MEMS needle-type sensor array for in situ measurements of dissolved oxygen and redox potential.

Microelectrodes are among the most accurate and reliable monitoring devices for measuring the dynamics of biofilm processes. This paper describes a novel needle-type microelectrode array (MEA) for simultaneous in situ measurements of dissolved oxygen (DO) and oxidation reduction potential (ORP) fabricated using microelectromechanical systems (MEMS) technologies. The MEA exhibits fast response times for both DO and ORP measurements and shows a substantial increase in DO sensitivity. To demonstrate the versatility of the new sensor, it was applied to the measurement of DO and ORP microprofiles in a multispecies biofilm. This work demonstrates that the MEA is able to monitor local concentration changes with a high spatial resolution and provide the versatility of the microelectrode technique needed for biofilm studies as well as the capability for repetitive measurements. In addition, the use of MEMS technologies and batch fabrication approaches enables integration, high consistency, high yields, and mass production. With further development, it may be possible to add additional sensors to the MEA (e.g., pH, phosphate) and integrate them with a reference electrode.

[1]  Tian C. Zhang,et al.  Effects of biofilm structure, microbial distributions and mass transport on biodegradation processes , 1995 .

[2]  R. E. Sharp,et al.  A microsensor for direct measurement of O2 partial pressure within plant tissues3 , 1996 .

[3]  Tong Yu,et al.  A microelectrode study of redox potential change in biofilms , 1999 .

[4]  R. Linsenmeier,et al.  Improved fabrication of double-barreled recessed cathode O2 microelectrodes. , 1987, Journal of applied physiology.

[5]  David M. Ward,et al.  Oxygen Microelectrode That Is Insensitive to Medium Chemical Composition: Use in an Acid Microbial Mat Dominated by Cyanidium caldarium , 1983, Applied and environmental microbiology.

[6]  Rosa Villa,et al.  New technology for multi-sensor silicon needles for biomedical applications , 2001 .

[7]  G. Kovacs.  Micromachined Transducers Sourcebook , 1998 .

[8]  R. Linsenmeier,et al.  Fabrication of a mediated glucose oxidase recessed microelectrode for the amperometric determination , 1996 .

[9]  Tian C. Zhang,et al.  An innovative electro-corrosion recess creation technique for improved microelectrode fabrication. , 2002, Water research.

[10]  R. Normann,et al.  Chronic recording capability of the Utah Intracortical Electrode Array in cat sensory cortex , 1998, Journal of Neuroscience Methods.

[11]  Tian C. Zhang,et al.  Transport and biodegradation of toxic organics in biofilms , 1995 .

[12]  A. Jang,et al.  Measurement of chlorine dioxide penetration in dairy process pipe biofilms during disinfection , 2006, Applied Microbiology and Biotechnology.

[13]  Ian Papautsky,et al.  Miniaturized redox potential probe for in situ environmental monitoring. , 2005, Environmental science & technology.

[14]  A. Bezbaruah,et al.  pH, redox, and oxygen microprofiles in rhizosphere of bulrush (Scirpus validus) in a constructed wetland treating municipal wastewater , 2004, Biotechnology and bioengineering.

[15]  Tian C. Zhang,et al.  Fabrication of Redox Potential Microelectrodes for Studies in Vegetated Soils or Biofilm Systems , 1998 .

[16]  R. W. Schubert,et al.  Modeling a micromanufactured open recess-tip oxygen microelectrode , 1997, Proceedings of the 1997 16 Southern Biomedical Engineering Conference.

[17]  F. Beyette,et al.  Fabrication of microelectrode arrays for in situ sensing of oxidation reduction potentials , 2006 .

[18]  K. Wise,et al.  A high-yield IC-compatible multichannel recording array , 1985, IEEE Transactions on Electron Devices.

[19]  Tian C Zhang,et al.  Fabrication of anodically electrodeposited iridium oxide film pH microelectrodes for microenvironmental studies. , 2002, Analytical chemistry.

[20]  K. Horch,et al.  A silicon-based, three-dimensional neural interface: manufacturing processes for an intracortical electrode array , 1991, IEEE Transactions on Biomedical Engineering.

[21]  Ian Papautsky,et al.  Micromachined arrays of cantilevered glass probes. , 2004, Applied optics.

[22]  P. Bishop,et al.  Stratification and Oxidation–Reduction Potential Change in an Aerobic and Sulfate‐Reducing Biofilm Studied Using Microelectrodes , 2001, Water environment research : a research publication of the Water Environment Federation.