Technical challenges in operating an SOFC in fuel flexible gas turbine hybrid systems: Coupling effects of cathode air mass flow

Considering the limited turndown potential of gasification technologies, supplementing a fuel cell turbine hybrid power system with natural gas provides flexibility that could improve economic viability. The dynamic characterization of fuel composition transients is an essential first step in completing the system identification required for controls development. In this work, both open loop and closed loop transient responses of the fuel cell in a solid oxide fuel cell (SOFC) gas turbine (GT) hybrid system to fuel composition changes were experimentally investigated using a cyber-physical fuel cell system. A transition from methane lean syngas to methane rich gases with no turbine speed control was studied. The distributed performance of the fuel cell was analyzed in detail with temporal and spatial resolution across the cell.

[1]  Fuel cell e gas turbine hybrid system design part II : Dynamics and control , 2014 .

[2]  Francesco Calise,et al.  Hybrid solid oxide fuel cells–gas turbine systems for combined heat and power: A review , 2015 .

[3]  David Tucker,et al.  IGFC Response to Initial Fuel Cell Load for Various Syngas Compositions , 2011 .

[4]  Thomas A. Adams,et al.  Energy Conversion with Solid Oxide Fuel Cell Systems: A Review of Concepts and Outlooks for the Short- and Long-Term , 2013 .

[5]  Thomas A. Adams,et al.  Open Loop and Closed Loop Performance of Solid Oxide Fuel Cell Turbine Hybrid Systems During Fuel Composition Changes , 2015 .

[6]  Jack Brouwer,et al.  Experimental and theoretical evidence for control requirements in solid oxide fuel cell gas turbine hybrid systems , 2012 .

[7]  Alberto Traverso,et al.  Liquid fuel utilization in SOFC hybrid systems , 2009 .

[8]  Larry E. Banta,et al.  Equivalence Ratio Startup Control of a Fuel Cell Turbine Hybrid System , 2013 .

[9]  David Tucker,et al.  SOFC Lifetime Assessment in Gas Turbine Hybrid Power Systems , 2014 .

[10]  David Tucker,et al.  A Real-Time Spatial SOFC Model for Hardware-Based Simulation of Hybrid Systems , 2011 .

[11]  Thomas A. Adams,et al.  Fuel Composition Transients in Fuel Cell Turbine Hybrid for Polygeneration Applications , 2014 .

[12]  Amornchai Arpornwichanop,et al.  Control structure design and dynamic modeling for a solid oxide fuel cell with direct internal reforming of methane , 2015 .

[13]  Rory A. Roberts,et al.  Control Design for a Bottoming Solid Oxide Fuel Cell Gas Turbine Hybrid System , 2006 .

[14]  J. Brouwer,et al.  Fuel flexibility study of an integrated 25 kW SOFC reformer system , 2005 .

[15]  Alberto Traverso,et al.  Avoiding Compressor Surge During Emergency Shutdown Hybrid Turbine Systems , 2013 .

[16]  Dimitri O. Hughes.  A hardware-based transient characterization of electrochemical start-up in an SOFC/gas turbine hybrid environment using a 1-D real time SOFC model , 2011 .

[17]  David Tucker,et al.  Evaluation of Hybrid Fuel Cell Turbine System Startup With Compressor Bleed , 2005 .

[18]  Thomas A. Adams,et al.  Impact of fuel composition transients on SOFC performance in gas turbine hybrid systems , 2016 .

[19]  F. Jabbari,et al.  Feedback control of solid oxide fuel cell spatial temperature variation , 2010 .

[20]  C. Adjiman,et al.  Anode-supported intermediate temperature direct internal reforming solid oxide fuel cell. I: model-based steady-state performance , 2004 .

[21]  Alberto Traverso,et al.  A distributed real-time model of degradation in a solid oxide fuel cell, part I: Model characterization , 2016 .

[22]  Ryuji Kikuchi,et al.  Fuel flexibility in power generation by solid oxide fuel cells , 2002 .

[23]  Jack Brouwer,et al.  Fuel Cell/Gas Turbine Hybrid System Control for Daily Load Profile and Ambient Condition Variation , 2006 .

[24]  Shinji Kimijima,et al.  Numerical analysis on dynamic behavior of solid oxide fuel cell with power output control scheme , 2013 .

[25]  Thomas A. Adams,et al.  Combining coal gasification, natural gas reforming, and solid oxide fuel cells for efficient polygen , 2011 .

[26]  R. Gorte,et al.  Direct hydrocarbon solid oxide fuel cells. , 2004, Chemical reviews.

[27]  Fabian Mueller,et al.  On the intrinsic transient capability and limitations of solid oxide fuel cell systems , 2009 .

[28]  Daniel Favrat,et al.  Simulation of thermal stresses in anode-supported solid oxide fuel cell stacks. Part I: Probability of failure of the cells , 2009 .

[29]  François Maréchal,et al.  Process integration and optimization of a solid oxide fuel cell – Gas turbine hybrid cycle fueled with hydrothermally gasified waste biomass , 2012 .

[30]  David Tucker,et al.  Fuel Cell Gas Turbine Hybrid Simulation Facility Design , 2002 .

[31]  David Tucker,et al.  General fuel cell hybrid synergies and hybrid system testing status , 2006 .

[32]  David Tucker,et al.  Determination of the Operating Envelope for a Direct Fired Fuel Cell Turbine Hybrid Using Hardware Based Simulation , 2009 .

[33]  Tong Seop Kim,et al.  Design performance analysis of pressurized solid oxide fuel cell/gas turbine hybrid systems considering temperature constraints , 2006 .

[34]  Thomas A. Adams,et al.  Optimal Design and Operation of Flexible Energy Polygeneration Systems , 2011 .

[35]  Lars Imsland,et al.  Control strategy for a solid oxide fuel cell and gas turbine hybrid system , 2006 .

[36]  Tong Seop Kim,et al.  Performance characteristics of a MW-class SOFC/GT hybrid system based on a commercially available gas turbine , 2006 .

[37]  Wei Jiang,et al.  Control Strategies for Start-Up and Part-Load Operation of Solid Oxide Fuel Cell/Gas Turbine Hybrid System , 2010 .

[38]  G. S. Samuelsen,et al.  Power and temperature control of fluctuating biomass gas fueled solid oxide fuel cell and micro gas turbine hybrid system , 2006 .

[39]  Alberto Traverso,et al.  Turbomachinery for the air management and energy recovery in fuel cell gas turbine hybrid systems , 2008 .