Adsorption of water and butanol in silicalite-1 film studied with in situ attenuated total reflectance-Fourier transform infrared spectroscopy.

Biobutanol produced by, e.g., acetone-butanol-ethanol (ABE) fermentation is a promising alternative to petroleum-based chemicals as, e.g., solvent and fuel. Recovery of butanol from dilute fermentation broths by hydrophobic membranes and adsorbents has been identified as a promising route. In this work, the adsorption of water and butanol vapor in a silicalite-1 film was studied using in situ attenuated total reflectance-Fourier transform infrared (ATR-FTIR) spectroscopy to better understand the adsorption properties of silicalite-1 membranes and adsorbents. Single-component adsorption isotherms were determined in the temperature range of 35-120 °C, and the Langmuir model was successfully fitted to the experimental data. The adsorption of butanol is very favorable compared to that of water. When the silicalite-1 film was exposed to a butanol/water vapor mixture with 15 mol % butanol (which is the vapor composition of an aqueous solution containing 2 wt % butanol, a typical concentration in an ABE fermentation broth, i.e., the composition of the gas obtained from gas stripping of an ABE broth) at 35 °C, the adsorption selectivity toward butanol was as high as 107. These results confirm that silicalite-1 quite selectively adsorbs hydrocarbons from vapor mixtures. To the best of our knowledge, this is the first comprehensive study on the adsorption of water and butanol in silicalite-1 from vapor phase.

[1]  S. Mukai,et al.  Preparation of hydrophilic and acid-proof silicalite-1 zeolite membrane and its application to selective separation of water from water solutions of concentrated acetic acid by pervaporation , 2003 .

[2]  Harland G. Tompkins,et al.  The Physical Basis for Analysis of the Depth of Absorbing Species Using Internal Reflection Spectroscopy , 1974 .

[3]  Philippe Bazin,et al.  Interaction of water and ammonium in NaHY zeolite as detected by combined IR and gravimetric analysis (AGIR). , 2010, Dalton transactions.

[4]  Ryan P. Lively,et al.  Adsorption of water and ethanol in MFI-type zeolites. , 2012, Langmuir : the ACS journal of surfaces and colloids.

[5]  Ryan P. Lively,et al.  Alcohol and water adsorption in zeolitic imidazolate frameworks. , 2013, Chemical communications.

[6]  Hang Zhou,et al.  High flux MFI membranes for pervaporation , 2013 .

[7]  Hang Zhou,et al.  The facile assembly of nanocrystals by optimizing humidity. , 2014, Chemical communications.

[8]  Xianming Li,et al.  Synthesis of highly b-oriented zeolite MFI films by suppressing twin crystal growth during the secondary growth , 2011 .

[9]  Fangfang Liu,et al.  Separation of acetone–butanol–ethanol (ABE) from dilute aqueous solutions by pervaporation , 2005 .

[10]  O. Talu,et al.  Adsorption Equilibria of C1 to C4 Alkanes, CO2, and SF6 on Silicalite , 1998 .

[11]  N. Qureshi,et al.  Energy-efficient recovery of butanol from model solutions and fermentation broth by adsorption , 2005, Bioprocess and biosystems engineering.

[12]  Adrie J. J. Straathof,et al.  Assessment of Options for Selective 1-Butanol Recovery from Aqueous Solution , 2009 .

[13]  J. Hedlund,et al.  Adsorption of CO2, CH4, and H2O in Zeolite ZSM-5 Studied Using In Situ ATR-FTIR Spectroscopy , 2013 .

[14]  Baoquan Zhang,et al.  Assembly of oriented zeolite monolayers and thin films on polymeric surfaces via hydrogen bonding. , 2008, Langmuir : the ACS journal of surfaces and colloids.

[15]  U. Rova,et al.  MFI zeolite as adsorbent for selective recovery of hydrocarbons from ABE fermentation broths , 2014, Adsorption.

[16]  D. Olson,et al.  Use of water as a probe of zeolitic properties: interaction of water with HZSM-5 , 2000 .

[17]  J. Hanson,et al.  Strain of MFI crystals in membranes: An in situ synchrotron X-ray study , 2005 .

[18]  V. Saravanan,et al.  Recovery of 1-butanol from aqueous solutions using zeolite ZSM-5 with a high Si/Al ratio; suitability of a column process for industrial applications , 2010 .

[19]  Riitta L. Keiski,et al.  Challenges in biobutanol production: How to improve the efficiency? , 2011 .

[20]  D. Korelskiy,et al.  A uniformly oriented MFI membrane for improved CO₂ separation. , 2014, Angewandte Chemie.

[21]  Y. Wan,et al.  Separation of acetone, butanol and ethanol (ABE) from dilute aqueous solutions by silicalite-1/PDMS hybrid pervaporation membranes , 2011 .

[22]  Hang Zhou,et al.  Ultrathin hydrophobic MFI membranes , 2014 .

[23]  F. Mirabella,et al.  Internal Reflection Spectroscopy: Theory and Applications , 1992 .

[24]  M. Grahn,et al.  Detailed Investigation of the Binary Adsorption of Carbon Dioxide and Methane in Zeolite Na-ZSM-5 Studied Using in Situ ATR-FTIR Spectroscopy , 2014 .

[25]  S. Nair,et al.  Infrared reflectance measurements of zeolite film thickness, refractive index and other characteristics , 2003 .

[26]  Jungkyu Choi,et al.  Rapid thermal processing and separation performance of columnar MFI membranes on porous stainless steel tubes , 2011 .

[27]  D. Creaser,et al.  Preparation and evaluation of thin ZSM-5 membranes synthesized in the absence of organic template molecules , 2001 .

[28]  J. Falconer,et al.  High-resolution physical adsorption on supported borosilicate MFI zeolite membranes: comparison with powdered samples , 2008 .

[29]  Joshua S Yuan,et al.  Plants to power: bioenergy to fuel the future. , 2008, Trends in plant science.

[30]  Johannes A. Lercher,et al.  Adsorption of water on ZSM 5 zeolites , 1989 .

[31]  D. Nielsen,et al.  In situ product recovery of n‐butanol using polymeric resins , 2009, Biotechnology and bioengineering.

[32]  J. Moulijn,et al.  TEOM: A Unique Technique for Measuring Adsorption Properties. Light Alkanes in Silicalite-1 , 1998 .

[33]  Bo Mattiasson,et al.  Adsorbents for extractive bioconversion applied to the acetone-butanol fermentation , 1988, Applied Microbiology and Biotechnology.

[34]  R. A. Conway,et al.  Activated carbon adsorption of petrochemicals , 2016 .

[35]  R. T. Yang,et al.  A novel FTIR method for studying mixed gas adsorption at low concentrations: H2O and CO2 on NaX zeolite and γ-alumina , 2001 .

[36]  B. Smit,et al.  Molecular Simulations of Adsorption Isotherms for Linear and Branched Alkanes and Their Mixtures in Silicalite , 1999 .

[37]  R. Szostak,et al.  Incorporation and stability of iron in molecular-sieve structures. Ferrisilicate analogues of zeolite ZSM-5 , 1987 .

[38]  J. Lercher,et al.  Surface processes during sorption of aromatic molecules on medium pore zeolites. , 2005, The journal of physical chemistry. B.

[39]  J. Weitkamp,et al.  Hydrophobic properties of all-silica zeolite beta , 1998 .

[40]  Liling Zhang,et al.  Adsorption of C1–C4 Alcohols in Zeolitic Imidazolate Framework-8: Effects of Force Fields, Atomic Charges, and Framework Flexibility , 2013 .

[41]  J. Fulton,et al.  Fourier transform infrared spectroscopy of molecular interactions of heptafluoro-1-butanol or 1-butanol in supercritical carbon dioxide and supercritical ethane , 1992 .

[42]  D. Lin-Vien.  The Handbook of Infrared and Raman Characteristic Frequencies of Organic Molecules , 1991 .

[43]  J. Falconer,et al.  Fundamentals and applications of pervaporation through zeolite membranes , 2004 .

[44]  R. Krishna,et al.  Highlighting pitfalls in the Maxwell-Stefan modeling of water-alcohol mixture permeation across pervaporation membranes , 2010 .

[45]  A. Straathof,et al.  Adsorption equilibria of bio-based butanol solutions using zeolite , 2009 .

[46]  J. Hedlund,et al.  Adsorption of n-hexane and p-xylene in thin silicalite-1 films studied by FTIR/ATR spectroscopy , 2008 .

[47]  F. Kapteijn,et al.  Adsorption of light alkanes on silicalite-1: Reconciliation of experimental data and molecular simulations , 2000 .

[48]  N. Qureshi,et al.  Recovery of butanol from model solutions and fermentation broth using a silicalite/silicone membrane , 1999 .

[49]  T. Ezeji,et al.  Acetone butanol ethanol (ABE) production from concentrated substrate: reduction in substrate inhibition by fed-batch technique and product inhibition by gas stripping , 2004, Applied Microbiology and Biotechnology.

[50]  Michael M. Meagher,et al.  Acetone butanol ethanol (ABE) recovery by pervaporation using silicalite–silicone composite membrane from fed-batch reactor of Clostridium acetobutylicum , 2001 .

[51]  W. Einicke,et al.  Liquid-phase adsorption of n-alcohol/water mixtuers on zeolite NaZSM-5 , 1988 .

[52]  C. Nolasco-Hipólito,et al.  Biodiesel production from crude palm oil and evaluation of butanol extraction and fuel properties , 2001 .

[53]  J. Hedlund,et al.  Silicalite-1 coated ATR elements as sensitive chemical sensor probes , 2005 .

[54]  J Huang,et al.  Pervaporative recovery of n-butanol from aqueous solutions and ABE fermentation broth using thin-film silicalite-filled silicone composite membranes , 2001 .

[55]  J. Hedlund,et al.  Zeolite coated ATR crystals for new applications in FTIR-ATR spectroscopy. , 2004, Chemical communications.

[56]  P. Ugliengo,et al.  Thermodynamic study of water adsorption in high-silica zeolites. , 2006, The journal of physical chemistry. B.

[57]  Jinglan Wu,et al.  Adsorption of butanol from aqueous solution onto a new type of macroporous adsorption resin: Studies of adsorption isotherms and kinetics simulation , 2012 .