Biogas production by anaerobic co-digestion of cattle slurry and cheese whey.

Biogas yield of mixtures of cattle slurry and cheese whey, rates of production of methane, removal efficiencies of chemical oxygen demand (COD) and biological oxygen demand (BOD) were investigated at 35 °C. Stable biogas production of 621 l/kg volatile solids at a hydraulic retention time of 42 days in a mixture containing 50% slurry and whey was obtained. The concentration of methane in the biogas was around 55%. Maximum removal efficiencies for COD and BOD5 were 82% and 90%, respectively. A maximum biogas production increase of 79% with respect to the start-up phase was achieved. The result of this study show that co-digestion of a high volume of whey (up to 65% in volume) is possible without the use of chemicals for pH correction, but also that this kind of mix has a similar energetic potential for anaerobic digestion as energy crops such as maize.

[1]  P. Weiland.  Biogas production: current state and perspectives , 2009, Applied Microbiology and Biotechnology.

[2]  W. Zollitsch,et al.  Biogas production from maize and dairy cattle manure - influence of biomass composition on the methane yield. , 2007 .

[3]  I. Angelidaki,et al.  Codigestion of manure and organic wastes in centralized biogas plants , 2003, Applied biochemistry and biotechnology.

[4]  B Mattiasson,et al.  Impact of food industrial waste on anaerobic co-digestion of sewage sludge and pig manure. , 2004, Journal of environmental management.

[5]  George Tchobanoglous,et al.  Wastewater Engineering Treatment and Reuse ( Fourth Edition ) , 2011 .

[6]  G. Demirer,et al.  Anaerobic biotransformation and methane generation potential of cheese whey in batch and UASB reactors. , 2001, Waste management.

[7]  Irini Angelidaki,et al.  Optimization of biogas production by co-digesting whey with diluted poultry manure , 2007 .

[8]  Anastassios G. Stamatis,et al.  Thermal analysis and optimization of an anaerobic treatment system of whey , 2011 .

[9]  Kwang Victor Lo,et al.  Anaerobic digestion of cheese whey using an upflow anaerobic sludge blanket reactor. III : Sludge and substrate profiles , 1990 .

[10]  A. Tilche,et al.  Cheese whey and cheese factory wastewater treatment with a biological anaerobic-aerobic process , 1995 .

[11]  A. E. Ghaly,et al.  A comparative study of anaerobic digestion of acid cheese whey and dairy manure in a two-stage reactor , 1996 .

[12]  A. J. Mawson,et al.  Bioconversions for whey utilization and waste abatement , 1994 .

[13]  Jørgen E. Olesen,et al.  Dairy farm CH4 and N2O emissions, from one square metre to the full farm scale , 2006 .

[14]  J. Rintala,et al.  Laboratory investigations on co-digestion of energy crops and crop residues with cow manure for methane production: Effect of crop to manure ratio , 2007 .

[15]  Elena Comino,et al.  Development of a pilot scale anaerobic digester for biogas production from cow manure and whey mix. , 2009, Bioresource technology.

[16]  J. Rintala,et al.  Anaerobic digestion of grass silage in batch leach bed processes for methane production. , 2008, Bioresource technology.

[17]  Bahattin Topaloglu,et al.  Biogas production from co-digestion of a mixture of cheese whey and dairy manure , 2010 .

[18]  Sergey Kalyuzhnyi,et al.  Anaerobic treatment of high-strength cheese-whey wastewaters in laboratory and pilot UASB-reactors , 1997 .

[19]  K. V. Lo,et al.  Anaerobic-aerobic biological treatment of a mixture of cheese whey and dairy manure , 1989 .

[20]  Elena Comino,et al.  Investigation of increasing organic loading rate in the co-digestion of energy crops and cow manure mix. , 2010, Bioresource technology.

[21]  H Lindorfer,et al.  Doubling the organic loading rate in the co-digestion of energy crops and manure--a full scale case study. , 2008, Bioresource technology.

[22]  H. D. Stensel,et al.  Wastewater Engineering: Treatment and Reuse , 2002 .