An efficient signal conditioning circuit to piecewise linearizing the response characteristic of highly nonlinear sensors

Abstract To obtain the solutions to the problem of linearization of the sensor characteristics is a matter of investigations for a long time. This paper presents a new and simple piecewise linearizing circuit to compensate the nonlinearity of highly nonlinear sensor. It is having a mixed signal conditioning circuit, employing a 2-bit flash ADC, a ( 4 × 1 ) multiplexer and the Op amp-based signal conditioning units. The circuit was initially simulated using SPICE software and then hardware implemented for linearizing the nonlinear response characteristic of two sensors. One of the sensors is a graphene oxide capacitive humidity sensor with nearly 46% nonlinearity and the other is a thermistor-based temperature sensor with 16.4 % nonlinearity. The humidity sensor is fabricated and characterized to measure humidity in the range of 2–85% RH. The maximum nonlinearity of the humidity and temperature sensors of the hardware implemented circuit after compensation was 1% and 1.5 % respectively. The circuit is simple and requires few hardware components for implementation and applicable for any nonlinear sensor. The circuit is CMOS compatible for ASIC implementation.

[1]  Hamit Erdem.  Implementation of software-based sensor linearization algorithms on low-cost microcontrollers. , 2010, ISA transactions.

[2]  D Patranabis,et al.  Linearization of transducers through a generalized software technique , 1991 .

[3]  Jafar Ghaisari,et al.  Intelligent Selection of Calibration Points Using a Modified Progressive Polynomial Method , 2012, IEEE Transactions on Instrumentation and Measurement.

[4]  L. Bengtsson,et al.  Lookup Table Optimization for Sensor Linearization in Small Embedded Systems , 2012 .

[5]  Vaegae Naveen Kumar,et al.  Development of thermistor signal conditioning circuit using artificial neural networks , 2015 .

[6]  Subhas Chandra Mukhopadhyay,et al.  Smart Sensors and Internet of Things: A Postgraduate Paper , 2017, IEEE Sensors Journal.

[7]  Giovanni Bucci,et al.  New ADC with piecewise linear characteristic: case study-implementation of a smart humidity sensor , 2000, IEEE Trans. Instrum. Meas..

[8]  Bogdan M. Wilamowski,et al.  Compensation of Nonlinearities Using Neural Networks Implemented on Inexpensive Microcontrollers , 2011, IEEE Transactions on Industrial Electronics.

[9]  Debangshu Dey,et al.  A Linearization Scheme for Thermistor-Based Sensing in Biomedical Studies , 2016, IEEE Sensors Journal.

[10]  Goutam Chakraborty,et al.  Development of Laguerre Neural-Network-Based Intelligent Sensors for Wireless Sensor Networks , 2011, IEEE Transactions on Instrumentation and Measurement.

[11]  Curtis D. Johnson,et al.  Process Control Instrumentation Technology , 1977 .

[12]  Daniele Marioli,et al.  Application of an optimal look-up table to sensor data processing , 1999, IEEE Trans. Instrum. Meas..

[13]  S. Mukhopadhyay,et al.  Graphene and its sensor-based applications: A review , 2018 .

[14]  Tarikul Islam.  Advanced Interfacing Techniques for the Capacitive Sensors , 2017 .

[15]  Hiranmay Saha,et al.  Study of long-term drift of a porous silicon humidity sensor and its compensation using ANN technique , 2007 .

[16]  Durlav Sonowal,et al.  Linearizing thermistor characteristics by piecewise linear interpolation in real time FPGA , 2013, 2013 International Conference on Advances in Computing, Communications and Informatics (ICACCI).

[17]  V. Pathirana,et al.  Experimental, analytical and numerical investigation of non-linearity of SOI diode temperature sensors at extreme temperatures , 2015 .

[18]  V. Jagadeesh Kumar,et al.  Linearizing Dual-Slope Digital Converter Suitable for a Thermistor , 2010, IEEE Transactions on Instrumentation and Measurement.

[19]  Ferran Reverter,et al.  Direct interface circuit to linearise resistive sensor bridges , 2008 .

[20]  Jijun Xiong,et al.  Wireless flexible pressure sensor based on micro-patterned Graphene/PDMS composite , 2018, Sensors and Actuators A: Physical.

[21]  Tae Bong Eom,et al.  A digital signal processing module for real-time compensation of nonlinearity in a homodyne interferometer using a field-programmable gate array , 2009 .

[22]  K. Sengupta,et al.  A Medium-Range Hygrometer Using Nano-Porous Thin Film of $\gamma $ -$\hbox{Al}_{2} \hbox{O} _{3}$ With Electronics Phase Detection , 2012, IEEE Sensors Journal.

[23]  Pardeep Kumar,et al.  E-SAP: Efficient-Strong Authentication Protocol for Healthcare Applications Using Wireless Medical Sensor Networks , 2012, Sensors.

[24]  Xiangdong Chen,et al.  Humidity sensing behaviors of graphene oxide-silicon bi-layer flexible structure , 2012 .

[25]  P. Sankaran,et al.  A new compensation scheme for thermistors and its implementation for response linearization over a wide temperature range , 1993 .

[26]  R. Pallas-Areny,et al.  Optimal two-point static calibration of measurement systems with quadratic response , 2004, Proceedings of the 21st IEEE Instrumentation and Measurement Technology Conference (IEEE Cat. No.04CH37510).

[27]  Xuan Li,et al.  Precise and robust position estimation for optical incremental encoders using a linearization technique , 2015 .

[28]  Boby George,et al.  A Linearizing Digitizer for Differential Sensors With Polynomial Characteristics , 2014, IEEE Transactions on Instrumentation and Measurement.

[29]  Debangshu Dey,et al.  Linearization of NTC Thermistor Characteristic Using Op-Amp Based Inverting Amplifier , 2013, IEEE Sensors Journal.

[30]  Jinwei Sun,et al.  Free knot recursive B-spline for compensation of nonlinear smart sensors , 2011 .

[31]  O. Postolache,et al.  Adaptive Self-Calibration Algorithm for Smart Sensors Linearization , 2005, 2005 IEEE Instrumentationand Measurement Technology Conference Proceedings.

[32]  Toshko G. Nenov,et al.  Linearization Circuit of the Thermistor Connection , 2009, IEEE Transactions on Instrumentation and Measurement.

[33]  Debdulal Saha,et al.  Implementation of linear trace moisture sensor by nano porous thin film moisture sensor and NLAmp , 2008 .

[34]  Octavian Postolache,et al.  A Digitally Programmable A/D Converter for Smart Sensors Applications , 2007, IEEE Transactions on Instrumentation and Measurement.

[35]  Boby George,et al.  A Linearizing Digitizer for Wheatstone Bridge Based Signal Conditioning of Resistive Sensors , 2017, IEEE Sensors Journal.