A 10-MHz Green-Mode Automatic Reconfigurable Switching Converter for DVS-Enabled VLSI Systems

A power-efficient, high-frequency, automatic reconfigurable switching converter is presented in this paper for DVS-enabled VLSI systems. Tailored to the system-level power management, the proposed cross-layered green-mode (GM) operation scheme adaptively configures the converter into three operation structures to achieve a seamless step-up/down voltage conversion with minimized power loss. In addition, an adaptive power transistor sizing (APTS) scheme is incorporated to further improve efficiency on the transistor level. To enable high-frequency operation in all power regulation conditions, an i L-assisted single-bound hysteresis controller (SBHC) is also proposed in this work. Meanwhile, in order to suppress output spectrum variations induced by the hysteresis controller, an adaptive frequency compensator (AFC) is employed. The proposed converter was fabricated with IBM 130-nm CMOS process, with a total chip area of 1 mm2. Its output voltage can be seamlessly regulated from 0.9 to 2.2 V, with a maximum load power of 400 mW. The input voltage is designed at 1.5 V, but is variable at any level between 0.9 and 1.8 V. The switching frequency of the converter is regulated at 10 MHz in all three operation modes, with ±3% deviation. Experimental results show a 26.7- μs/V down-tracking and 93.3-μs/V up-tracking speed for dynamic voltage scaling (DVS) reference tracking. Line regulation is maintained below 0.8% throughout the full input voltage range, with a lowest value of 0.17%. The power efficiency stays above 80% over the entire 400-mW power range, with a peak value of 92.1% at 1.2-V output and 250-mW load power.

[1]  Wing-Hung Ki,et al.  Fast-Transient PCCM Switching Converter With Freewheel Switching Control , 2007, IEEE Transactions on Circuits and Systems II: Express Briefs.

[2]  Ke-Horng Chen,et al.  Dithering Skip Modulation, Width and Dead Time Controllers in Highly Efficient DC-DC Converters for System-On-Chip Applications , 2007, IEEE Journal of Solid-State Circuits.

[3]  Wing-Hung Ki,et al.  Ultra Fast Fixed-Frequency Hysteretic Buck Converter With Maximum Charging Current Control and Adaptive Delay Compensation for DVS Applications , 2008, IEEE Journal of Solid-State Circuits.

[4]  Chi-Ying Tsui,et al.  An integrated one-cycle control buck converter with adaptive output and dual loops for output error correction , 2004 .

[5]  Siva G. Narendra,et al.  Leakage in Nanometer CMOS Technologies , 2010 .

[6]  Wing-Hung Ki,et al.  Digitally assisted quasi-V2 hysteretic buck converter with fixed frequency and without using large-ESR capacitor , 2009, 2009 IEEE International Solid-State Circuits Conference - Digest of Technical Papers.

[7]  Dongsheng Ma,et al.  Enabling Power-Efficient DVFS Operations on Silicon , 2010, IEEE Circuits and Systems Magazine.

[8]  T.Y. Man,et al.  A 0.9-V Input Discontinuous-Conduction-Mode Boost Converter With CMOS-Control Rectifier , 2008, IEEE Journal of Solid-State Circuits.

[9]  Dongsheng Ma,et al.  Design and Analysis of Monolithic Step-Down SC Power Converter With Subthreshold DPWM Control for Self-Powered Wireless Sensors , 2010, IEEE Transactions on Circuits and Systems I: Regular Papers.

[10]  Dongsheng Ma.  Automatic substrate switching circuit for on-chip adaptive power supply system , 2006, 2006 IEEE International Symposium on Circuits and Systems.

[11]  A.P. Chandrakasan,et al.  A 175 mV multiply-accumulate unit using an adaptive supply voltage and body bias (ASB) architecture , 2002, 2002 IEEE International Solid-State Circuits Conference. Digest of Technical Papers (Cat. No.02CH37315).

[12]  Robert W. Erickson,et al.  Fundamentals of Power Electronics , 2001 .

[13]  Wing-Hung Ki,et al.  Integrated 0.9 V charge-control switching converter with self-biased current sensor , 2004, The 2004 47th Midwest Symposium on Circuits and Systems, 2004. MWSCAS '04..

[14]  P.K.T. Mok,et al.  A Monolithic Buck Converter With Near-Optimum Reference Tracking Response Using Adaptive-Output-Feedback , 2007, IEEE Journal of Solid-State Circuits.

[15]  Chi-Ying Tsui,et al.  Integrated direct output current control switching converter using symmetrically-matched self-biased current sensors , 2006, Asia and South Pacific Conference on Design Automation, 2006..

[16]  Chi-Ying Tsui,et al.  A pseudo-CCM/DCM SIMO switching converter with freewheel switching , 2002, 2002 IEEE International Solid-State Circuits Conference. Digest of Technical Papers (Cat. No.02CH37315).

[17]  Massoud Pedram,et al.  Energy Minimization Using Multiple Supply Voltages , 1997 .

[18]  J. Kim,et al.  An efficient digital sliding controller for adaptive power supply regulation , 2001, 2001 Symposium on VLSI Circuits. Digest of Technical Papers (IEEE Cat. No.01CH37185).

[19]  Andreas G. Andreou,et al.  Low-Voltage/Low-Power Integrated Circuits and Systems , 1999 .

[20]  M.A. Horowitz,et al.  A variable-frequency parallel I/O interface with adaptive power-supply regulation , 2000, IEEE Journal of Solid-State Circuits.

[21]  Yi Zhang,et al.  Digitally controlled integrated pseudo-CCM SIMO converter with adaptive freewheel current modulation , 2010, 2010 Twenty-Fifth Annual IEEE Applied Power Electronics Conference and Exposition (APEC).

[22]  Tsz Yin Man,et al.  An Auto-Selectable-Frequency Pulse-Width Modulator for Buck Converters with Improved Light-Load Efficiency , 2008, 2008 IEEE International Solid-State Circuits Conference - Digest of Technical Papers.

[23]  Niraj K. Jha,et al.  Simultaneous Dynamic Voltage Scaling of Processors and Communication Links in Real-Time Distributed Embedded Systems , 2007, IEEE Transactions on Very Large Scale Integration (VLSI) Systems.

[24]  Pengfei Li,et al.  Digitally assisted discontinuous conduction mode 5V/100MHz and 10V/45MHz DC-DC boost converters with integrated Schottky diodes in standard 0.13µm CMOS , 2010, 2010 IEEE International Solid-State Circuits Conference - (ISSCC).

[25]  G.A. Rincon-Mora,et al.  A low voltage, dynamic, noninverting, synchronous buck-boost converter for portable applications , 2004, IEEE Transactions on Power Electronics.

[26]  Pengfei Li,et al.  A 90–240MHz hysteretic controlled DC-DC buck converter with digital PLL frequency locking , 2008, 2008 IEEE Custom Integrated Circuits Conference.

[27]  Dongsheng Ma,et al.  Integrated adaptive step-up/down switching DCDC converter with tri-band tri-mode digital control for dynamic voltage scaling , 2008, 2008 IEEE International Symposium on Industrial Electronics.

[28]  Chen Zheng,et al.  A 10MHz 92.1%-efficiency green-mode automatic reconfigurable switching converter with adaptively compensated single-bound hysteresis control , 2010, 2010 IEEE International Solid-State Circuits Conference - (ISSCC).

[29]  Anantha P. Chandrakasan,et al.  An energy/security scalable encryption processor using an embedded variable voltage DC/DC converter , 1998 .

[30]  P.K.T. Mok,et al.  A 1-V integrated current-mode boost converter in standard 3.3/5-V CMOS technologies , 2005, IEEE Journal of Solid-State Circuits.

[31]  O. Trescases.  A Digitally Controlled DC-DC Converter Module with a Segmented Output Stage for Optimized Efficiency , 2007, Proceedings of the International Symposium on Power Semiconductor Devices & ICs.