Excimer laser and rapid thermal annealing stimulation of solid-phase nucleation and crystallization in amorphous silicon films on glass substrates

The solid-phase crystallization process in thin amorphous silicon films on glass substrates was studied with application of excimer laser annealing (ELA) and rapid thermal annealing (RTA) for stimulation of nucleation. Use of ELA allowed us to create homogeneous polycrystalline silicon films on glass with grain sizes up to at temperatures below C. Use of RTA reduced the incubation time of nucleation from 100 to 6 h. The textured silicon films on glass with predominant orientation (110) and sizes of textured areas up to were manufactured using excimer laser stimulation of nucleation. The influence of the mechanical stress mechanism on grain orientation was suggested, and it was theoretically shown that internal stresses retard the nucleation process. The addition of deformation to the chemical potential difference was estimated for nucleation in amorphous silicon as 11.4 meV per nucleated atom.

[1]  Raphael Tsu,et al.  Critical volume fraction of crystallinity for conductivity percolation in phosphorus‐doped Si:F:H alloys , 1982 .

[2]  James W. Mayer,et al.  Laser Annealing of Semiconductors , 1983 .

[3]  M. Hiramoto,et al.  Induction Time for Nucleation in Amorphous Silicon Films Prepared by Plasma CVD , 1988 .

[4]  S. Fonash,et al.  Selective area crystallization of amorphous silicon films by low-temperature rapid thermal annealing , 1989 .

[5]  D. Kashchiev.  Solution of the non-steady state problem in nucleation kinetics , 1969 .

[6]  Keiichi Yamamoto,et al.  Probing the Crystallinity of Evaporated Silicon Films by Raman Scattering , 1985 .

[7]  K. Fujimoto,et al.  In-Situ Chemically Cleaning Poly-Si Growth at Low Temperature , 1992 .

[8]  G. Wicker,et al.  Low-temperature polycrystalline-silicon TFT on 7059 glass , 1989, IEEE Electron Device Letters.

[9]  S. Tsuda,et al.  Improving the Uniformity of Poly-Si Films Using a New Excimer Laser Annealing Method for Giant-Microelectronics , 1992 .

[10]  T. Tsuruoka,et al.  Structural properties of polycrystalline silicon films prepared at low temperature by plasma chemical vapor deposition , 1991 .

[11]  P. Migliorato,et al.  High‐performance thin‐film transistors from optimized polycrystalline silicon films , 1987 .

[12]  M. Matsumura,et al.  Drastic Enlargement of Grain Size of Excimer-Laser-Crystallized Polysilicon Films , 1992 .

[13]  É. Bustarret,et al.  Experimental determination of the nanocrystalline volume fraction in silicon thin films from Raman spectroscopy , 1988 .

[14]  M. Furuta,et al.  Low-Temperature Polycrystalline Silicon Thin-Film Transistors for Large-Area Liquid Crystal Display , 1992 .

[15]  M. Balkanski,et al.  Effect of dimensions on the vibrational frequencies of thin slabs of silicon , 1980 .

[16]  H. Kawata,et al.  Enlargement of Poly-Si Film Grain Size by Excimer Laser Annealing and Its Application to High-Performance Poly-Si Thin Film Transistor , 1991 .

[17]  J. González-Hernández,et al.  Comparison of low temperature polysilicon crystal growth on low cost substrates , 1991 .

[18]  T. Sameshima,et al.  Pulsed laser‐induced amorphization of silicon films , 1991 .

[19]  Wei Zhang,et al.  Raman measurement of the grain size for silicon crystallites , 1990 .

[20]  J. E. Smith,et al.  Vibrational properties of amorphous Si and Ge , 1975 .

[21]  S. Stiffler,et al.  Interfacial transport kinetics during the solidification of silicon , 1992 .

[22]  Beeman,et al.  Structural information from the Raman spectrum of amorphous silicon. , 1985, Physical review. B, Condensed matter.

[23]  D. Oxtoby.  Homogeneous nucleation: theory and experiment , 1992 .

[24]  J. Seinfeld,et al.  Transient kinetics of nucleation and crystallization: Part I. Nucleation , 1991 .

[25]  Y. Hishikawa.  Raman study on the variation of the silicon network of a‐Si:H , 1987 .