Macroalgae supercritical water gasification combined with nutrient recycling for microalgae cultivation

The composition of syngas and process water from the supercritical water gasification of macroalgae has been investigated. The potential for using the process water as a source of nutrients for microalgae cultivation was assessed. Saccharina latissima, harvested across the four seasons was gasified in a batch reactor at 500°C and 36 MPa to assess the influence of biochemical content and ash on syngas composition. In addition, summer harvests of four different macroalga were gasified with ruthenium catalyst (Ru/Al2O3). The molar yields of hydrogen and C1‐C4 gases from S. latissima increased by 30% in the presence of Ru/Al2O3 with a maximum gasification efficiency of 92% compared with work without these catalysts. Following a series of dilutions, the process water from catalyzed gasification of S. latissima was used in cultivation trials of Chlorella vulgaris and compared to standard growth media. The results indicate the potential to recover process waters from gasification of macroalgae in nutrient management for microalgae. © 2013 American Institute of Chemical Engineers Environ Prog, 32: 902–909, 2013

[1]  Paul T. Williams,et al.  Hydrogen and methane selectivity during alkaline supercritical water gasification of biomass with ruthenium-alumina catalyst , 2013 .

[2]  Paul T. Williams,et al.  Catalytic hydrothermal gasification of algae for hydrogen production: composition of reaction products and potential for nutrient recycling. , 2013, Bioresource technology.

[3]  Andrew B. Ross,et al.  Hydrothermal processing of algal biomass for the production of biofuels and chemicals , 2012 .

[4]  P. Savage,et al.  Hydrothermal Gasification of Nannochloropsis sp. with Ru/C , 2012 .

[5]  Amanda Lea-Langton,et al.  Nutrient recycling of aqueous phase for microalgae cultivation from the hydrothermal liquefaction process , 2012 .

[6]  Phillip E. Savage,et al.  Gasification of alga Nannochloropsis sp. in supercritical water , 2012 .

[7]  Manjinder Singh,et al.  Renewable biomass production by mixotrophic algae in the presence of various carbon sources and wastewaters , 2011 .

[8]  J. Yanik,et al.  Hydrothermal conversion of seaweeds in a batch autoclave , 2011 .

[9]  Senthil Chinnasamy,et al.  Evaluation of microalgae cultivation using recovered aqueous co-product from thermochemical liquefaction of algal biomass. , 2011, Bioresource technology.

[10]  Phillip E. Savage,et al.  Hydrothermal Liquefaction of a Microalga with Heterogeneous Catalysts , 2011 .

[11]  Jenny M. Jones,et al.  Seasonal variation in the chemical composition of the bioenergy feedstock Laminaria digitata for thermochemical conversion. , 2011, Bioresource technology.

[12]  Paul T. Williams,et al.  Hydrothermal reactions of sodium formate and sodium acetate as model intermediate products of the sodium hydroxide-promoted hydrothermal gasification of biomass , 2010 .

[13]  Paul T. Williams,et al.  Reaction products from the subcritical water gasification of food wastes and glucose with NaOH and H2O2. , 2010, Bioresource technology.

[14]  Phillip E. Savage,et al.  Biodiesel Production from Wet Algal Biomass through in Situ Lipid Hydrolysis and Supercritical Transesterification , 2010 .

[15]  H. Ted Davis,et al.  Hydrothermal carbonization of microalgae , 2010 .

[16]  Phillip E. Savage,et al.  Hydrothermal Liquefaction and Gasification of Nannochloropsis sp. , 2010 .

[17]  Derk Willem Frederik Brilman,et al.  Catalytic and Non-catalytic Supercritical Water Gasification of Microalgae and Glycerol , 2010 .

[18]  Paul T. Williams,et al.  Role of sodium hydroxide in the production of hydrogen gas from the hydrothermal gasification of biomass , 2009 .

[19]  A. Darzins,et al.  The promise and challenges of microalgal‐derived biofuels , 2009 .

[20]  Frédéric Vogel,et al.  Catalytic gasification of algae in supercritical water for biofuel production and carbon capture , 2009 .

[21]  Frédéric Vogel,et al.  SunCHem: an integrated process for the hydrothermal production of methane from microalgae and CO2 mitigation , 2009, Journal of Applied Phycology.

[22]  A. Kruse,et al.  Char and Coke Formation as Unwanted Side Reaction of the Hydrothermal Biomass Gasification , 2008 .

[23]  Andrea Kruse,et al.  Supercritical water gasification , 2008 .

[24]  T. Bridgeman,et al.  Classification of macroalgae as fuel and its thermochemical behaviour. , 2008, Bioresource technology.

[25]  J. Grobbelaar.  Algal nutrition: mineral nutrition. , 2007 .

[26]  F. Krumeich,et al.  Synthetic natural gas by hydrothermal gasification of biomass: Selection procedure towards a stable catalyst and its sodium sulfate tolerance , 2007 .

[27]  Frédéric Vogel,et al.  Synthetic natural gas from biomass by catalytic conversion in supercritical water , 2007 .

[28]  K. Pant,et al.  Hydrogen Production from Glucose Using Ru/Al2O3 Catalyst in Supercritical Water , 2007 .

[29]  M. Shirai,et al.  Effect of Sulfur on Catalytic Gasification of Lignin in Supercritical Water , 2007 .

[30]  M. Shirai,et al.  Stability of Supported Ruthenium Catalysts for Lignin Gasification in Supercritical Water , 2006 .

[31]  A. Scragg.  The effect of phenol on the growth of Chlorella vulgaris and Chlorella VT-1 , 2006 .

[32]  Paul T. Williams,et al.  Subcritical and Supercritical Water Gasification of Cellulose, Starch, Glucose, and Biomass Waste , 2006 .

[33]  M. Shirai,et al.  CATALYTIC GASIFICATION OF WOOD BIOMASS IN SUBCRITICAL AND SUPERCRITICAL WATER , 2006 .

[34]  Phang Siew Moi,et al.  Handbook of Microalgal Culture. Biotechnology and Applied Phycology , 2004, Journal of Applied Phycology.

[35]  Karla J. McDermid,et al.  Nutritional composition of edible Hawaiian seaweeds , 2003, Journal of Applied Phycology.

[36]  A. Kruse,et al.  Key Compounds of the Hydropyrolysis of Glucose in Supercritical Water in the Presence of K2CO3 , 2003 .

[37]  P. Rupérez,et al.  Mineral content of edible marine seaweeds , 2002 .

[38]  M. Hosomi,et al.  Algal growth inhibition effects and inducement modes by plant-producing phenols. , 2001, Water research.

[39]  T. Minowa,et al.  A novel microalgal system for energy production with nitrogen cycling , 1999 .

[40]  N. Lindley,et al.  Growth of Ralstonia eutropha on inhibitory concentrations of phenol: diminished growth can be attributed to hydrophobic perturbation of phenol hydroxylase activity , 1999 .

[41]  Phillip E. Savage,et al.  Organic Chemical Reactions in Supercritical Water. , 1999, Chemical reviews.

[42]  Eddie G. Baker,et al.  Chemical processing in high-pressure aqueous environments. 2. Development of catalysts for gasification , 1993 .

[43]  D. Spencer,et al.  Free nickel ion inhibits growth of two species of green algae , 1983 .