Boiling of droplets on a hot surface in low gravity

Abstract The boiling of single droplets of water and n-heptane on a hot stainless steel surface was observed in a low gravity environment, obtained on board a platform in free fall. Droplet impact was photographed using a single-shot flash-photographic method. Surface temperature variation during droplet impact was recorded using a fast-response thermocouple. Droplets could not be maintained in stable film boiling in low gravity: the pressure of vapour under droplets pushed them away from the surface. Nucleate boiling of droplets was not affected by a reduction in gravity. Vapour bubbles nucleating on the solid surface separated and rose into the liquid even in the absence of buoyancy forces.

[1]  J. Thome,et al.  Convective Boiling and Condensation , 1972 .

[2]  L. Bolle,et al.  SPRAY COOLING OF HOT SURFACES , 1982 .

[3]  D. Schroeder-Richter,et al.  A new model describing the superheated state of the wall layer during nucleate boiling , 1990 .

[4]  K. Baumeister,et al.  Leidenfrost temperature - Its correlation for liquid metals, cryogens, hydrocarbons, and water. , 1973 .

[5]  R. E. Henry.  A correlation for the minimum film boiling temperature , 1974 .

[6]  C. Avedisian,et al.  On the collision of a droplet with a solid surface , 1991, Proceedings of the Royal Society of London. Series A: Mathematical and Physical Sciences.

[7]  S. Yao,et al.  Analysis on film boiling heat transfer of impacting sprays , 1989 .

[8]  Kenneth J. Bell,et al.  The leidenfrost phenomenon: film boiling of liquid droplets on a flat plate , 1966 .

[9]  Kotaro Tanaka,et al.  Observational Study of Pool Boiling under Microgravity , 1992 .

[10]  M. Poniewski.  Dissipative model of film boiling crisis , 1987 .

[11]  A. E. Dukler,et al.  Gas liquid flow at microgravity conditions - Flow patterns and their transitions , 1988 .

[12]  S. Chandra,et al.  Leidenfrost Evaporation of Liquid Nitrogen Droplets , 1994 .

[13]  J. Ervin,et al.  Transient pool boiling in microgravity , 1992 .

[14]  Hiroshi Kawamura,et al.  Transient Temperature Profile of a Hot Wall Due to an Impinging Liquid Droplet , 1978 .

[15]  H. Merte,et al.  Boiling Heat Transfer With Cryogenic Fluids at Standard, Fractional, and Near-Zero Gravity , 1964 .

[16]  J. Straub,et al.  POOL BOILING IN A REDUCED GRAVITY FIELD , 1990 .

[17]  A. W. Cronenberg,et al.  On the Minimum Film Boiling Conditions for Spherical Geometries , 1980 .

[18]  R. Hendricks,et al.  Thermally driven oscillations and wave motion of a liquid drop , 1977 .

[19]  Shigefumi Nishio,et al.  DIRECT CONTACT PHENOMENON BETWEEN A LIQUID DROPLET AND HIGH TEMPERATURE SOLID SURFACE , 1978 .

[20]  R. Siegel.  Effects of reduced gravity on heat transfer. , 1967 .

[21]  J. C. Jaeger,et al.  Conduction of Heat in Solids , 1952 .

[22]  T. Cochran.  Forced convection boiling near inception in zero-gravity , 1970 .

[23]  S. Yao,et al.  Mechanisms of film boiling heat transfer of normally impacting spray , 1987 .

[24]  K. S. Rezkallah,et al.  A comparison of existing flow-pattern predictions during forced-convective two-phase flow under microgravity conditions , 1990 .

[25]  B. Antar,et al.  Boiling heat transfer in the quenching of a hot tube under microgravity , 1995 .