Thermal conductivity measurements of thin silicon dioxide films in integrated circuits

The thermal conductivity of thin silicon dioxide (SiO/sub 2/) films is measured using specialized test structures. The test structures consist of parallel plate-electrodes that sandwich the dielectric whose thermal conductivity is determined. The accuracy of the measurement technique is verified based on simulations. Films with thicknesses in the range of 0.57 /spl mu/m to 2.28 /spl mu/m are investigated. At room temperature the thin films exhibit a thermal conductivity of /spl sim/1.1 W/Km which is approximately 20% below that of bulk fused SiO/sub 2/. As opposed to prior studies, the thermal conductivity of the thin films is observed to increase with rising temperature. Temperature dependence of thermal conductivity is found to be very similar to that of bulk fused SiO/sub 2/. The impart of thermal resistances at boundaries between silicon dioxide and metallization is shown to be insignificant for the films investigated. In addition, no dependence of thermal conductivity on film thickness is observed. Vias are found to be very effective in reducing thermal resistance between adjacent metallization layers.

[1]  Chenming Hu,et al.  Effects of self-heating on integrated circuit metallization lifetimes , 1989, International Technical Digest on Electron Devices Meeting.

[2]  John C. Lambropoulos,et al.  Thermal conductivity of dielectric thin films , 1989 .

[3]  F. Brotzen,et al.  Thermal conductivity of thin SiO2 films , 1992 .

[4]  H. A. Schafft,et al.  Thermal conductivity measurements of thin-film silicon dioxide , 1989, Proceedings of the 1989 International Conference on Microelectronic Test Structures.

[5]  Y. Hayashi,et al.  A new three dimensional IC fabrication technology, stacking thin film DUAL-CMOS layers , 1991, International Electron Devices Meeting 1991 [Technical Digest].

[6]  L. T. Su,et al.  Annealing-temperature dependence of the thermal conductivity of LPCVD silicon-dioxide layers , 1993, IEEE Electron Device Letters.

[7]  J.H. Orchard-Webb.  A new structure for measuring the thermal conductivity of integrated circuit dielectrics , 1990, Proceedings of the 1991 International Conference on Microelectronic Test Structures.

[8]  M. Kleiner,et al.  Thermal analysis of vertically integrated circuits , 1995, Proceedings of International Electron Devices Meeting.

[9]  Kenneth E. Goodson,et al.  Measurement and modeling of self-heating in SOI nMOSFET's , 1994 .

[10]  Xiang Gui,et al.  Thermal simulation of thin-film interconnect failure caused by high current pulses , 1995 .

[11]  Krishna Shenai,et al.  Scaling constraints imposed by self-heating in submicron SOI MOSFET's , 1995 .