Design and performance research on eliminating multiple reflections of solar radiation within compound parabolic concentrator (CPC) in hybrid CPV/T system

Abstract Aimed at developing a concentrating flat-plate photovoltaic-thermal (CPV/T) system of low cost and high output, a new-type eliminating multiple reflections CPC (EMR) with a geometric concentration ratio 4× was designed, and the best concentration plane of EMR, full CPC (FUL) and half truncation CPC (HAL) were defined to conduct optical performance study. Afterward, the material consumption assessment method was developed to evaluate the reflector and support material consumption of EMR, FUL and HAL, and the Monte-Carlo simulation was developed to calculate the values of uniformity and optical efficiency of those three types of CPCs. Additionally, the formula method was employed to figure out the optical efficiency of EMR in simple and convenient way, and the EMR related experiments were carried out to testify the theoretical results of EMR figured out via the Monte-Carlo simulation and formula method in different total solar irradiance (TSI) and ratio of direct normal irradiance (DNI) to TSI. Finally, the research shows that the experimental results of EMR are in good agreement with the theoretical data of EMR calculated via the Monte-Carlo simulation and formula method, and that the uniformity on best concentration plane is better than that of outlet aperture, indicating that not only the reflector and support material consumption of EMR is the minimum among those of EMR, FUL and HAL, but also the uniformity and optical efficiency of EMR is the best among them according to the comparative research with the material consumption assessment method and Monte-Carlo simulation adopted. Especially, the material consumption of EMR is about one-half less than that of FUL when geometric concentration ratio is 4×, meanwhile, the uniformity of EMR on best concentration plane is about 20% more than that of FUL and the optical efficiency of EMR is about 2% more than that of FUL. Furthermore, theoretical and test results show that the optical efficiency of EMR can exceed 80% when the ratio of DNI to TSI is equal to or greater than 0.8, and then a new CPV/T system was assembled with EMR, PV/T and low-precision solar tracking subsystem, and the overall efficiency of the CPV/T system can exceed 71%. In conclusion, it is obvious that the EMR has more extensive application potential compared to FUL and those traditional truncation CPCs such as HAL.

[1]  Chigueru Tiba,et al.  Analytic solutions for the geometric and optical properties of stationary compound parabolic concentrators with fully illuminated inverted V receiver , 2008 .

[2]  T. Mallick,et al.  Numerical modelling and experimental validation of a low concentrating photovoltaic system , 2013 .

[3]  Ewan D. Dunlop,et al.  Characterization of a pulsed solar simulator for concentrator photovoltaic cell calibration , 2010 .

[4]  Jyeshtharaj B. Joshi,et al.  Performance analysis of a novel and cost effective CPC system , 2013 .

[5]  Björn Karlsson,et al.  Optical efficiency of a PV-thermal hybrid CPC module for high latitudes , 2001 .

[6]  Ji Jie,et al.  Experiment and simulation study on the flux distribution of lens-walled compound parabolic concentrator compared with mirror compound parabolic concentrator , 2013 .

[7]  A. Rabl.  Optical and thermal properties of Compound Parabolic Concentrators , 1975 .

[8]  Qiang Yao,et al.  The Effect of Non-Uniform Illumination on the Performance of Conventional Polycrystalline Silicon Solar Cell , 2008 .

[9]  Jinjia Wei,et al.  Numerical investigation on uniformity of heat flux for semi-gray surfaces inside a solar cavity receiver , 2015 .

[10]  H. P. Garg,et al.  Optical design calculations for CPCS , 1998 .

[11]  Jinjia Wei,et al.  Thermal performance simulation of a solar cavity receiver under windy conditions , 2011 .

[12]  Gang Pei,et al.  Comparative study on annual solar energy collection of a novel lens-walled compound parabolic concentrator (lens-walled CPC) , 2012 .

[13]  T. Mallick,et al.  Performance analysis of a dielectric based 3D building integrated concentrating photovoltaic system , 2014 .

[14]  Stefan W. Glunz,et al.  BICON: high concentration PV using one‐axis tracking and silicon concentrator cells , 2006 .

[15]  A. Zahedi.  Review of modelling details in relation to low-concentration solar concentrating photovoltaic , 2011 .

[16]  Roland Winston,et al.  Design and test of non-evacuated solar collectors with compound parabolic concentrators , 1979 .

[17]  Yiannis Tripanagnostopoulos,et al.  Integrated collector storage solar systems with asymmetric CPC reflectors , 2004 .

[18]  Hulin Huang,et al.  A Novel Lens-Walled Compound Parabolic Concentrator for Photovoltaic Applications , 2012 .

[19]  Chigueru Tiba,et al.  Optical and thermal optimization of stationary non-evacuated CPC solar concentrator with fully illuminated wedge receivers , 2011 .

[20]  Jian Sun,et al.  Numerical study on optical and electric-thermal performance for solar concentrating PV/T air system , 2009 .

[21]  Thermodynamically efficient solar concentrators , 2012 .

[22]  Korbinian Kramer,et al.  Multi-linear performance model for hybrid (C)PVT solar collectors , 2013 .

[23]  Tapas K. Mallick,et al.  Optical efficiency study of PV Crossed Compound Parabolic Concentrator , 2013 .

[24]  Björn Karlsson,et al.  Mitigating the non-uniform illumination in low concentrating CPCs using structured reflectors , 2009 .

[25]  J. Coventry.  Performance of a concentrating photovoltaic/thermal solar collector , 2005 .

[26]  Jinfu Wang,et al.  A note on multiple reflections of radiation within CPCs and its effect on calculations of energy collection , 2013 .

[27]  Graham L. Morrison,et al.  Theoretical analysis of a novel, portable, CPC-based solar thermal collector for methanol reforming , 2014 .

[28]  Björn Karlsson,et al.  Evaluation of CPC-collector designs for stand-alone, roof- or wall installation , 2005 .

[29]  Ruzhu Wang,et al.  Concentrated solar energy applications using Fresnel lenses: A review , 2011 .

[30]  Tapas K. Mallick,et al.  Non-uniform illumination in concentrating solar cells , 2012 .

[31]  Francesco Calise,et al.  A novel solar trigeneration system based on concentrating photovoltaic/thermal collectors. Part 1: Design and simulation model , 2013 .

[32]  Said Farahat,et al.  Thermal and Electrical Assessment of an Integrated Solar Photovoltaic Thermal (PV/T) Water Collector Equipped with a Compound Parabolic Concentrator (CPC) , 2013 .