Performance Analysis of a RED-MED Salinity Gradient Heat Engine

A performance analysis of a salinity gradient heat engine (SGP-HE) is presented for the conversion of low temperature heat into power via a closed-loop Reverse Electrodialysis (RED) coupled with Multi-Effect Distillation (MED). Mathematical models for the RED and MED systems have been purposely developed in order to investigate the performance of both processes and have been then coupled to analyze the efficiency of the overall integrated system. The influence of the main operating conditions (i.e., solutions concentration and velocity) has been quantified, looking at the power density and conversion efficiency of the RED unit, MED Specific Thermal Consumption (STC) and at the overall system exergy efficiency. Results show how the membrane properties (i.e., electrical resistance, permselectivity, water and salt permeability) dramatically affect the performance of the RED process. In particular, the power density achievable using membranes with optimized features (ideal membranes) can be more than three times higher than that obtained with current reference ion exchange membranes. On the other hand, MED STC is strongly influenced by the available waste heat temperature, feed salinity and recovery ratio to be achieved. Lowest values of STC below 25 kWh/m3 can be reached at 100 ◦C and 27 effects. Increasing the feed salinity also increases the STC, while an increase in the recovery ratio is beneficial for the thermal efficiency of the system. For the integrated system, a more complex influence of operating parameters has been found, leading to the identification of some favorable operating conditions in which exergy efficiency close to 7% (1.4% thermal) can be achieved for the case of current membranes, and up to almost 31% (6.6% thermal) assuming ideal membrane properties.

[1]  Ali Altaee,et al.  Single and dual stage closed-loop pressure retarded osmosis for power generation: Feasibility and performance , 2017 .

[2]  François Maréchal,et al.  Optimal heat pump integration in industrial processes , 2018, Applied Energy.

[3]  Guillermo Zaragoza,et al.  Steady state model for multi-effect distillation case study: Plataforma Solar de Almería MED pilot plant , 2014 .

[4]  Ibrahim S. Al-Mutaz,et al.  Development of a steady-state mathematical model for MEE-TVC desalination plants , 2014 .

[5]  A. R. Tavakolpour-Saleh,et al.  A novel active free piston Stirling engine: Modeling, development, and experiment , 2017 .

[6]  Veva Elwell,et al.  Toxicity and Anti-Inflammatory Activity of Phenolic-Rich Extract from Nopalea cochenillifera (Cactaceae): A Preclinical Study on the Prevention of Inflammatory Bowel Diseases , 2023, Plants.

[7]  Onder Kaska,et al.  Energy and exergy analysis of an organic Rankine for power generation from waste heat recovery in steel industry , 2014 .

[8]  Geert Versteeg,et al.  Application of the Pitzer model for the estimation of activity coefficients of electrolytes in ion selective membranes , 1999 .

[9]  F. N. Alasfour,et al.  Thermal analysis of ME—TVC+MEE desalination systems , 2005 .

[10]  Ngai Yin Yip,et al.  Comparison of energy efficiency and power density in pressure retarded osmosis and reverse electrodialysis. , 2014, Environmental science & technology.

[11]  Guillermo Zaragoza,et al.  Characterisation of the coupling of multi-effect distillation plants to concentrating solar power plants , 2015 .

[12]  Andrea Cipollina,et al.  Effect of different aqueous solutions of pure salts and salt mixtures in reverse electrodialysis systems for closed-loop applications , 2018 .

[13]  François Maréchal,et al.  Defining “Waste Heat” for industrial processes , 2013 .

[14]  Hassan A. Arafat,et al.  Reverse electrodialysis powered greenhouse concept for water- and energy-self-sufficient agriculture , 2017 .

[15]  J. Veerman,et al.  Reducing power losses caused by ionic shortcut currents in reverse electrodialysis stacks by a validated model , 2008 .

[16]  Douglas F. Call,et al.  Impact of natural organic matter and inorganic solutes on energy recovery from five real salinity gradients using reverse electrodialysis , 2017 .

[17]  Enrico Drioli,et al.  Membrane technology in renewable-energy-driven desalination , 2018 .

[18]  M. Elimelech,et al.  Membrane-based processes for sustainable power generation using water , 2012, Nature.

[19]  Bartolomé Ortega-Delgado,et al.  Opportunities of improvement of the MED seawater desalination process by pretreatments allowing high-temperature operation , 2017 .

[20]  N. Hilal,et al.  Membrane distillation: A comprehensive review , 2012 .

[21]  Juha Honkatukia,et al.  Evaluation of a small-scale waste heat recovery organic Rankine cycle , 2017 .

[22]  Dorothea C. Nijmeijer,et al.  Theoretical power density from salinity gradients using reverse electrodialysis , 2012 .

[23]  J. Veerman,et al.  Reverse electrodialysis: A validated process model for design and optimization , 2011 .

[24]  Bopeng Zhang,et al.  Potential ion exchange membranes and system performance in reverse electrodialysis for power generation: A review , 2015 .

[25]  Fatma H. Ashour,et al.  Power generation using waste heat recovery by organic Rankine cycle in oil and gas sector in Egypt: A case study , 2014 .

[26]  V. Nikonenko,et al.  Ion-exchange membrane materials: Properties, modification, and practical application , 2009 .

[27]  Kenneth S. Pitzer,et al.  Electrolyte theory: improvements since Debye and Hueckel , 1977 .

[28]  Alessandro Galia,et al.  Investigation of electrode material – Redox couple systems for reverse electrodialysis processes. Part I: Iron redox couples , 2012 .

[29]  Amy E. Childress,et al.  Power generation with pressure retarded osmosis: An experimental and theoretical investigation , 2009 .

[30]  Antonio Piacentino,et al.  Reverse electrodialysis heat engine for sustainable power production , 2017 .

[31]  Douglas F. Call,et al.  Impact of solution composition on the resistance of ion exchange membranes , 2018 .

[32]  Francesco Giacalone,et al.  Exergy analysis of reverse electrodialysis , 2018 .

[33]  Yiping Dai,et al.  Thermodynamic analysis and optimization of an (organic Rankine cycle) ORC using low grade heat source , 2013 .

[34]  K. Goni Boulama,et al.  Power generation from residual industrial heat , 2010 .

[35]  Hubertus V. M. Hamelers,et al.  Towards implementation of reverse electrodialysis for power generation from salinity gradients , 2010 .

[36]  François Maréchal,et al.  Generic superstructure synthesis of organic Rankine cycles for waste heat recovery in industrial processes , 2018 .

[37]  Andrea Cipollina,et al.  Development of a Membrane Distillation module for solar energy seawater desalination , 2012 .

[38]  Antonio Piacentino,et al.  Salinity gradient engines , 2016 .

[39]  Jin Gi Hong,et al.  Modeling of power generation from the mixing of simulated saline and freshwater with a reverse electrodialysis system: The effect of monovalent and multivalent ions , 2013 .

[40]  Andrea Cipollina,et al.  Modelling the Reverse ElectroDialysis process with seawater and concentrated brines , 2012 .

[41]  William T. Choate,et al.  Waste Heat Recovery. Technology and Opportunities in U.S. Industry , 2008 .

[42]  Xiao Feng,et al.  Thermodynamic performance comparison between ORC and Kalina cycles for multi-stream waste heat recovery , 2017 .

[43]  Matthias Wessling,et al.  Practical potential of reverse electrodialysis as process for sustainable energy generation. , 2009, Environmental science & technology.

[44]  Giorgio Micale,et al.  A simulation tool for analysis and design of reverse electrodialysis using concentrated brines , 2015 .

[45]  Bartolomé Ortega-Delgado,et al.  Parametric study of a multi-effect distillation plant with thermal vapor compression for its integration into a Rankine cycle power block , 2016 .

[46]  Andrea Cipollina,et al.  تحلية مياه البحر؛ سيرورات الطاقة التقليدية والمتجددة (Seawater Desalination. Conventional and Renewable Energy Processes) , 2009 .

[47]  Wei He,et al.  High net power output analysis with changes in exhaust temperature in a thermoelectric generator system , 2017 .

[48]  Robert L McGinnis,et al.  A novel ammonia–carbon dioxide osmotic heat engine for power generation , 2007 .

[49]  Kenneth S. Pitzer,et al.  Thermodynamics of electrolytes. I. Theoretical basis and general equations , 1973 .

[50]  Ngai Yin Yip,et al.  Salinity Gradients for Sustainable Energy: Primer, Progress, and Prospects. , 2016, Environmental science & technology.

[51]  S. Brandani,et al.  Novel solutions for closed-loop reverse electrodialysis: Thermodynamic characterisation and perspective analysis , 2019, Energy.

[52]  H. Ettouney,et al.  Fundamentals of Salt Water Desalination , 2002 .

[53]  Susan Krumdieck,et al.  Feasibility assessment of refinery waste heat-to-power conversion using an organic Rankine cycle , 2014 .

[54]  Emmanuel Kakaras,et al.  Energetic and exergetic analysis of waste heat recovery systems in the cement industry , 2013 .

[55]  Wei Liu,et al.  Hybrid membrane distillation-reverse electrodialysis electricity generation system to harvest low-grade thermal energy , 2017 .

[56]  Antonio Piacentino,et al.  Reverse electrodialysis with NH4HCO3-water systems for heat-to-power conversion , 2017 .

[57]  Ping Wang,et al.  Theoretical simulation and evaluation for the performance of the hybrid multi-effect distillation—reverse electrodialysis power generation system , 2018, Desalination.

[58]  J. Post,et al.  Salinity-gradient power : Evaluation of pressure-retarded osmosis and reverse electrodialysis , 2007 .

[59]  Grinnell Jones,et al.  The Conductance of Aqueous Solutions as a Function of the Concentration. I. Potassium Bromide and Lanthanum Chloride , 1934 .