Single-phase pressure drop and heat transfer characteristics of turbulent liquid nitrogen flow in micro-tubes.

Abstract Experiments have been conducted to investigate the single-phase pressure drop and heat transfer characteristics of liquid nitrogen in four micro-tubes with the diameters of 1.931, 1.042, 0.834 and 0.531 mm. The friction factors are compared with the conventional correlations over a Reynolds number range of 10,000–90,000. The effect of the variable thermal properties of liquid nitrogen, i.e., viscosity and thermal conductivity, on the flow and local heat transfer in the micro-tubes is clarified. The average Nusselt numbers are determined and compared with the correlations for the conventional channels and micro-channels, respectively. It is found that large roughness of the micro-tube causes high friction factor, and the modified Colebrook correlation can well predict the experimental friction factors by using the measured surface roughness. With the increase of liquid nitrogen temperature, the pressure drop decreases as a result of the lower viscosity. Opposite to water, the local heat transfer coefficient of liquid nitrogen flow in the micro-tube drops by 12.5% along the tube. The experimental data show that the average Nusselt numbers for the micro-tubes are higher than those predicted by the correlations for the conventional channels. Taking into account the effect of surface roughness of the micro-tubes on the heat transfer, the modified Gnielinski correlation enables to predict the experimental Nusselt numbers with a mean absolute error (MAE) of 6.4%.

[1]  B. Donnelly,et al.  The evolution and state of modern technology for prostate cryosurgery. , 2002, Urology.

[2]  The application of cryosurgery in the treatment of lung cancer. , 2004, Cryobiology.

[3]  A. Bontemps,et al.  Liquid flow friction factor and heat transfer coefficient in small channels: an experimental investigation , 2004 .

[4]  G. Peterson,et al.  The effect of thermofluid and geometrical parameters on convection of liquids through rectangular microchannels , 1995 .

[5]  W. Little,et al.  Measurement of friction factors for the flow of gases in very fine channels used for microminiature Joule-Thomson refrigerators , 1983 .

[6]  Zeng-chen Ma,et al.  Clinical evaluation of cryosurgery in the treatment of primary liver cancer Report of 60 Cases , 1988, Cancer.

[7]  S. Hsieh,et al.  Liquid flow in a micro-channel , 2006 .

[8]  Zeng-Yuan Guo,et al.  Size effect on microscale single-phase flow and heat transfer , 2002 .

[9]  Roland Span,et al.  A Reference Equation of State for the Thermodynamic Properties of Nitrogen for Temperatures from 63.151 to 1000 K and Pressures to 2200 MPa , 2000 .

[10]  G. Morini.  Single-phase Convective Heat Transfer in Microchannels: a Review of Experimental Results , 2004 .

[11]  S. Kandlikar,et al.  Characterization of the effect of surface roughness and texture on fluid flow—past, present, and future , 2006 .

[12]  C F Colebrook,et al.  TURBULENT FLOW IN PIPES, WITH PARTICULAR REFERENCE TO THE TRANSITION REGION BETWEEN THE SMOOTH AND ROUGH PIPE LAWS. , 1939 .

[13]  V. Gnielinski.  New equations for heat and mass transfer in turbulent pipe and channel flow , 1976 .

[14]  V. N. Pavlov.  Development of perspective cryogenic surgical apparatus , 2000 .

[15]  Huiying Wu,et al.  An experimental study of convective heat transfer in silicon microchannels with different surface conditions , 2003 .

[16]  X. Peng,et al.  Experimental investigation on liquid forced-convection heat transfer through microchannels☆ , 1994 .

[17]  H. Herwig,et al.  Variable property effects in single-phase incompressible flows through microchannels , 2006 .

[18]  Björn Palm,et al.  Experimental investigation of single-phase convective heat transfer in circular microchannels , 2004 .

[19]  S. Lin,et al.  Local frictional pressure drop during vaporization of R-12 through capillary tubes , 1991 .

[20]  A A Gage,et al.  Minimally invasive cryosurgery--technological advances. , 1997, Cryobiology.

[21]  Said I. Abdel-Khalik,et al.  An experimental investigation of single-phase forced convection in microchannels , 1998 .

[22]  Masanori Kunieda,et al.  Development of parallel spark electrical discharge machining , 2004 .

[23]  Chien-Yuh Yang,et al.  FRICTION CHARACTERISTICS OF WATER, R-134a, AND AIR IN SMALL TUBES , 2003, Proceeding of Heat Transfer and Transport Phenomena in Microscale.

[24]  V. Dhir,et al.  Heat transfer and pressure drop in narrow rectangular channels , 2002 .

[25]  W. Little,et al.  Measurement of the heat transfer characteristics of gas flow in fine channel heat exchangers used for microminiature refrigerators , 1984 .