Investigations of swirl flames in a gas turbine model combustor: I. Flow field, structures, temperature, and species distributions

Abstract A gas turbine model combustor for swirling CH 4 /air diffusion flames at atmospheric pressure with good optical access for detailed laser measurements is discussed. Three flames with thermal powers between 7.6 and 34.9 kW and overall equivalence ratios between 0.55 and 0.75 were investigated. These behave differently with respect to combustion instabilities: Flame A burned stably, flame B exhibited pronounced thermoacoustic oscillations, and flame C, operated near the lean extinction limit, was subject to sudden liftoff with partial extinction and reanchoring. One aim of the studies was a detailed experimental characterization of flame behavior to better understand the underlying physical and chemical processes leading to instabilities. The second goal of the work was the establishment of a comprehensive database that can be used for validation and improvement of numerical combustion models. The flow field was measured by laser Doppler velocimetry, the flame structures were visualized by planar laser-induced fluorescence (PLIF) of OH and CH radicals, and the major species concentrations, temperature, and mixture fraction were determined by laser Raman scattering. The flow fields of the three flames were quite similar, with high velocities in the region of the injected gases, a pronounced inner recirculation zone, and an outer recirculation zone with low velocities. The flames were not attached to the fuel nozzle and thus were partially premixed before ignition. The near field of the flames was characterized by fast mixing and considerable finite-rate chemistry effects. CH PLIF images revealed that the reaction zones were thin (⩽0.5 mm) and strongly corrugated and that the flame zones were short ( h ⩽ 50  mm ). Despite the similar flow fields of the three flames, the oscillating flame B was flatter and opened more widely than the others. In the current article, the flow field, structures, and mean and rms values of the temperature, mixture fraction, and species concentrations are discussed. Turbulence intensities, mixing, heat release, and reaction progress are addressed. In a second article, the turbulence–chemistry interactions in the three flames are treated.

[1]  Normand M. Laurendeau,et al.  Quantitative measurements of nitric oxide in high-pressure (2-5 atm), swirl-stabilized spray flames via laser-induced fluorescence , 2000 .

[2]  Manfred Aigner,et al.  Establishment of a Confined Swirling Natural Gas/Air Flame as a Standard Flame: Temperature and Species Distributions from Laser Raman Measurements , 2002 .

[3]  Ulrich Meier,et al.  LIF imaging and 2D temperature mapping in a model combustor at elevated pressure , 2000 .

[4]  Sanjay M. Correa,et al.  Power generation and aeropropulsion gas turbines: From combustion science to combustion technology , 1998 .

[5]  Jürgen Wolfrum,et al.  Lasers in combustion: From basic theory to practical devices , 1998 .

[6]  Yoshihiro Deguchi,et al.  Industrial applications of temperature and species concentration monitoring using laser diagnostics , 2002 .

[7]  Friedrich Dinkelacker,et al.  Structure of locally quenched highly turbulent lean premixed Flames , 1998 .

[8]  R. Barlow,et al.  The structure of turbulent nonpremixed flames revealed by Raman-Rayleigh-LIF measurements , 1996 .

[9]  C. Carter,et al.  Simultaneous CH planar laser-induced fluorescence and particle imaging velocimetry in turbulent nonpremixed flames , 1998 .

[10]  Normand M. Laurendeau,et al.  Comparison of laser-induced and planar laser-induced fluorescence measurements of nitric oxide in a high-pressure, swirl-stabilized, spray flame , 2000 .

[11]  A. Leipertz,et al.  Simultaneous coherent anti-Stokes Raman scattering and two-dimensional laser Rayleigh thermometry in a contained technical swirl combustor. , 1995, Applied optics.

[12]  David L. Warren,et al.  Turbulent velocity and temperature measurements from a gas-fueled technology combustor with a practical fuel injector , 1995 .

[13]  Wolfgang Meier,et al.  Phase-resolved laser Raman scattering and laser Doppler velocimetry applied to periodic instabilities in a gas turbine model combustor , 2005 .

[14]  J. Daily,et al.  Rotational level dependence of ground state recovery rates for OH X 2Π(v″=0) in atmospheric pressure flames using the picosecond saturating-pump degenerate four-wave mixing probe technique , 2002 .

[15]  M. J. Dyer,et al.  Time-resolved CH (A(2)Delta and B(2)Sigma(-)) laser-induced fluorescence in low pressure hydrocarbon flames. , 1988, Applied optics.

[16]  D. Demare,et al.  Physical Mechanisms of a Lifted NonPremixed Flame Stabilized in an Acoustic Field , 2002 .

[17]  János M. Beér,et al.  Combustion in swirling flows: A review , 1974 .

[18]  N. Syred,et al.  Flame stabilization in recirculation zones of jets with swirl , 1971 .

[19]  O. Keck,et al.  Periodic combustion instabilities in a swirl burner studied by phase-locked planar laser-induced fluorescence , 2003 .

[20]  Jacques Dugue,et al.  Combustion accelerated swirling flows in high confinements , 1992 .

[21]  Robert J. Santoro,et al.  An experimental estimation of mean reaction rate and flame structure during combustion instability in a lean premixed gas turbine combustor , 2000 .

[22]  Winfried Stricker,et al.  Application of spontaneous Raman and Rayleigh scattering and 2D LIF for the characterization of a turbulent CH4/H2/N2 jet diffusion flame , 1998 .

[23]  J. Driscoll,et al.  Optimization of CH fluorescence diagnostics in flames: range of applicability and improvements with hydrogen addition. , 2003, Applied optics.

[24]  X. Duan,et al.  Reaction zone structures and mixing characteristics of partially premixed swirling CH4/air flames in a gas turbine model combustor , 2005 .

[25]  H. M. Crosswhite,et al.  The ultraviolet bands of OH Fundamental data , 1962 .

[26]  J. Jeffries,et al.  Collisional processes near the CH B 2Σ- v′=0,1 predissociation limit in laser-induced fluorescence flame diagnostics , 2000 .

[27]  Jay P. Gore,et al.  Flow structure in lean premixed swirling combustion , 2002 .

[28]  R. Barlow,et al.  Effect of Damkohler number on superequilibrium OH concentration in turbulent nonpremixed jet flames , 1990 .

[29]  P. S. Wyckoff,et al.  On the Adequacy of Certain Experimental Observables as Measurements of Flame Burning Rate , 1998 .

[30]  A. Lefebvre.  Gas Turbine Combustion , 1983 .

[31]  Wolfgang Meier,et al.  Investigations of swirl flames in a gas turbine model combustor: II. Turbulence–chemistry interactions , 2006 .

[32]  X. Duan,et al.  Laser Diagnostic Study of the Mechanism of a Periodic Combustion Instability in a Gas Turbine Model Combustor , 2005 .

[33]  D. Crosley,et al.  ELECTRONIC TRANSITION MOMENT AND ROTATIONAL MOMENT AND ROTATIONAL TRANSITION PROBABILITIES IN CH. II. B2SIGMA --X 2PI SYSTEM , 1996 .

[34]  G. Dixon-Lewis,et al.  Structure of laminar flames , 1991 .

[35]  Hans-Joerg Bauer,et al.  New low emission strategies and combustor designs for civil aeroengine applications , 2004 .

[36]  A. Eckbreth.  Laser Diagnostics for Combustion Temperature and Species , 1988 .

[37]  Christoph Hassa,et al.  Experimental and Numerical Investigation of a Planar Combustor Sector at Realistic Operating Conditions , 2001 .

[38]  KoHse-HoingHaus.  Applied Combustion Diagnostics , 2002 .

[39]  David G. Lilley,et al.  Swirl Flows in Combustion: A Review , 1977 .

[40]  Domenic A. Santavicca,et al.  Stability and emissions characteristics of a lean premixed gas turbine combustor , 1996 .