Direct contact membrane distillation for the concentration of saline dairy effluent.

The ability of direct contact membrane distillation to concentrate the waste effluent from salty whey, a by-product from the cheese making industry has been investigated. The effect of trace protein in the feed, cross-flow velocity and feed acidity were the factors examined. Flat Sheet PTFE membranes of nominal pore sizes 0.05, 0.22 and 0.45 μm were utilised. A decline in feed flux in the presence of trace protein in the feed was observed, but liquid penetration through the membrane could still be prevented by utilization of a membrane of smaller pore size, to achieve a final total solids concentration of ±30% w/w with water recovery from 37 to 83 %. The pressure-drop across the channel length was also predicted accounting for the feed spacer. To increase the channel length up to 1 m will require operation using the smallest pore size of 0.05 μm, unless very low cross-flow velocities are used. The fouling of the membrane is primarily governed by precipitation of a calcium phosphate salt. However, operation at low pH does not improve the flux or the final salt concentration significantly.

[1]  Dianne E. Wiley,et al.  Spacer characterization and pressure drop modelling in spacer-filled channels for ultrafiltration☆ , 1994 .

[2]  M. Vahdati,et al.  Direct Contact Membrane Distillation , 2000 .

[3]  Bart Van der Bruggen,et al.  Distillation vs. membrane filtration: overview of process evolutions in seawater desalination , 2002 .

[4]  Mohamed Khayet,et al.  Application of response surface methodology and experimental design in direct contact membrane distillation , 2007 .

[5]  Jun-de Li,et al.  Identification of material and physical features of membrane distillation membranes for high performance desalination , 2010 .

[6]  L. Martinez-diez,et al.  Temperature and concentration polarization in membrane distillation of aqueous salt solutions , 1999 .

[7]  Anthony G. Fane,et al.  Membrane distillation crystallization of concentrated salts—flux and crystal formation , 2005 .

[8]  E. Drioli,et al.  Membrane Distillation and Related Operations—A Review , 2005 .

[9]  José M. Rodríguez-Maroto,et al.  On transport resistances in direct contact membrane distillation , 2007 .

[10]  G. Stevens,et al.  Membrane stripping: Desorption of carbon dioxide from alkali solvents , 2011 .

[11]  Thomas Melin,et al.  State-of-the-art of reverse osmosis desalination , 2007 .

[12]  G. Daufin,et al.  Physico-chemical aspects of membrane fouling by dairy fluids , 1995 .

[13]  M. M. Bradford.  A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding. , 1976, Analytical biochemistry.

[14]  Marcel Mulder,et al.  Basic Principles of Membrane Technology , 1991 .

[15]  P. Koutsoukos,et al.  Precipitation of Calcium Phosphate from Simulated Milk Ultrafiltrate Solutions , 2007 .

[16]  Giulio C. Sarti,et al.  Low temperature distillation through hydrophobic membranes , 1987 .

[17]  Giulio C. Sarti,et al.  Heat and mass transport resistances in vacuum membrane distillation per drop , 1999 .

[18]  E. Drioli,et al.  MEMBRANE DISTILLATION , 2012 .

[19]  Anthony G. Fane,et al.  The efficient use of energy in membrane distillation , 1987 .

[20]  Noam Lior,et al.  Membrane-distillation desalination: Status and potential , 2005 .

[21]  G. Stevens,et al.  Fouling of NF membranes by dairy ultrafiltration permeates , 2009 .

[22]  Mohamed Khayet,et al.  Membrane distillation : principles and applications , 2011 .

[23]  M. Gryta.  Effectiveness of Water Desalination by Membrane Distillation Process , 2012, Membranes.

[24]  M. E. Findley.  Vaporization through Porous Membranes , 1967 .

[25]  Jianhua Zhang,et al.  Theoretical and experimental investigation of membrane distillation , 2011 .

[26]  S. T. Hsu,et al.  Seawater desalination by direct contact membrane distillation , 2002 .

[27]  Stephen R Gray,et al.  Fouling mechanisms of dairy streams during membrane distillation , 2013 .

[28]  Pieter Walstra,et al.  Dairy chemistry and physics , 1984 .

[29]  Akili D. Khawaji,et al.  Advances in seawater desalination technologies , 2008 .

[30]  Marek Gryta,et al.  The study of membrane distillation used for separation of fermenting glycerol solutions , 2013 .

[31]  N. Hilal,et al.  Treatment of high salinity solutions: Application of air gap membrane distillation , 2012 .

[32]  G. Stevens,et al.  Analysis of separation and fouling behaviour during nanofiltration of dairy ultrafiltration permeates , 2009 .

[33]  Tai-Shung Chung,et al.  Development of hollow fiber membranes for water and salt recovery from highly concentrated brine via direct contact membrane distillation and crystallization , 2012 .

[34]  Mikel Duke,et al.  Integration of membrane distillation into heat paths of industrial processes , 2012 .

[35]  Anthony G. Fane,et al.  Factors affecting flux in membrane distillation , 1990 .

[36]  Anthony G. Fane,et al.  Direct contact membrane distillation mechanism for high concentration NaCl solutions , 2006 .

[37]  Giulio C. Sarti,et al.  Separation efficiency in vacuum membrane distillation , 1992 .

[38]  L. MartõÂnez-DõÂez,et al.  Study of membrane distillation using channel spacers , 1998 .

[39]  Enrico Drioli,et al.  Direct contact membrane distillation: modelling and concentration experiments , 2000 .

[40]  M. Tomaszewska,et al.  Membrane distillation - examples of applications in technology and environmental protection , 2000 .

[41]  N. Hilal,et al.  Membrane distillation: A comprehensive review , 2012 .

[42]  M. Duke,et al.  Direct Contact Membrane Distillation of Dairy Process Streams , 2011, Membranes.

[43]  R. Brooks,et al.  Closing the Loop: an holistic approach to the management of dairy processor waste streams , 2004 .