Mathematical Modelling of Anaerobic Reactors Treating Domestic Wastewater: Rational Criteria for Model Use

Anaerobic digestion modelling is an established method for assessing anaerobic wastewater treatment for design, systems analysis, operational analysis, and control. Anaerobic treatment of domestic wastewater is a relatively new, but rapidly maturing technology, especially in developing countries, where the combination of low cost, and moderate-good performance are particularly attractive. The key emerging technology is high-rate anaerobic treatment, particularly UASB reactors. Systems modelling can potentially offer a number of advantages to this field, and the key motivations for modelling have been identified as operational analysis, technology development, and model-based design. Design is particularly important, as it determines capital cost, a key motivation for implementers. Published modelling studies for anaerobic domestic sewage treatment are limited in number, but well directed at specific issues. Most have a low structural complexity, with first order kinetics, as compared to the more commonly used Monod kinetics. This review addresses the use of anaerobic models in general, application of models to domestic sewage systems, and evaluates future requirements for models that need to address the key motivations of operational analysis, technology development, and model-based design. For operational analysis and technology development, a complex model such as the ADM1 is recommended, with further extensions as required to address factors such as sulphate reduction. For design, the critical issSues are hydraulics and particles (i.e., biomass and solid substrate) modelling. Therefore, the kinetic structure should be relatively simple (at least two-step), but the hydraulic and particulate model should be relatively complex.

[1]  W. Gujer,et al.  Activated sludge model No. 3 , 1995 .

[2]  Spyros G. Pavlostathis,et al.  Preliminary Conversion Mechanisms in Anaerobic Digestion of Biological Sludges , 1988 .

[3]  V. Vavilin,et al.  A description of hydrolysis kinetics in anaerobic degradation of particulate organic matter , 1996 .

[4]  Thiruvenkatachari Viraraghavan,et al.  Start-up and operation of UASB reactors at 20°C for municipal wastewater treatment , 1998 .

[5]  G. Zeeman,et al.  Anaerobic hydrolysis kinetics of particulate substrates. , 2000, Water science and technology : a journal of the International Association on Water Pollution Research.

[6]  W. Gujer,et al.  Conversion processes in anaerobic digestion , 1983 .

[7]  Indu Mehrotra,et al.  Sludge blanket of UASB reactor: Mathematical simulation , 1997 .

[8]  Peter L. Lee,et al.  Dynamic modelling of a single-stage high-rate anaerobic reactor—I. Model derivation , 1991 .

[9]  J. Ferguson,et al.  Solubilization of particulate organic carbon during the acid phase of anaerobic digestion , 1981 .

[10]  David C. Stuckey,et al.  Soluble Microbial Products in ABR Treating Low-Strength Wastewater , 2000 .

[11]  J N Lester,et al.  Anaerobic treatment of domestic wastewater in temperate climates: treatment plant modelling with economic considerations. , 2001, Water research.

[12]  M. Madigan,et al.  Brock Biology of Microorganisms , 1996 .

[13]  V. Vavilin,et al.  Simulation model ‘methane’ as a tool for effective biogas production during anaerobic conversion of complex organic matter , 1994 .

[14]  M vonSperling.  Comparison among the most frequently used systems for wastewater treatment in developing countries , 1996 .

[15]  Marcos von Sperling,et al.  Comparison among the most frequently used systems for wastewater treatment in developing countries , 1996 .

[16]  Damien J. Batstone,et al.  Anaerobic digestion: impact of future GHG mitigation policies on methane generation and usage: Keynote presentation , 2004 .

[17]  M. Zaiat,et al.  Fed-batch and batch operating mode analysis of a stirred anaerobic sequencing reactor with self-immobilized biomass treating low-strength wastewater. , 2003, Journal of environmental management.

[18]  G Lettinga,et al.  Decentralised treatment of concentrated sewage at low temperature in a two-step anaerobic system: two upflow-hybrid septic tanks. , 2003, Water science and technology : a journal of the International Association on Water Pollution Research.

[19]  I. Angelidaki,et al.  A comprehensive model of anaerobic bioconversion of complex substrates to biogas , 1999, Biotechnology and bioengineering.

[20]  Joan Mata-Álvarez,et al.  A kinetic study of a combined anaerobic–aerobic system for treatment of domestic sewage , 1999 .

[21]  M. Ruzicka,et al.  The effect of hydrogen on acidogenic glucose cleavage , 1996 .

[22]  J. Gossett,et al.  A kinetic model for anaerobic digestion of biological sludge , 1986, Biotechnology and bioengineering.

[23]  J. Keller,et al.  Greenhouse gas production in wastewater treatment: process selection is the major factor. , 2003, Water science and technology : a journal of the International Association on Water Pollution Research.

[24]  Marcelo Zaiat,et al.  Enhancement of the performance of an anaerobic sequencing batch reactor treating low-strength wastewater through implementation of a variable stirring rate program , 2004 .

[25]  R. B. Newell,et al.  Modelling anaerobic degradation of complex wastewater. I: model development , 2000 .

[26]  S. Pavlostathis,et al.  Kinetics of anaerobic treatment: A critical review , 1991 .

[27]  D J Batstone,et al.  Kinetics of thermophilic, anaerobic oxidation of straight and branched chain butyrate and valerate , 2003, Biotechnology and bioengineering.

[28]  W. Gujer,et al.  Mathematical Modelling of Anaerobic Mesophilic Sewage Sludge Treatment , 1993 .

[29]  B. Schink.  Energetics of syntrophic cooperation in methanogenic degradation , 1997, Microbiology and molecular biology reviews : MMBR.

[30]  M. Mösche,et al.  Detection of very low saturation constants in anaerobic digestion: Influences of calcium carbonate precipitation and pH , 1998, Applied Microbiology and Biotechnology.

[31]  J. Gossett,et al.  Anaerobic Digestion of Waste Activated Sludge , 1982 .

[32]  W. Gujer,et al.  Mathematical model for meso- and thermophilic anaerobic sewage sludge digestion. , 2002, Environmental science & technology.

[33]  Waldir Medri,et al.  A Mathematical Model for the Removal of Organic Mater in Stabilization Ponds , 2002 .

[34]  Marcelo Zaiat,et al.  A mathematical model and criteria for designing horizontal-flow anaerobic immobilized biomass reactors for wastewater treatment , 2000 .

[35]  P. Reichert.  AQUASIM-a tool for simulation and data analysis of aquatic systems , 1994 .

[36]  George Tchobanoglous,et al.  Wastewater Engineering Treatment Disposal Reuse , 1972 .

[37]  Lutgarde Raskin,et al.  Quantification of Syntrophic Fatty Acid-β-Oxidizing Bacteria in a Mesophilic Biogas Reactor by Oligonucleotide Probe Hybridization , 1999, Applied and Environmental Microbiology.

[38]  R. C. Weast.  CRC Handbook of Chemistry and Physics , 1973 .

[39]  G. A. Ekama,et al.  Integrated chemical–physical processes modelling—I. Development of a kinetic-based model for mixed weak acid/base systems , 2000 .

[40]  Sergey Kalyuzhnyi,et al.  Batch anaerobic digestion of glucose and its mathematical modeling. I. Kinetic investigations , 1997 .

[41]  D J Batstone,et al.  Hydraulics of laboratory and full-scale upflow anaerobic sludge blanket (UASB) reactors. , 2005, Biotechnology and bioengineering.

[42]  F. Mosey.  Mathematical Modelling of the Anaerobic Digestion Process: Regulatory Mechanisms for the Formation of Short-Chain Volatile Acids from Glucose , 1983 .

[43]  Grietje Zeeman,et al.  A REVIEW: THE ANAEROBIC TREATMENT OF SEWAGE IN UASB AND EGSB REACTORS , 1998 .

[44]  James Gomes,et al.  Axial Dispersion Model for Upflow Anaerobic Sludge Blanket Reactors , 1998, Biotechnology progress.

[45]  Sergey Kalyuzhnyi,et al.  Extension of Enaerobic Digestion Model No. 1 with processes of sulfate reduction , 2003, Applied biochemistry and biotechnology.

[46]  R. B. Newell,et al.  Mathematical modelling of prefermenters—I. Model development and verification , 1999 .

[47]  J. J. Morgan,et al.  Aquatic Chemistry: Chemical Equilibria and Rates in Natural Waters , 1970 .

[48]  James G. Ferry,et al.  Methanogenesis : Ecology, Physiology, Biochemistry and Genetics , 1994 .

[49]  Marc Strous,et al.  Ammonium removal from concentrated waste streams with the anaerobic ammonium oxidation (Anammox) process in different reactor configurations , 1997 .

[50]  J Keller,et al.  The influence of substrate kinetics on the microbial community structure in granular anaerobic biomass. , 2004, Water research.

[51]  D J Batstone,et al.  Improved nitrogen removal in upflow anaerobic sludge blanket (UASB) reactors by incorporation of Anammox bacteria into the granular sludge. , 2004, Water science and technology : a journal of the International Association on Water Pollution Research.

[52]  Hansruedi Siegrist,et al.  Mathematical modeling of autotrophic denitrification in a nitrifying biofilm of a rotating biological contactor , 2000 .

[53]  N. Kossen,et al.  An integral dynamic model for the UASB reactor , 1986, Biotechnology and bioengineering.

[54]  O Bernard,et al.  Advanced monitoring and control of anaerobic wastewater treatment plants: software sensors and controllers for an anaerobic digester. , 2001, Water science and technology : a journal of the International Association on Water Pollution Research.

[55]  P. Pullammanappallil,et al.  Protein degradation during anaerobic wastewater treatment: derivation of stoichiometry , 2004, Biodegradation.

[56]  Hikmet Toprak,et al.  Removal of soluble chemical oxygen demand from domestic wastewaters in a laboratory-scale anaerobic waste stabilization pond , 1995 .

[57]  D J Batstone,et al.  Anaerobic digestion: impact of future greenhouse gases mitigation policies on methane generation and usage. , 2005, Water science and technology : a journal of the International Association on Water Pollution Research.

[58]  J C Huang,et al.  Ethanol-type fermentation from carbohydrate in high rate acidogenic reactor. , 1997, Biotechnology and bioengineering.

[59]  M Perrier,et al.  Liquid-to-Gas Mass Transfer in Anaerobic Processes: Inevitable Transfer Limitations of Methane and Hydrogen in the Biomethanation Process , 1990, Applied and environmental microbiology.

[60]  David C. Stuckey,et al.  The use of the anaerobic baffled reactor (ABR) for wastewater treatment: a review , 1999 .