Chemo‐Mechanical Coupling in Fractured Shale With Water and Hydrocarbon Flow

The transport of chemically reactive fluids through fractured clay‐rich rocks is fundamental to many subsurface engineering technologies. Here, we present results of direct‐shear laboratory experiments with simultaneous imaging by X‐ray Computed Tomography in Opalinus claystone with subsequent fluid injection to unravel the interplay between mechanical fracture deformation, fluid sorption, and flow. Under constant radial stress (σc = 1.5 MPa), the average mechanical aperture d¯CT increases with shear displacement. Upon brine injection, d¯CT is reduced by 40% relative to initial conditions ( d¯CT0=140−250 μm) and fluid‐sorption induces a divergent displacement of the two sample halves (Δh = ±50 − 170 μm) quantified by digital image correlation. None of these changes are observed in a control experiment with decane, indicating that creep is subordinate to swelling in sealing the fracture. Swelling‐induced changes in permeability within the fracture are heterogeneous and largely affect the fracture flow field, as computed using numerical simulations.

[1]  D. Giardini,et al.  Shale fault zone structure and stress dependent anisotropic permeability and seismic velocity properties (Opalinus Clay, Switzerland) , 2021 .

[2]  M. Mazzotti,et al.  Fault sealing and caprock integrity for CO2 storage: an in situ injection experiment , 2020, Solid Earth.

[3]  J. Ajo-Franklin,et al.  The Sealing Mechanisms of a Fracture in Opalinus Clay as Revealed by in situ Synchrotron X-Ray Micro-Tomography , 2020, Frontiers in Earth Science.

[4]  D. Elsworth,et al.  Swelling and embedment induced by sub- and super-critical-CO2 on the permeability of propped fractures in shale , 2020, International Journal of Coal Geology.

[5]  S. Wiemer,et al.  Fault Stability Perturbation by Thermal Pressurization and Stress Transfer Around a Deep Geological Repository in a Clay Formation , 2019, Journal of Geophysical Research: Solid Earth.

[6]  R. Pini,et al.  Spatial Mapping of Fracture Aperture Changes With Shear Displacement Using X‐ray Computerized Tomography , 2019, Journal of Geophysical Research: Solid Earth.

[7]  J. Avouac,et al.  Stabilization of fault slip by fluid injection in the laboratory and in situ , 2019, Science Advances.

[8]  M. Violay,et al.  Contrasting Mechanical and Hydraulic Properties of Wet and Dry Fault Zones in a Proposed Shale‐Hosted Nuclear Waste Repository , 2019, Geophysical Research Letters.

[9]  S. den Hartog,et al.  Chemo-mechanical behavior of clay-rich fault gouges affected by CO2 -brine-rock interactions , 2018, Greenhouse Gases: Science and Technology.

[10]  T. Mitchell,et al.  Fault Reactivation by Fluid Injection: Controls From Stress State and Injection Rate , 2018, Geophysical Research Letters.

[11]  R. Giot,et al.  Self-sealing of claystone under X-ray nanotomography , 2018, Special Publications.

[12]  H. M. Wentinck,et al.  Swelling stress development in confined smectite clays through exposure to CO2 , 2018, International Journal of Greenhouse Gas Control.

[13]  J. Rutqvist,et al.  Permeability Variations Associated With Fault Reactivation in a Claystone Formation Investigated by Field Experiments and Numerical Simulations , 2018 .

[14]  D. Elsworth,et al.  The influence of Preslip Sealing on the Permeability Evolution of Fractures and Faults , 2018 .

[15]  D. Crandall,et al.  CT scanning and flow measurements of shale fractures after multiple shearing events , 2017 .

[16]  H. Viswanathan,et al.  Caprock integrity susceptibility to permeable fracture creation , 2017 .

[17]  Harvey E. Goodman,et al.  Large Rock Mass Experimentation @ Mont Terri Underground Research Laboratory – CO2 Containment Assurance Experiments , 2017 .

[18]  P. Cerasi,et al.  Shale Creep as Leakage Healing Mechanism in CO2 Sequestration , 2017 .

[19]  T. Ishibashi,et al.  Frictional stability‐permeability relationships for fractures in shales , 2017 .

[20]  Peter Connolly,et al.  Mont Terri rock laboratory, 20 years of research: introduction, site characteristics and overview of experiments , 2017, Swiss Journal of Geosciences.

[21]  C. Spiers,et al.  Coupling of swelling, internal stress evolution, and diffusion in coal matrix material during exposure to methane , 2017 .

[22]  D. Jaeggi,et al.  The Mont Terri rock laboratory , 2016 .

[23]  L. Laloui,et al.  Anisotropic volumetric behaviour of Opalinus clay shale upon suction variation , 2016 .

[24]  S. Norris,et al.  Engineered damage zone sealing during a water injection test at the Tournemire URL , 2016, Environmental Earth Sciences.

[25]  S. Benson,et al.  A calibration-free approach for measuring fracture aperture distributions using X-ray computed tomography , 2016 .

[26]  Hari S. Viswanathan,et al.  Fracture-permeability behavior of shale , 2015 .

[27]  Justin L. Rubinstein,et al.  Myths and Facts on Wastewater Injection, Hydraulic Fracturing, Enhanced Oil Recovery, and Induced Seismicity , 2015 .

[28]  Pierre Henry,et al.  Seismicity triggered by fluid injection–induced aseismic slip , 2015, Science.

[29]  R. Ewy.  Shale swelling/shrinkage and water content change due to imposed suction and due to direct brine contact , 2014 .

[30]  Hiroki Sone,et al.  Mechanical properties of shale-gas reservoir rocks — Part 2: Ductile creep, brittle strength, and their relation to the elastic modulus , 2013 .

[31]  W. Ellsworth.  Injection-Induced Earthquakes , 2013, Science.

[32]  Ruben Juanes,et al.  No geologic evidence that seismicity causes fault leakage that would render large-scale carbon capture and storage unsuccessful , 2012, Proceedings of the National Academy of Sciences.

[33]  Steven M Gorelick,et al.  Earthquake triggering and large-scale geologic storage of carbon dioxide , 2012, Proceedings of the National Academy of Sciences.

[34]  Jonny Rutqvist,et al.  Impact of CO2 geological sequestration on the nucleation of earthquakes , 2011 .

[35]  Chun-liang Zhang.  Experimental evidence for self-sealing of fractures in claystone , 2011 .

[36]  J. Harrington,et al.  Fracture transmissivity as a function of normal and shear stress : first results in Opalinus Clay , 2011 .

[37]  M. Jobmann,et al.  Investigation of damage-induced permeability of Opalinus clay , 2010 .

[38]  R. Wong,et al.  Characterization of Variable Aperture Rock Fractures Using X‐ray Computer Tomography , 2010 .

[39]  C. Marone,et al.  Frictional and hydrologic properties of clay‐rich fault gouge , 2009 .

[40]  Chun-liang Zhang,et al.  Damage and sealing of clay rocks detected by measurements of gas permeability , 2008 .

[41]  Wim Bastiaens,et al.  SELFRAC: Experiments and conclusions on fracturing, self-healing and self-sealing processes in clays , 2007 .

[42]  Paul Marschall,et al.  Characterisation of Gas Transport Properties of the Opalinus Clay, a Potential Host Rock Formation for Radioactive Waste Disposal , 2005 .

[43]  K D Eigenbrod,et al.  Self-healing in fractured fine-grained soils , 2003 .

[44]  Marte Gutierrez,et al.  Stress-dependent permeability of a de-mineralised fracture in shale , 2000 .

[45]  M. Zoback,et al.  Fault reactivation and fluid flow along a previously dormant normal fault in the northern North Sea , 2000 .

[46]  János Urai,et al.  Top-seal leakage through faults and fractures: the role of mudrock properties , 1999, Geological Society, London, Special Publications.

[47]  D. Dewhurst,et al.  Permeability and fluid flow in natural mudstones , 1999, Geological Society, London, Special Publications.

[48]  Robert W. Zimmerman,et al.  Effect of shear displacement on the aperture and permeability of a rock fracture , 1998 .

[49]  M. Yamano,et al.  The seismogenic zone of subduction thrust faults , 1997 .

[50]  E. Drumm,et al.  Infiltration Tests on Fractured Compacted Clay , 1997 .

[51]  Gudmundur S. Bodvarsson,et al.  Hydraulic conductivity of rock fractures , 1996 .

[52]  J. D. Rockaway,et al.  Swelling pressure studies of shales , 1986 .

[53]  P. A. Witherspoon,et al.  Hydromechanical behavior of a deformable rock fracture subject to normal stress , 1981 .

[54]  P. Handler.  Solid surfaces and the gas-solid interface advances in chemistry series no. 33: American Chemical Society, Washington, D.C. , 1962 .

[55]  W. Zisman,et al.  SOLID SURFACES: and the Gas-Solid Interface , 1961 .