Pollution control and metal resource recovery for acid mine drainage

Abstract Although the metals contained in acid mine drainage (AMD) are considered environmental pollutants, they may also be valuable resources. The traditional chemical precipitation processes for AMD not only produce large amounts of sludge, but also make it difficult to recycle the waste metals. This study comprehensively investigated the recycling of Fe, Cu, Zn and Mn from AMD. Ferrous ions were first oxidised by 0.15 ml/L 30% H 2 O 2 , and then a four-step fractional precipitation was applied with the selective addition of Ca(OH) 2 and Na 2 S solutions. The Fe, Cu, Zn and Mn contents of particular sludges were 45.91%, 11.58%, 31.06% and 7.95% respectively, and the recovery efficiencies of Fe, Cu, Zn and Mn from AMD reached 99.51%, 86.09%, 87.87% and 79.71%, respectively. The metals contained in the effluent were below the Code of Federal Regulations (CFR) limits after the Mn precipitation process. Technology for the complete reuse of the sludge was also tested. Fe oxide red was obtained by roasting the Fe sludge for 30 min at a temperature of 500 °C, resulting in a Fe 2 O 3 content of 85.18%. Cu and Zn crude concentrates were generated by a flotation process; the Cu and Zn contents of these concentrates were 35.72% and 55.13% respectively, and the recovery efficiencies of the Cu and Zn were 72.66% and 76.18%, respectively. The Mn sludge obtained can be used in cement mixes to replace 45% of ordinary Portland cement (OPC). Based on the technology tested, a comprehensive metal recovery process is proposed here for the control of metal pollution and metal recovery from AMD.

[1]  R. Hammack,et al.  The removal of nickel from mine waters using bacterial sulfate reduction , 1992, Applied Microbiology and Biotechnology.

[2]  A. Bernardes,et al.  Spent NiMH batteries—The role of selective precipitation in the recovery of valuable metals , 2009 .

[3]  F. Pagnanelli,et al.  Selective precipitation of metals from synthetic spent refinery catalyst leach liquor with biogenic H2S produced in a lactate-fed anaerobic baffled reactor , 2013 .

[4]  D. Atwood,et al.  Chemical precipitation of heavy metals from acid mine drainage. , 2002, Water research.

[5]  Nicholas F. Gray,et al.  Acid mine drainage composition and the implications for its impact on lotic systems , 1998 .

[6]  F. Pagnanelli,et al.  Leaching of low-grade manganese ores by using nitric acid and glucose: optimization of the operating conditions , 2004 .

[7]  D. Banerjee,et al.  Comparison of two sequential extraction procedures for heavy metal partitioning in mine tailings. , 2010, Chemosphere.

[8]  G. Pérez,et al.  Zinc recovery from an effluent using Ionquest 290: From laboratory scale to pilot plant , 2011 .

[9]  H. Matsuda,et al.  Study on reaction kinetics and selective precipitation of Cu, Zn, Ni and Sn with H₂S in single-metal and multi-metal systems. , 2008, Chemosphere.

[10]  A. Brand,et al.  Formation and stability of schwertmannite in acidic mining lakes , 2004 .

[11]  M. Katsioti,et al.  Properties of stabilized/solidified admixtures of cement and sewage sludge , 2007 .

[12]  J. Webb,et al.  Chemical stability of acid rock drainage treatment sludge and implications for sludge management. , 2006, Environmental science & technology.

[13]  William J. Mitsch,et al.  Water quality, fate of metals, and predictive model validation of a constructed wetland treating acid mine drainage , 1998 .

[14]  Nicomedes D. Briones.  Mining pollution: The case of the Baguio mining district, the philippines , 1987 .

[15]  Francesco Vegliò,et al.  Recovery of rare earths and base metals from spent nickel-metal hydride batteries by sequential sulphuric acid leaching and selective precipitations , 2012 .

[16]  M. McBride,et al.  Health risk from heavy metals via consumption of food crops in the vicinity of Dabaoshan mine, South China. , 2009, The Science of the total environment.

[17]  Y. Ma,et al.  Well water contaminated by acidic mine water from the Dabaoshan Mine, south China: chemistry and toxicity. , 2007, Chemosphere.

[18]  D. Johnson,et al.  Sulfidogenesis and selective precipitation of metals at low pH mediated by Acidithiobacillus spp. and acidophilic sulfate-reducing bacteria , 2010 .

[19]  K. A. Matis,et al.  Copper removal from effluents by various separation techniques , 2004 .

[20]  Mohamed Lachemi,et al.  Utilization of tailings from tungsten mine waste as a substitution material for cement , 2009 .

[21]  I. Schneider,et al.  Selective precipitation/UV production of magnetite particles obtained from the iron recovered from acid mine drainage , 2012 .

[22]  E. Meux,et al.  Use of sodium decanoate for selective precipitation of metals contained in industrial wastewater. , 2007, Chemosphere.

[23]  G. Banfalvi.  Removal of insoluble heavy metal sulfides from water. , 2006, Chemosphere.

[24]  E. Meux,et al.  Selective precipitation of cadmium from nickel cadmium sulphate solutions using sodium decanoate , 2008 .

[25]  M. Räisänen,et al.  Seasonal variations of ochreous precipitates in mine effluents in Finland , 2007 .

[26]  C. Polprasert,et al.  Electrochemical precipitation of chromium (Cr6+) from an electroplating wastewater , 1995 .

[27]  J. Weijma,et al.  Control of the sulfide (S2-) concentration for optimal zinc removal by sulfide precipitation in a continuously stirred tank reactor. , 2003, Water research.

[28]  D Barrie Johnson,et al.  Acid mine drainage remediation options: a review. , 2005, The Science of the total environment.

[29]  S. Beauchemin,et al.  Arsenic in an alkaline AMD treatment sludge: Characterization and stability under prolonged anoxic conditions , 2010 .

[30]  B. Xia,et al.  Human health risk from soil heavy metal contamination under different land uses near Dabaoshan Mine, Southern China. , 2012, The Science of the total environment.

[31]  Jerry M. Bigham,et al.  Sorption of trace metals to an aluminum precipitate in a stream receiving acid rock-drainage; Snake River, Summit County, Colorado , 2002 .

[32]  Yanting Xie,et al.  Recovery of nickel, copper and cobalt from low-grade Ni–Cu sulfide tailings , 2005 .

[33]  G. Faure,et al.  Removal of trace metals by coprecipitation with Fe, Al and Mn from natural waters contaminated with acid mine drainage in the Ducktown Mining District, Tennessee , 2002 .

[34]  Bart Van der Bruggen,et al.  Distillation vs. membrane filtration: overview of process evolutions in seawater desalination , 2002 .

[35]  F. Farges,et al.  Zn–Ni sulfide selective precipitation: The role of supersaturation , 2010 .

[36]  R. Hammack,et al.  Treatment of water from an open-pit copper mine using biogenic sulfide and limestone: A feasibility study , 1994 .

[37]  Eun-hee Lee,et al.  Influence of acid mine drainage on microbial communities in stream and groundwater samples at Guryong Mine, South Korea , 2009 .

[38]  Zaini Ujang,et al.  Application of low-pressure reverse osmosis membrane for Zn2+ and Cu2+ removal from wastewater , 1996 .

[39]  T. Igarashi,et al.  Acid mine drainage treatment through a two-step neutralization ferrite-formation process in northern Japan: Physical and chemical characterization of the sludge , 2007 .

[40]  Dynamic Modelling and Process Control of ZnS Precipitation , 2006 .

[41]  F. W. Gilcreas,et al.  Standard methods for the examination of water and waste water. , 1966, American journal of public health and the nation's health.

[42]  Jorge Rubio,et al.  The FF (flocculation–flotation) process , 2005 .