vibration Problems of Generating Set , 2005 .

[7]  Li Xiaoxiao,et al.  Analysis on oscillation in electro-hydraulic regulating system of steam turbine and fault diagnosis based on PSOBP , 2010 .

[8]  Jianfu Hou,et al.  An investigation of fatigue failures of turbine blades in a gas turbine engine by mechanical analysis , 2002 .

[9]  Tolga Yüksel,et al.  Two fault detection and isolation schemes for robot manipulators using soft computing techniques , 2010, Appl. Soft Comput..

[10]  Ali Cinar,et al.  Monitoring, fault diagnosis, fault-tolerant control and optimization: Data driven methods , 2012, Comput. Chem. Eng..

[11]  I Aharon,et al.  Topological Overview of Powertrains for Battery-Powered Vehicles With Range Extenders , 2011, IEEE Transactions on Power Electronics.

[12]  Yeon-Sun Choi,et al.  Fault diagnosis of partial rub and looseness in rotating machinery using Hilbert-Huang transform , 2008 .

[13]  Si-Zhao Joe Qin,et al.  Survey on data-driven industrial process monitoring and diagnosis , 2012, Annu. Rev. Control..

[14]  Li Xing-yang.  Study on imbalance-misalignment-rubbing coupling faults in aero-engine vibration , 2009 .

[15]  Peng Qian.  Impact of Electromechanical Coupling on Shaft Torsional Dynamics , 2010 .

[16]  H. Amstutz,et al.  "Modes of failure" of cemented stem-type femoral components: a radiographic analysis of loosening. , 1979, Clinical orthopaedics and related research.

[17]  Thomas H. Bradley,et al.  Review of hybrid, plug-in hybrid, and electric vehicle market modeling Studies , 2013 .

[18]  Le Zheng-wei.  Summarization of Fault Diagnostic Technology for Diesel , 2008 .

[19]  Zhang Jun-hon.  Dynamic analysis of rotor-ball bearings system based on elasto-hydrodynamic lubrication with rubbing-misalignment coupling fault , 2014 .

[20]  Hui Ma.  Dynamic Characteristic Analysis of a Rotor System with Pedestal Looseness Coupled Rub-impact Fault , 2012 .

[21]  Chandan Kumar,et al.  Experimental investigation on misalignment fault detection in induction motors using current and vibration signature analysis , 2015, 2015 International Conference on Futuristic Trends on Computational Analysis and Knowledge Management (ABLAZE).

[22]  David Taylor,et al.  Prediction of fatigue failure in a crankshaft using the technique of crack modelling , 1997 .

[23]  Zhang Lixiang.  Lateral-torsional Coupling Vibration of Rotor System of Hydro-turbine Generator Unit in Electro-magnetic Transitional Condition , 2010 .

[24]  Zissimos P. Mourelatos,et al.  A crankshaft system model for structural dynamic analysis of internal combustion engines , 2001 .

[25]  Mohamed El Hachemi Benbouzid.  A review of induction motors signature analysis as a medium for faults detection , 2000, IEEE Trans. Ind. Electron..

[26]  X. Q. Fu,et al.  Imbalance-misalignment-rubbing coupling faults in hydraulic turbine vibration , 2016 .

[27]  Fulei Chu,et al.  Experimental Investigation of Pedestal Looseness in a Rotor-Bearing System , 2009 .

[28]  Nicola Bianchi,et al.  Salient-rotor PM synchronous motors for an extended flux-weakening operation range , 2000 .

[29]  Zheng-Dong Ma,et al.  An Efficient Multibody Dynamics Model for Internal Combustion Engine Systems , 2003 .

[30]  Yeping Xiong,et al.  Nonlinear coupled dynamics of an asymmetric double-disc rotor-bearing system under rub-impact and oil-film forces , 2016 .

[31]  Ma Hui.  APPLICATION OF TIME-FREQUENCY ANALYSIS TO COUPLING FAULTS WITH OIL-FILM INSTABILITY AND PARTIAL RUB-IMPACT , 2007 .

[32]  Ali Fatemi,et al.  Dynamic Load and Stress Analysis of a Crankshaft , 2007 .

[33]  Agnes Muszynska,et al.  Chaotic responses of unbalanced rotor/bearing/stator systems with looseness or rubs , 1995 .

[34]  P. L. Bogler,et al.  Shafer-dempster reasoning with applications to multisensor target identification systems , 1987, IEEE Transactions on Systems, Man, and Cybernetics.

[35]  Ping Zhang,et al.  A comparison study of basic data-driven fault diagnosis and process monitoring methods on the benchmark Tennessee Eastman process , 2012 .

[36]  Bo-Suk Yang,et al.  Application of Dempster–Shafer theory in fault diagnosis of induction motors using vibration and current signals , 2006 .

[37]  Fulei Chu,et al.  Recent advances in time–frequency analysis methods for machinery fault diagnosis: A review with application examples , 2013 .

[38]  Jun Sun,et al.  Hydrodynamic lubrication analysis of journal bearing considering misalignment caused by shaft deformation , 2004 .

[39]  Naresh K. Raghuwanshi,et al.  Failure Analysis of Internal Combustion EngineValves: A Review , 2012 .

[40]  Wang Hai-fe.  Modeling for whole missile turbofan engine vibration with support looseness fault and characteristics of casing response , 2015 .

[41]  Frede Blaabjerg,et al.  A review of failure mechanisms in wind turbine generator systems , 2015, 2015 17th European Conference on Power Electronics and Applications (EPE'15 ECCE-Europe).

[42]  Wen Bang-chun.  Looseness-rubbing coupling fault of dual-disk three-support rotor-bearing system , 2013 .

[43]  Li Fu-cai.  Review of Signal Processing Methods in Fault Diagnosis for Machinery Using Time-frequency Analysis , 2013 .

[44]  Ali Emadi,et al.  Classification and Review of Control Strategies for Plug-In Hybrid Electric Vehicles , 2011, IEEE Transactions on Vehicular Technology.

[45]  Nigel P. Brandon,et al.  Comparative analysis of battery electric, hydrogen fuel cell and hybrid vehicles in a future sustainable road transport system , 2010 .

[46]  D. Sperling,et al.  China's electric car surge , 2017 .

[47]  L. D. Mitchell,et al.  Detection of a Misaligned Disk Coupling Using Spectrum Analysis , 1984 .

[48]  Wen Bang-chun.  Review and prospect for research of coupling faults in rotor systems , 2012 .

[49]  Junguo Wang,et al.  Nonlinear dynamic analysis of a rub-impact rotor supported by oil film bearings , 2013 .

[50]  Ali Emadi,et al.  Modern electric, hybrid electric, and fuel cell vehicles : fundamentals, theory, and design , 2009 .

[51]  Jianzhong Zhou,et al.  Vibration characteristics of a hydraulic generator unit rotor system with parallel misalignment and rub-impact , 2011 .

[52]  Wen Bang-chun.  Slow and sudden variations of misalignment angles for flexible coupling-rotor system , 2012 .

[53]  Mehrdad Ehsani,et al.  Current status and future trends in More Electric Car power systems , 1999, 1999 IEEE 49th Vehicular Technology Conference (Cat. No.99CH36363).

[54]  Zhang Guoyua.  A Nonlinear Dynamic Model and Its Stability for the Generator Rotor With Coupling the Unbalanced Electromagnetic Force and the Oil Film Force , 2014 .

[55]  Fengxing Zhou,et al.  Demodulated resonance technique in fault diagnosis of high speed line rolling-mill synchromesh gears , 2012, 2012 IEEE International Conference on Imaging Systems and Techniques Proceedings.

[56]  Zhou Ya.  Research on Fault Analysis and Dispose for Oil Film Whirl of Large Steam Turbine Rotor-bearing System , 2014 .

[57]  Takashi Matsuyama,et al.  Belief formation from observation and belief integration using virtual belief space in Dempster-Shafer probability model , 1994, Proceedings of 1994 IEEE International Conference on MFI '94. Multisensor Fusion and Integration for Intelligent Systems.

[58]  Aijun Hu,et al.  Nonlinear dynamics of an asymmetric rotor-bearing system with coupling faults of crack and rub-impact under oil-film forces , 2016 .

[59]  Xiao Ha.  Dynamic modeling and response signal decomposition for a sliding bearing-rotor system with unbalance-misalignment-rubbing coupled faults , 2013 .

[60]  Xiao Li.  Finite Element Analyses on Transverse Vibration in Large Hydro-electric Generating Set , 2006 .

[61]  J. Xie,et al.  Review of electric vehicle policies in China: Content summary and effect analysis , 2017 .

[62]  Gan Chun-biao Yang Shi-xi Wang Yue-hua Yang Dan.  Analysis on response of a rotor with initial bend deformation under coupling fault of crack and rub-impact , 2014 .