Laser beam induced current measurements of Cd1−xZnxS/CdTe solar cells

The role of the window layer in Cd1−xZnxS/CdTe photovoltaic (PV) device structures was investigated using a triple wavelength laser beam induced current (LBIC) technique. Full pn structures were deposited using metal organic chemical vapour deposition (MOCVD). The triple wavelength LBIC technique allowed for the diagnostic analysis of carrier collection uniformity at 3 wavelength dependent photon penetration depths, δp. An assessment of the Cd1−xZnxS window layer film thickness and surface coverage showed a correlation between lateral device performance and window layer thickness distribution. Islands of thick Cd1−xZnxS were shown to increase localised blue absorption, correlating to isolated regions of increased red and IR photoresponse. Overall device open-circuit voltage, Voc is shown to demonstrate a linear dependence on thick (∼300 nm) Cd1−xZnxS surface coverage. Voc and shunt resistance Rsh losses attributed to the window layer were found to jointly contribute to the overall cell efficiency losses. A non-uniform pin-hole distribution, leading to Rsh loss, was found to be independent of the overall Cd1−xZnxS thickness distribution; thus the triple wavelength LBIC measurement was able to identify causes for the observed losses in both Voc and Rsh.

[1]  James Keane,et al.  High-Efficiency CTO/ZTO/CdS/CdTe Polycrystalline Thin-Film Solar Cells: Preprint , 2001 .

[2]  K. Sankaranarayanan,et al.  TUNABILITY OF STRUCTURAL, SURFACE TEXTURE, COMPOSITIONAL AND OPTICAL PROPERTIES OF CdZnS THIN FILMS BY PHOTO ASSISTED- CHEMICAL BATH DEPOSITION TECHNIQUE. , 2009 .

[3]  Jie Zhou,et al.  CBD‐Cd1−xZnxS thin films and their application in CdTe solar cells , 2004 .

[4]  K. Durose,et al.  Characterisation of thin film CdS/CdTe solar cells using electron and optical beam induced current , 1999 .

[5]  William Brooks,et al.  High-resolution laser beam induced current measurements on Cd0.9Zn0.1S/ CdTe solar cells , 2011 .

[6]  K. Durose,et al.  Highly Arsenic Doped CdTe Layers for the Back Contacts of CdTe Solar Cells , 2007 .

[7]  K. Durose,et al.  EBIC and luminescence mapping of CdTe/CdS solar cells , 2000 .

[8]  Kea-Joon Yang,et al.  Characteristics of the CdZnS thin film doped by indium diffusion , 2002 .

[9]  H. Leamy,et al.  Charge collection scanning electron microscopy , 1982 .

[10]  J. Sites,et al.  LBIC analysis of thin-film polycrystalline solar cells , 2005, Conference Record of the Thirty-first IEEE Photovoltaic Specialists Conference, 2005..

[11]  K. Durose,et al.  A study of the effects of post‐deposition treatments on CdS/CdTe thin film solar cells using high resolution optical beam induced current , 1996 .

[12]  J. Sites,et al.  Impact of sheet resistance on 2-D modeling of thin-film solar cells , 2009 .

[13]  J. Marek,et al.  Light-beam-induced current characterization of grain boundaries , 1984 .

[14]  Vincent Barrioz,et al.  Towards ultra-thin CdTe solar cells using MOCVD , 2009 .

[15]  Chi-Jen Yang,et al.  Reconsidering solar grid parity , 2010 .

[16]  S. Guha,et al.  Molecular beam epitaxial growth of CdZnS using elemental sources , 1993 .

[17]  C. Ferekides,et al.  Transparent conductors and buffer layers for CdTe solar cells , 2005 .

[18]  S. Irvine,et al.  MOCVD of thin film photovoltaic solar cells—Next-generation production technology? , 2008 .

[19]  K. Durose,et al.  Study of buried junction and uniformity effects in CdTe/CdS solar cells using a combined OBIC and EQE apparatus , 2009 .

[20]  C. H. Seager,et al.  The determination of grain‐boundary recombination rates by scanned spot excitation methods , 1982 .

[21]  J. Sites,et al.  Effect of Shunts on Thin-Film CdTe Module Performance , 2009 .

[22]  J. Hiltner.  Investigation of spatial variations in collection efficiency of solar cells , 2001 .