An Optical Fiber Viscometer Based on Long-Period Fiber Grating Technology and Capillary Tube Mechanism

This work addresses the development and assessment of a fiber optical viscometer using a simple and low-cost long-period fiber grating (LPFG) level sensor and a capillary tube mechanism. Previous studies of optical viscosity sensors were conducted by using different optical sensing methods. The proposed optical viscometer consists of an LPFG sensor, a temperature-controlled chamber, and a cone-shaped reservoir where gravitational force could cause fluid to flow through the capillary tube. We focused on the use of LPFGs as level sensors and the wavelength shifts were not used to quantify the viscosity values of asphalt binders. When the LPFG sensor was immersed in the constant volume (100 mL) AC-20 asphalt binder, a wavelength shift was observed and acquired using LabVIEW software and GPIB controller. The time spent between empty and 100 mL was calculated to determine the discharge time. We simultaneously measured the LPFG-induced discharge time and the transmission spectra both in hot air and AC-20 asphalt binder at five different temperatures, 60, 80, 100, 135, and 170 Celsius. An electromechanical rotational viscometer was also used to measure the viscosities, 0.15–213.80 Pa·s, of the same asphalt binder at the above five temperatures. A non-linear regression analysis was performed to convert LPFG-induced discharge time into viscosities. Comparative analysis shows that the LPFG-induced discharge time agreed well with the viscosities obtained from the rotational viscometer.

[1]  L H Tanner.  The measurement of viscosity by optical techniques applied to a falling liquid film , 1976 .

[2]  L H Tanner.  Two accurate optical methods for Newtonian viscosity measurement, and observations on a surface effect with silicon oil , 1977 .

[3]  R J Mazza,et al.  The use of fibre optics in viscometry , 1984 .

[4]  Wei Chih Wang,et al.  Optical viscosity sensor using forward light scattering , 1995 .

[5]  J. Judkins,et al.  Long-period fiber gratings as band-rejection filters , 1995 .

[6]  A. Vengsarkar,et al.  Optical fiber long-period grating sensors. , 1996, Optics letters.

[7]  N. S. Bergano,et al.  Long-period fiber-grating-based gain equalizers. , 1996, Optics letters.

[8]  R O Claus,et al.  Simultaneous strain and temperature measurement with long-period gratings. , 1997, Optics letters.

[9]  S. B. Lee,et al.  Displacements of the resonant peaks of a long-period fiber grating induced by a change of ambient refractive index. , 1997, Optics letters.

[10]  R. Claus,et al.  Temperature-insensitive and strain-insensitive long-period grating sensors for smart structures , 1997 .

[11]  Noel Zabaronick,et al.  Temperature-insensitive long-period gratings for strain and refractive index sensing , 1997, Smart Structures.

[12]  Eric Udd,et al.  Advanced fiber-grating strain sensor systems for bridges, structures, and highways , 1998, Smart Structures.

[13]  Alan D. Kersey,et al.  Analysis of the response of long period fiber gratings to external index of refraction , 1998 .

[14]  T. Erdogan,et al.  Leaky cladding mode propagation in long-period fiber grating devices , 1999, IEEE Photonics Technology Letters.

[15]  V. Bhatia.  Applications of long-period gratings to single and multi-parameter sensing. , 1999, Optics express.

[16]  Wei Chih Wang,et al.  Fluid viscosity measurement using forward light scattering , 1999 .

[17]  Ian Bennion,et al.  Detection of organic aromatic compounds in paraffin by a long-period fiber grating optical sensor with optimized sensitivity , 2001 .

[18]  Craig A. Grimes,et al.  Measurement of temperature and liquid viscosity using wireless magneto-acoustic/magneto-optical sensors , 2001 .

[19]  Chiara F. Ferraris,et al.  Guide to Rheological Nomenclature: Measurements in Ceramic Particulate Systems , 2001 .

[20]  Zabih Ghassemlooy,et al.  Modelling of long-period fibre grating response to refractive index higher than that of cladding , 2001 .

[21]  S. James,et al.  Optical fibre long-period grating sensors: characteristics and application , 2003 .

[22]  Sabato Fusco,et al.  Viscosity measurements on micron-size scale using optical tweezers , 2005 .

[23]  Derek A. Fischer,et al.  Optical fiber-based fluorescent viscosity sensor. , 2006, Optics letters.

[24]  Y. Nagasaka,et al.  Miniaturized Optical Viscosity Sensor based on a Laser-induced Capillary Wave , 2007, 2007 IEEE/LEOS International Conference on Optical MEMS and Nanophotonics.

[25]  Jian-Neng Wang,et al.  Measurement of chloride-ion concentration with long-period grating technology , 2007 .

[26]  C. E. Maneschy,et al.  The carreau-yasuda fluids: a skin friction equation for turbulent flow in pipes and kolmogorov dissipative scales , 2007 .

[27]  Wei Chih Wang,et al.  Optical viscosity sensor based on the partially immersed fiber vibrations , 2008, SPIE Smart Structures and Materials + Nondestructive Evaluation and Health Monitoring.

[28]  Yoshihiro Taguchi,et al.  Novel optical viscosity sensor based on laser-induced capillary wave , 2008, SPIE MOEMS-MEMS.

[29]  Jaw-Luen Tang,et al.  Chemical Sensing Sensitivity of Long-Period Grating Sensor Enhanced by Colloidal Gold Nanoparticles , 2008, Sensors.

[30]  Joachim Kohlbrecher,et al.  SANS and dynamic light scattering to investigate the viscosity of toluene under high pressure up to 1800 bar , 2008 .

[31]  Per G. Reinhall,et al.  Optical viscosity sensor using bend loss of fiber , 2008, SPIE Smart Structures and Materials + Nondestructive Evaluation and Health Monitoring.

[32]  Jyh-Dong Lin,et al.  Development of viscosity sensor with long period fiber grating technology , 2009, Smart Structures and Materials + Nondestructive Evaluation and Health Monitoring.

[33]  Yoshihiro Taguchi,et al.  Micro Optical Viscosity Sensor for in situ Measurement Based on a Laser-Induced Capillary Wave , 2009 .

[34]  Wei Chih Wang,et al.  Optical viscosity sensor , 2009, Smart Structures and Materials + Nondestructive Evaluation and Health Monitoring.