Active Control of High Frequency Combustion Instability in Aircraft Gas-Turbine Engines

Abstract Active control of high-frequency (>500Hz) combustion instability has been demonstrated in the NASA single-nozzle combustor rig at United Technologies Research Center. The combustor rig emulates an actual engine instability and has many of the complexities of a real engine combustor (i.e. actual fuel nozzle and swirler, dilution cooling, etc.) In order to demonstrate control, a high-frequency fuel valve capable of modulating the fuel flow at up to 1kHz was developed. Characterization of the fuel delivery system was accomplished in a custom dynamic flow rig developed for that purpose. Two instability control methods, one model-based and one based on adaptive phase-shifting, were developed and evaluated against reduced order models and a Sectored-1-dimensional model of the combustor rig. Open-loop fuel modulation testing in the rig demonstrated sufficient fuel modulation authority to proceed with closed-loop testing. During closed-loop testing, both control methods were able to identify the instability from the background noise and were shown to reduce the pressure oscillations at the instability frequency by 30%. This is the first known successful demonstration of high-frequency combustion instability suppression in a realistic aero-engine environment. Future plans are to carry these technologies forward to demonstration on an advanced low-emissions combustor.

[1]  Airbreathing Missiles.  Active Combustion Control for Propulsion Systems ( AGARD R-820 ) Executive Summary , 2002 .

[2]  George Kopasakis,et al.  Adaptive Instability Suppression Controls in a Liquid-fueled Combustor , 2002 .

[3]  Daniel E. Paxson.  A Sectored-One-Dimensional Model for Simulating Combustion Instabilities in Premix Combustors , 2000 .

[4]  Jeffrey M. Cohen,et al.  Active control of combustion instability in a liquid-fueled low-NOx combustor , 1999 .

[5]  Changlie Wey,et al.  A Low NO(x) Lean-Direct Injection, Multipoint Integrated Module Combuster Concept for Advanced Aircraft Gas Turbines , 2002 .

[6]  Barry V Kiel,et al.  REVIEW OF ADVANCES IN COMBUSTION CONTROL, ACTUATION, SENSING, MODELING AND RELATED TECHNOLOGIES FOR AIR BREATHING GAS TURBINES , 2001 .

[7]  Jeffrey M. Cohen,et al.  Experimental Replication of an Aeroengine Combustion Instability , 2000 .

[8]  Jeffrey M. Cohen,et al.  Active Combustion Instability Control With Spinning Valve Actuator , 2003 .

[9]  Anuradha M. Annaswamy,et al.  Active control of combustion instability: theory and practice , 2002 .

[10]  John C. DeLaat,et al.  Control of Thermo-Acoustics Instabilities: The Multi-Scale Extended Kalman Approach , 2003 .

[11]  John Magill,et al.  Closed-loop system for stability control in gas turbine combustors , 1997 .

[12]  A. Lefebvre.  Gas Turbine Combustion , 1983 .

[13]  Daniel E. Paxson,et al.  Active Combustion Control for Aircraft Gas Turbine Engines , 2000 .

[14]  Ephraim Gutmark,et al.  Chapter 15 – CHARACTERISTICS AND CONTROL OF COMBUSTION INSTABILITIES IN A SWIRL-STABILIZED SPRAY COMBUSTOR , 1999 .

[15]  Clifford Johnson,et al.  Demonstration of Active Control of Combustion Instabilities on a Full-Scale Gas Turbine Combustor , 2001 .

[16]  Quang-Viet Nguyen.  Measurements of Equivalence Ratio Fluctuations in a Lean Premixed Prevaporized (LPP) Combustor and Its Correlation to Combustion Instability , 2002 .

[17]  Y. Neumeier,et al.  An overview of active control of combustion instabilities , 1997 .

[18]  Gary W. Hunter,et al.  An Overview of High-Temperature Electronics and Sensor Development at NASA Glenn Research Center , 2003 .

[19]  C. Smith,et al.  LES modeling of combustion dynamics in a liquid-fueled flametube combustor , 2000 .

[20]  George Kopasakis.  High Frequency Adaptive Instability Suppression Controls in a Liquid-Fueled Combustor , 2003 .