Effects of DC Bias Tuning on Air-Coupled PZT Piezoelectric Micromachined Ultrasonic Transducers

In this paper, we report an air-coupled piezoelectric ultrasonic micromachined transducer (PMUT) using a lead-zirconate-titanate (PZT) piezoelectric layer. A dc bias voltage applied to the PZT film controls its polarization and intrinsic stress, tuning the frequencies of two closely-spaced resonance modes of the rectangular shaped PMUT. At an optimal bias voltage of approximately 5 V, the modes nearly overlap at 230 kHz, increasing the bandwidth by a factor of 8 relative to the zero dc biased state. Measurements of the electromechanical coupling coefficient of the PZT film show that it is maximized at 5-6 V, agreeing with device performance experiments. Acoustic transmission and reception were demonstrated using two identical PMUTs by adding the optimum dc bias of 6 V to the 1.4 V peak-to-peak ac voltage which is maximum within the linear displacement regime. The signal detectable range of the transmit and receive measurement with optimum dc bias tuning was 4 cm to 19 cm in air. [2017-0223]

[1]  M. Kupnik,et al.  50 kHz capacitive micromachined ultrasonic transducers for generation of highly directional sound with parametric arrays , 2009, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[2]  M. Sheplak,et al.  An AlN MEMS Piezoelectric Microphone for Aeroacoustic Applications , 2012, Journal of Microelectromechanical Systems.

[3]  P. Muralt,et al.  PZT thin films for microsensors and actuators: Where do we stand? , 2000, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[4]  A. Barzegar,et al.  Piezoelectric micromachined ultrasonic transducers based on PZT thin films , 2005, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[5]  Bernhard E. Boser,et al.  Broadband piezoelectric micromachined ultrasonic transducers based on dual resonance modes , 2015, 2015 28th IEEE International Conference on Micro Electro Mechanical Systems (MEMS).

[6]  S. Gevorgian,et al.  Ferroelectric thin films: Review of materials, properties, and applications , 2006 .

[7]  Martin Schoeppler,et al.  Three-dimensional micro electromechanical system piezoelectric ultrasound transducer , 2012 .

[8]  Richard J. Przybyla,et al.  Improved acoustic coupling of air-coupled micromachined ultrasonic transducers , 2014, 2014 IEEE 27th International Conference on Micro Electro Mechanical Systems (MEMS).

[9]  Bernhard E. Boser,et al.  3D Ultrasonic Rangefinder on a Chip , 2015, IEEE Journal of Solid-State Circuits.

[10]  Arthur W. Leissa,et al.  Vibration of Plates , 2021, Solid Acoustic Waves and Vibration.

[11]  Bernhard E. Boser,et al.  Pulse-Echo Ultrasound Imaging Using an AlN Piezoelectric Micromachined Ultrasonic Transducer Array With Transmit Beam-Forming , 2016, Journal of Microelectromechanical Systems.

[12]  Firas Sammoura,et al.  CMOS-compatible AlN piezoelectric micromachined ultrasonic transducers , 2009, 2009 IEEE International Ultrasonics Symposium.

[13]  Minchul Shin,et al.  Acoustic Doppler velocity measurement system using capacitive micromachined ultrasound transducer array technology. , 2013, The Journal of the Acoustical Society of America.

[14]  L. Sancheza.  Optimization of PbTiO 3 seed layers and Pt metallization for PZT-based piezoMEMS actuators , 2013 .

[15]  J. S. Pulskamp,et al.  Mechanical and Ferroelectric Behavior of PZT-Based Thin Films , 2011, Journal of Microelectromechanical Systems.

[16]  C. R. Hazell,et al.  A simple frequency formula for clamped rectangular plates , 1987 .

[17]  O. V. von Ramm,et al.  Theory and operation of 2-D array piezoelectric micromachined ultrasound transducers , 2008, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[18]  Yipeng Lu,et al.  Design, Fabrication, and Characterization of Scandium Aluminum Nitride-Based Piezoelectric Micromachined Ultrasonic Transducers , 2017, Journal of Microelectromechanical Systems.

[19]  F. Akasheh,et al.  Piezoelectric micromachined ultrasonic transducers: modeling the influence of structural parameters on device performance , 2005, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[20]  Z. Zeng,et al.  ELASTIC PROPERTIES OF TRANSITION METAL DIOXIDES: XO2 (X = Ru, Rh, Os, and Ir) , 2008, 0807.3251.

[21]  Kwan Kyu Park,et al.  Bandwidth and sensitivity optimization in CMUTs for airborne applications , 2014, 2014 IEEE International Ultrasonics Symposium.

[22]  A. Safari,et al.  Characterization of the effective electrostriction coefficients in ferroelectric thin films , 2001 .

[23]  Bernhard E. Boser,et al.  Ultrasonic fingerprint sensor using a piezoelectric micromachined ultrasonic transducer array integrated with complementary metal oxide semiconductor electronics , 2015 .

[24]  Madan Dubey,et al.  Stress analysis of SiO/sub 2//Ta/Pt/PZT/Pt stack for MEMS application , 2000, ISAF 2000. Proceedings of the 2000 12th IEEE International Symposium on Applications of Ferroelectrics (IEEE Cat. No.00CH37076).

[25]  D. Blackstock.  Fundamentals of Physical Acoustics , 2000 .

[26]  Madan Dubey,et al.  Mitigation of residual film stress deformation in multilayer microelectromechanical systems cantilever devices , 2003 .

[27]  Richard Przybyla,et al.  A micromechanical ultrasonic distance sensor with >1 meter range , 2011, 2011 16th International Solid-State Sensors, Actuators and Microsystems Conference.

[28]  Paul Muralt,et al.  Micromachined Ultrasonic Transducers and Acoustic Sensors Based on Piezoelectric Thin Films , 2004 .

[29]  B. Khuri-Yakub,et al.  Experimental evaluation of CMUTs with vented cavities under varying pressure , 2013, 2013 IEEE International Ultrasonics Symposium (IUS).

[30]  D. Horsley,et al.  Wideband air-coupled PZT piezoelectric micromachined ultrasonic transducer through DC bias tuning , 2017, 2017 IEEE 30th International Conference on Micro Electro Mechanical Systems (MEMS).

[31]  Richard J. Przybyla,et al.  In-Air Rangefinding With an AlN Piezoelectric Micromachined Ultrasound Transducer , 2011, IEEE Sensors Journal.

[32]  L. Lorenzelli,et al.  Mechanical characterization of thin TiO2 films by means of microelectromechanical systems-based cantilevers. , 2010, The Review of scientific instruments.

[33]  Pt/TiO 2 Growth Templates for Enhanced PZT films and MEMS Devices , 2011 .