Thermal Nitridation of Si and SiO/sub 2/ for VLSI

This paper presents an extensive review of our work on thermal nitridation of Si and SiO/sub 2/. High-quality ultrathin films of silicon nitride and nitrided-oxide (nitroxide) have been thermally grown in ammonia atmosphere in a cold-wall RF-heated reactor and in a lamp-heated system. The growth kinetics and their dependence on processing time and temperature have been studied from very short to long nitridation times. The kinetics of thermal nitridation of SiO/sub 2/ in ammonia ambient have also been studied. In nitroxide, nitrogen-rich layers are formed at the surface and interface at a very early stage of the nitridation. Then the nitridation reaction mainly goes on in the bulk region with the surface and near interface nitrogen content remaining fairly constant. Our results also indicate the formation of an oxygen-rich layer at the interface underneath the nitrogen-rich layer whose thickness increases slowly with nitridation time. The nitride and nitroxide films were analyzed using Auger electron spectroscopy, grazing angle Rutherford backscattering, and etch rate measurements. MIS devices were fabricated using these films as gate insulators and were electrically characterized using I-V, C-V, time-dependent breakdown, trapping, and dielectric breakdown techniques. Breakdown, conduction, and C -V measurements on metal-insulator semiconductor (MIS) structures fabricated with these films show that very thin thermal silicon nitride and nitroxide films can be used as gate dielectrics for future highly scaled-dowm VLSI devices. The electrical characterization results also indicate extremely low trapping in the nitride films. The reliability of ultrathin nitride was observed to be far superior to SiO/sub 2/ and nitroxide due to its much less trapping. Studies show that the interface transition from nitride to silicon is almost abrupt and the morphology and roughness of the interface are comparable to the SiO/sub 2/-Si interfaces.

[1]  Y. Hayafuji,et al.  Shrinkage and growth of oxidation stacking faults during thermal nitridation of silicon and oxidized silicon , 1982 .

[2]  J. Amano,et al.  Characterization of thermally nitrided silicon dioxide , 1982 .

[3]  L. Yau.  Arguments for electron conduction in silicon nitride , 1984, IEEE Electron Device Letters.

[4]  S.S. Wong,et al.  Nitrided-oxides for thin gate dielectrics in MOS devices , 1982, 1982 International Electron Devices Meeting.

[5]  Takashi Ito,et al.  Retardation of Destructive Breakdown of SiO2 Films Annealed in Ammonia Gas , 1980 .

[6]  V.K. Dham,et al.  Design considerations for scaling FLOTOX E2PROM cell , 1983, 1983 International Electron Devices Meeting.

[7]  A. C. Adams,et al.  Thermal Nitridation of Silicon in Ammonia Gas: Composition and Oxidation Resistance of the Resulting Films , 1979 .

[8]  W. Oldham,et al.  A multiwafer plasma system for anodic nitridation and oxidation , 1984, IEEE Electron Device Letters.

[9]  S. Chang,et al.  IIIB-6 analysis of current transport and charge trapping in ultrathin nitrided oxide MIS capacitors , 1984, IEEE Transactions on Electron Devices.

[10]  Takashi Ito,et al.  Thermally grown silicon nitride films for high-performance MNS devices , 1978 .

[11]  F. Herman.  Electronic Structure of the Si-SiO2 Interface , 1981 .

[12]  Ching-Yuan Wu,et al.  Growth Kinetics of Silicon Thermal Nitridation , 1982 .

[14]  Takashi Ito,et al.  Direct Thermal Nitridation of Silicon Dioxide Films in Anhydrous Ammonia Gas , 1980 .

[15]  A. Renninger,et al.  A 5V-only 16K EEPROM utilizing oxynitride dielectrics and EPROM redundancy , 1982, 1982 IEEE International Solid-State Circuits Conference. Digest of Technical Papers.

[16]  Charles G. Sodini,et al.  Low Pressure Nitrided‐Oxide as a Thin Gate Dielectric for MOSFET's , 1983 .

[17]  A. S. Grove,et al.  General Relationship for the Thermal Oxidation of Silicon , 1965 .

[18]  N. Tsubouchi,et al.  Plasma Anodic Nitridation of Silicon in N 2 ‐ H 2 System , 1984 .

[19]  G. M. Samuelson,et al.  The Correlations Between Physical and Electrical Properties of PECVD SiN with Their Composition Ratios , 1982 .

[20]  F. Habraken,et al.  Thermal nitridation of silicon dioxide films , 1982 .

[21]  A. Hartstein,et al.  Effects of Ammonia Anneal on Electron Trappings in Silicon Dioxide , 1982 .

[22]  S. Senturia,et al.  IIIB-5 high-field electron capture and emission in nitrided oxides , 1984, IEEE Transactions on Electron Devices.

[23]  Yutaka Hayashi,et al.  Carrier conduction and trapping in metal‐nitride‐oxide‐semiconductor structures , 1982 .

[24]  T. Nakamura,et al.  Advantages of thermal nitride and nitroxide gate films in VLSI process , 1982, IEEE Transactions on Electron Devices.

[25]  T. Nozaki,et al.  Thermal nitride gate FET technology for VLSI devices , 1980, 1980 IEEE International Solid-State Circuits Conference. Digest of Technical Papers.

[26]  T. Tan.  Intrinsic Point Defects and Diffusion Processes in Silicon , 1983 .

[27]  Mehrdad M. Moslehi,et al.  Electrical Characteristics of Devices Fabricated with Ultra-Thin Thermally Grown Silicon Nitride and Nitroxide Gate Insulators , 1983, 1983 Symposium on VLSI Technology. Digest of Technical Papers.

[28]  J. Hu,et al.  Properties of thin oxynitride films used as floating-gate tunneling dielectrics , 1982, 1982 International Electron Devices Meeting.

[29]  Y. Fukukawa,et al.  Thermal Nitridation of Silicon in Advanced LSI Processing , 1980 .

[30]  F. Habraken,et al.  Characterization of low‐pressure chemical‐vapor‐deposited and thermally‐grown silicon nitride films , 1982 .

[31]  J. M. Andrews,et al.  High‐field dark currents in thin CVD silicon nitride , 1980 .

[32]  Stephen Aplin Lyon,et al.  Capture and tunnel emission of electrons by deep levels in ultrathin nitrided oxides on silicon , 1984 .

[33]  S. Senturia,et al.  Radiation effects in nitrided oxides , 1983, IEEE Electron Device Letters.

[34]  T.T.L. Chang,et al.  Oxidized-nitridized oxide (ONO) for high performance EEPROMs , 1982, 1982 International Electron Devices Meeting.

[35]  M. Shinoda,et al.  Low-voltage alterable EAROM cells with nitride-barrier avalanche-injection MIS (NAMIS) , 1979, IEEE Transactions on Electron Devices.

[36]  H. Higuchi,et al.  Effect of Si and SiO2 thermal nitridation on impurity diffusion and oxidation induced stacking fault size in Si , 1983 .

[37]  A. Reisman,et al.  Nitridation of silicon in a multiwafer plasma system , 1984 .

[38]  S.K. Lai,et al.  Electrical properties of nitrided-oxide systems for use in gate dielectrics and EEPROM , 1983, 1983 International Electron Devices Meeting.

[39]  R. Dutton,et al.  Kinetics of thermal nitridation processes in the study of dopant diffusion mechanisms in silicon , 1985 .

[40]  Studies of trapping and conduction in ultrathin SiO 2 gate insulators , 1984 .

[41]  Y. Hayafuji,et al.  Nitridation of Silicon and Oxidized‐Silicon , 1982 .

[42]  T. Sugii,et al.  Excimer laser enhanced nitridation of silicon substrates , 1984 .

[43]  Akira Shintani,et al.  The Influence of Thermal Silicon Nitride Formation on VLSI Fabrication , 1983, 1983 Symposium on VLSI Technology. Digest of Technical Papers.

[44]  S. Hijiya,et al.  Very Thin Silicon Nitride Films Grown by Direct Thermal Reaction with Nitrogen , 1978 .

[45]  R. Dutton,et al.  Effect of thermal nitridation processes on boron and phosphorus diffusion in 〈100〉 silicon , 1983 .