A novel CO2 refrigeration system achieved by CO2 solid-gas two-phase fluid and its basic study on system performance

Abstract In this report, a new CO2 refrigeration system is introduced, which can achieve a refrigeration capability below the CO2 triple point of −56.6 °C. The proposed CO2 refrigeration system consists of two thermodynamic cycles arranged in cascade, where one is a CO2 trans-critical cycle and another is a trans-triple-point cycle. An experimental set-up is constructed and tested in order to obtain a basic knowledge about this CO2 system. Based on the measured data, it is concluded that the built CO2 refrigeration system can operate continuously and stably, although dry ice particles exist in the closed CO2 loops. An average COP (a ratio of cooling energy to the compressor power consumption) is measured at 2.45 in the present experiment range for the low-pressure system of the experimental set-up. In addition, the influence of the condensation temperature on the refrigeration cycle is investigated and more studies are needed for the future optimization work.

[1]  G. Lorentzen.  Revival of carbon dioxide as a refrigerant , 1994 .

[2]  Junjie Gu,et al.  The optimum high pressure for CO2 transcritical refrigeration systems with internal heat exchangers , 2005 .

[3]  Jostein Pettersen,et al.  Fundamental process and system design issues in CO2 vapor compression systems , 2004 .

[4]  A. Miyara,et al.  Heat transfer coefficients and pressure drops during in-tube condensation of CO2/DME mixture refrigerant , 2008 .

[5]  J. Thome,et al.  Analysis of supercritical CO2 cooling in macro- and micro-channels , 2008 .

[6]  Petter Nekså,et al.  Commercial refrigeration system using CO2 as the refrigerant , 2004 .

[7]  Armin Hafner,et al.  An automobile HVAC system with CO2 as the refrigerant. Discussion , 1998 .

[8]  Jahar Sarkar,et al.  Simulation of a transcritical CO2 heat pump cycle for simultaneous cooling and heating applicationsElimination des cristaux de givre sur une plaque froide: effets des fréquences stationnaires et de balayage des champs électriques , 2006 .

[9]  Stephen White,et al.  Modelling the performance of a transcritical CO2 heat pump for high temperature heating , 2002 .

[10]  Marco Corradi,et al.  Carbon dioxide as refrigerant for tap water heat pumps: A comparison with the traditional solution , 2005 .

[11]  Xin‐Rong Zhang,et al.  Basic study on new cryogenic refrigeration using CO2 solid–gas two phase flow , 2008 .

[12]  Jahar Sarkar,et al.  Optimization of a transcritical CO2 heat pump cycle for simultaneous cooling and heating applications , 2004 .

[13]  Hiroshi Yamaguchi,et al.  A Feasibility Study of CO2-Based Rankine Cycle Powered by Solar Energy , 2005 .

[14]  Petter Nekså,et al.  Commercial refrigeration using CO2 as refrigerant : System design and experimental results. Discussion , 1998 .

[15]  Petter Nekså,et al.  CO2 heat pump systems , 2002 .

[16]  Honghyun Cho,et al.  Performance evaluation of a two-stage CO2 cycle with gas injection in the cooling mode operation , 2009 .

[17]  Jørn Stene,et al.  Residential CO2 heat pump system for combined space heating and hot water heating , 2005 .

[18]  René Rieberer.  Naturally circulating probes and collectors for ground-coupled heat pumps , 2005 .

[19]  Min-Soo Kim,et al.  Performance evaluation of a stack cooling system using CO2 air conditioner in fuel cell vehicles , 2009 .