Experimental study on the flow and heat transfer characteristics of a tetra-n-butyl ammonium bromide hydrate slurry (first report: Flow characteristics)

The flow characteristics of a tetra-n-butyl ammonium bromide hydrate slurry were investigated experimentally. Reynolds number, tube diameter and solid fraction were varied as the experimental parameters. For laminar flow, it was found that the ratio of the coefficients of pipe friction increases with solid fraction, and the rate of increase is high in the case of a low Reynolds number. For turbulent flow, the ratio of the coefficients of pipe friction was approximately 1 for all tube diameters at low solids fraction. It then decreased slightly at a particular solid fraction and increased again at high solid fraction. Theoretical analysis was carried out using the experimental results, and it was found that the flow characteristics of the hydrate slurry can be treated as those of a pseudoplastic fluid and clarified using the apparent Reynolds number.

[1]  G. A. Jeffrey,et al.  Hydrates of the Tetra n‐butyl and Tetra i‐amyl Quaternary Ammonium Salts , 1959 .

[2]  T. Ebinuma,et al.  Separation of Gas Molecule Using Tetra-n-butyl Ammonium Bromide Semi-Clathrate Hydrate Crystals , 2003 .

[3]  A. Saito.  Recent advances in research on cold thermal energy storage , 2002 .

[4]  J. Herri,et al.  Rheological study of TBAB hydrate slurries as secondary two-phase refrigerants , 2005 .

[5]  T. Hirata,et al.  Flow characteristics of ice slurry in narrow tubes , 2010 .

[6]  Hiroyuki Oyama,et al.  Phase diagram, latent heat, and specific heat of TBAB semiclathrate hydrate crystals , 2005 .

[7]  V. Ayel,et al.  Rheology, flow behaviour and heat transfer of ice slurries: a review of the state of the art , 2003 .

[8]  A. B. Metzner,et al.  Flow of non‐newtonian fluids—correlation of the laminar, transition, and turbulent‐flow regions , 1955 .

[9]  Hiroyuki Oyama,et al.  Free-growth forms and growth kinetics of tetra-n-butyl ammonium bromide semi-clathrate hydrate crystals , 2005 .

[10]  B. Niezgoda-Żelasko,et al.  Momentum transfer of ice slurry flows in tubes, experimental investigations , 2006 .

[11]  X. Rui,et al.  Experimental investigation on TBAB clathrate hydrate slurry flows in a horizontal tube: Forced convective heat transfer behaviors , 2009 .

[12]  Michael Kauffeld,et al.  From physical properties of ice slurries to industrial ice slurry applications , 2005 .

[13]  Ruzhu Wang,et al.  Forced flow and convective melting heat transfer of clathrate hydrate slurry in tubes , 2010 .