Membrane distillation combined with an anaerobic moving bed biofilm reactor for treating municipal wastewater.

A fermentative strategy with an anaerobic moving bed biofilm reactor (AMBBR) was used for the treatment of domestic wastewater. The feasibility of using a membrane separation technique for post-treatment of anaerobic bio-effluent was evaluated with emphasis on employing a membrane distillation (MD). Three different hydrophobic 0.2 μm membranes made of polytetrafluoroethylene (PTFE), polyvinylidene fluoride (PVDF), and polypropylene (PP) were examined in this study. The initial permeate flux of the membranes ranged from 2.5 to 6.3 L m(-2) h(-1) when treating AMBBR effluent at a temperature difference between the feed and permeate streams of 20 °C, with the permeate flux increasing in the order PP < PVDF < PTFE. The permeate flux of the PTFE membrane gradually decreased to 84% of the initial flux after the 45 h run for distillation, while a flux decline in MD with either the PVDF or PP membrane was not found under the identical distillation conditions. During long-term distillation with the PVDF membrane, total phosphorus was completely rejected and >98% rejection of dissolved organic carbon was also achieved. The characterization of wastewater effluent organic matter (EfOM) using an innovative suite of analytical tools verified that almost all of the EfOM was rejected via the PVDF MD treatment.

[1]  Anthony G. Fane,et al.  Heat and mass transfer in membrane distillation , 1987 .

[2]  W. Pronk,et al.  Characterisation of aquatic humic and non-humic matter with size-exclusion chromatography--organic carbon detection--organic nitrogen detection (LC-OCD-OND). , 2011, Water research.

[3]  Rosalam Sarbatly,et al.  Vacuum membrane distillation processes for aqueous solution treatment—A review , 2013 .

[4]  N. Hilal,et al.  Membrane distillation: A comprehensive review , 2012 .

[5]  Hyun-Chul Kim,et al.  Characterization of natural organic matter in conventional water treatment processes for selection of treatment processes focused on DBPs control. , 2005, Water research.

[6]  Jun-de Li,et al.  Performance of asymmetric hollow fibre membranes in membrane distillation under various configurations and vacuum enhancement , 2010 .

[7]  Noam Lior,et al.  Membrane-distillation desalination: Status and potential , 2005 .

[8]  David C. Stuckey,et al.  Treatment of Dilute Wastewaters Using a Novel Submerged Anaerobic Membrane Bioreactor , 2006 .

[9]  Hyun-Chul Kim,et al.  Pump diffusion flash mixing (PDFM) for improving coagulation process in drinking water treatment , 2006 .

[10]  E. Drioli,et al.  Recent advances on membrane processes for the concentration of fruit juices: a review , 2004 .

[11]  Jack Gilron,et al.  Direct Contact Membrane Distillation-Based Desalination: Novel Membranes, Devices, Larger-Scale Studies, and a Model , 2007 .

[12]  Mark R. Wiesner,et al.  Surface modification of nanostructured ceramic membranes for direct contact membrane distillation , 2009 .

[13]  Giulio C. Sarti,et al.  Concentration of must through vacuum membrane distillation , 2002 .

[14]  Raja Ben Amar,et al.  Modification of Tunisian clay membrane surface by silane grafting: Application for desalination with Air Gap Membrane Distillation process , 2011 .

[15]  P. Czermak,et al.  Theoretical and experimental approaches of liquid entry pressure determination in membrane distillation processes , 2014 .

[16]  Jaeho Bae,et al.  Anaerobic fluidized bed membrane bioreactor for wastewater treatment. , 2011, Environmental science & technology.

[17]  Wojciech Kujawski,et al.  Comparison of various membrane distillation methods for desalination using hydrophobic ceramic membranes , 2009 .

[18]  Fenglin Yang,et al.  Anaerobic treatment of domestic wastewater in a membrane-coupled expended granular sludge bed (EGSB) reactor under moderate to low temperature , 2005 .

[19]  Mohamed Khayet Souhaimi.  Membrane Distillation: Principles and Applications , 2011 .

[20]  T. Matsuura,et al.  Development of novel surface modified phase inversion membranes having hydrophobic surface-modifying macromolecule (nSMM) for vacuum membrane distillation , 2010 .

[21]  Jun-de Li,et al.  Identification of material and physical features of membrane distillation membranes for high performance desalination , 2010 .

[22]  F. J. Florido-Díaz,et al.  Theoretical and experimental studies on desalination using membrane distillation , 2001 .

[23]  R. Shishoo,et al.  Surface properties of polymers treated with tetrafluoromethane plasma , 1997 .

[24]  R. A. Ashworth,et al.  Removal of volatile organic compounds from groundwater using a rotary air stripper , 1992 .

[25]  S. T. Hsu,et al.  Seawater desalination by direct contact membrane distillation , 2002 .

[26]  Marek Gryta,et al.  Wastewater treatment by membrane distillation , 2006 .

[27]  Marek Gryta,et al.  Heat transport in the membrane distillation process , 1998 .

[28]  Mohamed Khayet,et al.  Theory and experiments on sweeping gas membrane distillation , 2000 .

[29]  Niall Finn,et al.  Characterization and evaluation of carbon nanotube Bucky-Paper membranes for direct contact membrane distillation , 2010 .

[30]  H. Ng,et al.  Feasibility of submerged anaerobic membrane bioreactor (SAMBR) for treatment of low-strength wastewater. , 2008, Water science and technology : a journal of the International Association on Water Pollution Research.

[31]  E. Drioli,et al.  Membrane Distillation and Related Operations—A Review , 2005 .

[32]  Takeshi Matsuura,et al.  Synthesis of a new type of surface modifying macromolecules (nSMM) and characterization and testing of nSMM blended membranes for membrane distillation , 2006 .

[33]  Gary D. Hopkins,et al.  Evaluating two-resistance models for air stripping of volatile organic contaminants in a countercurrent, packed column , 1985 .

[34]  Marcel Mulder,et al.  Basic Principles of Membrane Technology , 1991 .